Research Article
BibTex RIS Cite

Production and Characterization of PAN/Zeolite Based Nanofibers

Year 2020, Volume: 7 Issue: 3, 1101 - 1109, 30.09.2020

Funda Cengiz Çallıoğlu Hülya Kesici Güler

https://doi.org/10.31202/ecjse.709403

Abstract

In this study, it was aimed to achieve production and characterization of polyacrylonitrile (PAN)/zeolite nanofibers via electrospinning method. Firstly, polymer solutions were prepared with various concentrations of zeolite. Then, solution properties were determined such as; viscosity, conductivity and surface tension. Nanofiber production was carried out with electrospinning under the optimum process parameters (voltage, distance between the electrodes, feed rate and atmospheric conditions). Lastly, nanofibers were morphologically characterized with SEM-EDS. According to the results; solution viscosity and surface tension increased while conductivity decreased with zeolite concentration increasement. Also, during the spinning process, it was observed that spinning performance decreased and average fiber diameter increased dramatically with zeolite concentration especially for 10 wt % PAN/10 wt % zeolite. Moreover, zeolite particles held on to the nanofibrous structure successfully even at minimum and maximum concentration.

Keywords

Polyacrylonitrile Zeolite Ionorganic Nanofiber Electrospinning

Thanks

The authors would like to express their deepest appreciation to organizing committee of TICMET19 in the selection of our study which was presented in the conference organized on 10-12 October, 2019 in Gaziantep University.

References

  • [1] Agarwal, S. R., Subramanian, S. Seeram, R., “Functionalized cellulose:PET polymer fibers with zeolites for detoxification against nerve agents”, J Inorg Mater., 2012, 27(3):332-336.
  • [2] Bilgin, Ö., Koç, E., “Doğal zeolitlerin çevre kirliliği kontrolünde kullanımı”, Türk Bilimsel Derlemeler Dergisi, 2013, 6(1):169-174.
  • [3] Faghihian, H., Iravani, M., Moayed, M., Ghannadi-Maragheh, M., “A novel polyacrylonitrile-zeolite nanocomposite to clean Cs and Sr from radioactive waste”, Environ. Chem. Lett., 2013, 11(3):277-282.
  • [4] Moattar, F., Hayeripour, S., “Application of chitin and zeolite adsorbents for treatment of low level radioactive liquid wastes”, IJEST, 2004, 1(1):45-50.
  • [5] Namekawa, K., Schreiber, M. T., Aoyagi, T., Ebara, M., “Fabrication of zeolite-polymer composite nanofibers for removal of uremic toxins from kidney patients”, Biomater. Sci., 2013, 2(5):674-679.
  • [6] Nawawi, M. S., Ahmad, M. R., Affandi, N. D. N, Sekak, K. A., Ahmad, W. Y. W., “Effect of zeolite presence and voltage variance on the fiber diameter of microporous PVA/zeolite nanofibrous membrane”, IEEE Business Engineering and Industrial Applications Colloquium (BEIAC), 2013, 344-348.
  • [7] Anis, S. F., & Hashaikeh, R., “Electrospun zeolite-Y fibers: fabrication and morphology analysis”, Microporous Mesoporous Mater., 2016, 233, 78-86.
  • [8] Kim, H. G., Kim, J. H., “Preparation and properties of antibacterial poly (vinyl alcohol) nanofibers by nanoparticles”, Fibers and Polymers, 2011, 12(5), 602.
  • [9] Bhardwaj, N., Kundu, S.C., “Electrospinning: a fascinating fiber fabrication technique”, Biotechnol. Adv., 2010, 28(3):325–347.
  • [10] Haghi, A. K., “Advances in Nanofibre Research”, Smithers Rapra, Shawbury, Shrewsbury, Shropshire, United Kingdom, 2011.
  • [11] He, J. H., Liu, Y., Mo, L. F., Wan, Y. Q., Xu, L., “Electrospun nanofibres and their applications”, ISmithers, Shawbury, UK, 2008.
  • [12] Chen, M., Wang, C., Fang, W., Wang, J., Zhang, W., Jin, G., Diao, G., “Electrospinning of calixarene-functionalized polyacrylonitrile nanofiber membranes and application as an adsorbent and catalyst support”, Langmuir, 2013, 29(38):11858-11867.
  • [13] Lu, L., Samarasekera, C., Yeow, J. T., “Creatinine adsorption capacity of electrospun polyacrylonitrile (PAN)‐zeolite nanofiber membranes for potential artificial kidney applications”, J. Appl. Polym., 2015, 132(34).
  • [14] Kang, D. H., Kang, H. W., “Surface energy characteristics of zeolite embedded PVDF nanofiber films with electrospinning process”, Appl. Surf., 2016, 387:82-88.
  • [15] Rad, L. R., Momeni, A., Ghazani, B. F., Irani, M., Mahmoudi, M., Noghreh, B., “Removal of Ni2+ and Cd2+ ions from aqueous solutions using electrospun PVA/zeolite nanofibrous adsorbent”, Chem. Eng, 2014, 256:119-127.
  • [16] Cengiz, F., Jirsak, O., “The effect of salt on the roller electrospinning of polyurethane nanofibers”, Fibers and Polymers, 2009, 10(2):177-184.

