Abstract
Concept and purpose
Virtually all water treatment facilities worldwide generate an enormous amount of water treatment residual (WTR) solids for which environmentally friendly end-use options are continually being sought as opposed to their landfilling. Aluminium-based WTR (Al-WTR) can offer huge benefits particularly for phosphorus (P) removal and biofilm attachment when used as media in engineered wetlands. However, potential environmental risks that may arise from the leaching out of its constituents must be properly evaluated before such reuse can be assured. This paper presents results of an assessment carried out to monitor and examine the leachability and leaching patterns of the constituents of an Al-WTR used as media in laboratory-scale engineered wetland systems.
Main features, materials and methods
Al-WTR was used as media in four different configurations of laboratory-scale engineered wetland systems treating agricultural wastewater. Selected metal levels were determined in the Al-WTR prior to being used while levels of total and dissolved concentration for the metals were monitored in the influent and effluent samples. The increase or decrease of these metals in the used Al-WTR and their potential for leaching were determined. Leached metal levels in the effluents were compared with relevant environmental quality standards to ascertain if they pose considerable risks.
Results
Aluminium, arsenic, iron, lead and manganese were leached into the treated effluent, but aluminium exhibited the least leaching potential relative to its initial content in the fresh Al-WTR. Levels of P increased from 0.13 mg-P/g (fresh Al-WTR) to 33.9–40.6 mg-P/g (used Al-WTR). Dissolved levels of lead and arsenic (except on one instance) were below the prescribed limits for discharge. However, total and dissolved levels of aluminium were in most cases above the prescribed limits for discharge, especially at the beginning of the experiments.
Conclusions, recommendations and perspectives
Overall, the study indicates that leaching is observed when Al-WTR is beneficially reused for enhanced P removal in engineered wetlands. In particular, levels of aluminium in the treated effluent beyond the prescribed limits of 0.2 mg/l were observed. However, since the results obtained indicate that aluminium leached is mostly associated with solids, a post-treatment unit which can further reduce the level of aluminium in the treated effluent by filtering out the solids could serve to mitigate this. In addition, plants used in such wetland systems can uptake metals and this can also be a potential solution to ameliorating such metal releases. Periodic monitoring is thus advised. Notwithstanding, the use of Al-WTR as a media in engineered wetlands can serve to greatly enhance the removal of P from wastewaters and also serve as support material for biofilm attachment.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
APHA-AWWA-WEF (1998) Standard methods for the examination of water and wastewater, 20th edn. American Public Health Association, Washington, DC
Babatunde AO (2007) The development of an alum sludge based tidal flow constructed wetland for optimizing phosphorus and organic matter removal from wastewaters, PhD dissertation, University College Dublin, Ireland
Babatunde AO, Zhao YQ (2007) Constructive approaches towards water treatment works sludge management: an international review of beneficial re-uses. Crit Rev Environ Sci Tech 37:129–164
Babatunde AO, Zhao YQ (2009) Forms, patterns and extractability of phosphorus retained in alum sludge used as substrate in laboratory-scale constructed wetland systems. Chem Eng J 152:8–13
Babatunde AO, Zhao YQ, Yang Y, Kearney P (2008) Reuse of dewatered aluminium-coagulated water treatment residual to immobilize phosphorus: batch and column trials using a condensed phosphate. Chem Eng J 136:108–115
Babatunde AO, Zhao YQ, Burke AM, Morris MA, Hanrahan JP (2009) Characterization of aluminium-based water treatment residual for potential phosphorus removal in engineered wetlands. Environ Pollut 157:2830–2836