PAN/Zeolit Esaslı Nanoliflerin Üretimi ve Karakterizasyonu

Year 2020, Volume: 7 Issue: 3, 1101 - 1109, 30.09.2020

Funda Cengiz Çallıoğlu Hülya Kesici Güler

https://doi.org/10.31202/ecjse.709403

Abstract

Bu çalışmada, poliakrilonitril (PAN)/zeolit nanoliflerin elektro lif çekim yöntemi ile üretimi ve karakterizasyonunun gerçekleştirilmesi amaçlanmıştır. İlk olarak, farklı zeolit konsantrasyonlarında polimer çözeltileri hazırlanmıştır. Daha sonra, viskozite, iletkenlik ve yüzey gerilimi gibi çözelti özellikleri belirlenmiştir. Nanolif üretimi optimum proses parametreleri (voltaj, elektrotlar arası mesafe, besleme hızı ve atmosferik koşullar) altında elektro lif çekim yöntemi ile gerçekleştirilmiştir. Son olarak, nanolifler SEM-EDS ile morfolojik olarak karakterize edilmiştir. Sonuçlara göre; zeolit konsantrasyonu artışı ile iletkenlik azalırken çözelti viskozitesi ve yüzey gerilimi artmıştır. Ayrıca, lif çekim prosesi boyunca, zeolit konsantrasyonu artışı ile lif çekim performansının azaldığı ve ortalama lif çapının özellikle %10 PAN/%10 zeolit için önemli ölçüde arttığı gözlemlenmiştir. Dahası, zeolit partikülleri maksimum ve minimum konsantrasyonda bile nanolifli yapıya başarıyla tutunmuşlardır.

Keywords

Poliakrilonitril Zeolit İnorganik Nanolif Elektro lif çekimi

References

  • [1] Agarwal, S. R., Subramanian, S. Seeram, R., “Functionalized cellulose:PET polymer fibers with zeolites for detoxification against nerve agents”, J Inorg Mater., 2012, 27(3):332-336.
  • [2] Bilgin, Ö., Koç, E., “Doğal zeolitlerin çevre kirliliği kontrolünde kullanımı”, Türk Bilimsel Derlemeler Dergisi, 2013, 6(1):169-174.
  • [3] Faghihian, H., Iravani, M., Moayed, M., Ghannadi-Maragheh, M., “A novel polyacrylonitrile-zeolite nanocomposite to clean Cs and Sr from radioactive waste”, Environ. Chem. Lett., 2013, 11(3):277-282.
  • [4] Moattar, F., Hayeripour, S., “Application of chitin and zeolite adsorbents for treatment of low level radioactive liquid wastes”, IJEST, 2004, 1(1):45-50.
  • [5] Namekawa, K., Schreiber, M. T., Aoyagi, T., Ebara, M., “Fabrication of zeolite-polymer composite nanofibers for removal of uremic toxins from kidney patients”, Biomater. Sci., 2013, 2(5):674-679.
  • [6] Nawawi, M. S., Ahmad, M. R., Affandi, N. D. N, Sekak, K. A., Ahmad, W. Y. W., “Effect of zeolite presence and voltage variance on the fiber diameter of microporous PVA/zeolite nanofibrous membrane”, IEEE Business Engineering and Industrial Applications Colloquium (BEIAC), 2013, 344-348.
  • [7] Anis, S. F., & Hashaikeh, R., “Electrospun zeolite-Y fibers: fabrication and morphology analysis”, Microporous Mesoporous Mater., 2016, 233, 78-86.
  • [8] Kim, H. G., Kim, J. H., “Preparation and properties of antibacterial poly (vinyl alcohol) nanofibers by nanoparticles”, Fibers and Polymers, 2011, 12(5), 602.
  • [9] Bhardwaj, N., Kundu, S.C., “Electrospinning: a fascinating fiber fabrication technique”, Biotechnol. Adv., 2010, 28(3):325–347.
  • [10] Haghi, A. K., “Advances in Nanofibre Research”, Smithers Rapra, Shawbury, Shrewsbury, Shropshire, United Kingdom, 2011.
  • [11] He, J. H., Liu, Y., Mo, L. F., Wan, Y. Q., Xu, L., “Electrospun nanofibres and their applications”, ISmithers, Shawbury, UK, 2008.
  • [12] Chen, M., Wang, C., Fang, W., Wang, J., Zhang, W., Jin, G., Diao, G., “Electrospinning of calixarene-functionalized polyacrylonitrile nanofiber membranes and application as an adsorbent and catalyst support”, Langmuir, 2013, 29(38):11858-11867.
  • [13] Lu, L., Samarasekera, C., Yeow, J. T., “Creatinine adsorption capacity of electrospun polyacrylonitrile (PAN)‐zeolite nanofiber membranes for potential artificial kidney applications”, J. Appl. Polym., 2015, 132(34).
  • [14] Kang, D. H., Kang, H. W., “Surface energy characteristics of zeolite embedded PVDF nanofiber films with electrospinning process”, Appl. Surf., 2016, 387:82-88.
  • [15] Rad, L. R., Momeni, A., Ghazani, B. F., Irani, M., Mahmoudi, M., Noghreh, B., “Removal of Ni2+ and Cd2+ ions from aqueous solutions using electrospun PVA/zeolite nanofibrous adsorbent”, Chem. Eng, 2014, 256:119-127.
  • [16] Cengiz, F., Jirsak, O., “The effect of salt on the roller electrospinning of polyurethane nanofibers”, Fibers and Polymers, 2009, 10(2):177-184.
There are 16 citations in total.

Details

Primary Language English
Subjects Engineering
Journal Section Makaleler
Authors

Funda Cengiz Çallıoğlu 0000-0002-6614-3616

Hülya Kesici Güler 0000-0002-5793-7772

Publication Date September 30, 2020
Submission Date March 26, 2020
Acceptance Date June 18, 2020
Published in Issue Year 2020 Volume: 7 Issue: 3

Cite

IEEE F. Cengiz Çallıoğlu and H. Kesici Güler, “Production and Characterization of PAN/Zeolite Based Nanofibers”, ECJSE, vol. 7, no. 3, pp. 1101–1109, 2020, doi: 10.31202/ecjse.709403.
 Download Cover Image

Creative Commons Lisansı