Bounheng S, Kazunori N, Munehiro M, Nobuo C, Osamu N (2006) Phragmites australis: a novel biosorbent for the removal of heavy metals from aqueous solution. Water Res 40:2295–2302
Bourgeois JC, Walsh ME, Gagnon GA (2004) Comparison of process options for treatment of water treatment residual streams. Environ Eng Sci 3:477–484
Cornwell DA, Vandermeyden C, Dillow G, Wang M (1992) Landfilling of water treatment plant coagulant sludges. Project No. 512, AWWA Research Foundation. Denver, Colorado, USA
DeWolfe J (2006) Water residuals to reduce soil phosphorus, AWWA research foundation
Elliot HA, Dempsey BA (1991) Agronomic effects of land application of water treatment sludges. J Am WaterWorks Assoc 4:126–131
Elliot HA, Dempsey BA, Maille PJ (1990) Content and fractionation of heavy metals in water treatment sludges. J Environ Qual 19:330–334
EPA (1997) Environmental quality objectives and environmental quality standards: the aquatic environment—a discussion document. Environmental Protection Agency (EPA), Ardcavan, Wexford, Ireland
Hsieh H, Tian P, Raghu D (2000) Leaching of metals from water treatment plant residuals. Pract Period Hazard Toxic Radioact Waste Manag 4:134–139
Hsieh H, Raghu D, Tian P (2006) Leaching studies on a model monofill of water treatment plant residuals. Environ Eng Sci 23:230–238
Jin Q, Liang F, Zhang H, Zhao L, Huan Y, Song D (1999) Microwave technique in analytical chemistry. Trends Anal Chem 18:479–484
Makris KC, O’Connor GA (2007) Beneficial utilization of drinking-water treatment residuals as contaminant-mitigating agents. In: Sarkar D, Datta R, Hannigan R (eds) Concepts and applications in environmental geochemistry. Elsevier, Amsterdam, pp 609–635
Pierzynski GM (2000) In: Pierzynski GM (ed) Methods of soil phosphorus analysis for soils, sediments, residuals and waters. Southern Cooperative series bulletin No. 396
Razali M, Zhao YQ, Bruen M (2007) Effectiveness of a drinking-water treatment sludge in removing different phosphorus species from aqueous solution. Sep Purif Technol 55:300–306
Robache A, Mathe F, Galloo JC, Guillermo R (2000) Multi-element analysis by inductively coupled plasma optical emission spectrometry of airborne particulate matter collected with a low-pressure cascade impactor. Analyst 125:1855–1859
Sandroni V, Clare MM, Donovan A (2003) Microwave digestion of sediment, soils and urban particulate matter for trace metals analysis. Talanta 60:715–723
UK Technical Advisory Group on the Water Framework Directive (2008). Proposals for environmental quality standards for Annex VIII substances. Final report SR1-2007
Yang Y, Tomlinson D, Kennedy S, Zhao YQ (2006a) Dewatered alum sludge: a potential adsorbent for phosphorus removal. Water Sci Technol 54:207–213
Yang Y, Zhao YQ, Babatunde AO, Wang L, Ren YX, Han Y (2006b) Characteristics and mechanisms of phosphate adsorption on dewatered alum sludge. Sep Purif Technol 51:193–200
Yang Y, Zhao YQ, Kearney P (2008) Influence of ageing on the structure and phosphate adsorption capacity of dewatered alum sludge. Chem Eng J 145:276–284
Zhao XH, Zhao YQ (2009) Investigation of phosphorus desorption from P-saturated alum sludge used as a substrate in constructed wetland. Sep Purif Technol 66:71–75
Zhao YQ, Razali M, Babatunde AO, Yang Y, Bruen M (2007) Reuse of aluminium-based water treatment sludge to immobilize a wide range of phosphorus contamination: equilibrium study with different isotherm models. Sep Sci Technol 42:2705–2721
Zhao YQ, Babatunde AO, Razali M, Harty F (2008) Use of dewatered alum sludge as a substrate in reed bed treatment systems for wastewater treatment. J Environ Sci Health A Tox Hazard Subst Environ Eng 43:105–110
Zhao YQ, Babatunde AO, Zhao XH, Li WC (2009a) Development of alum sludge-based constructed wetland: an innovative and cost-effective system for wastewater treatment. J Environ Sci Health A Tox Hazard Subst Environ Eng 44:827–832
Zhao YQ, Zhao XH, Babatunde AO (2009b) Use of dewatered alum sludge as main substrate in treatment reed bed receiving agricultural wastewater: long-term trial. Bioresour Technol 100:644–648
Acknowledgements
Financial support obtained from the Environmental Protection Agency Ireland (grant no: 2005-ET-MS-38-M3) is hereby acknowledged. Mr. Patrick Kearney, Section head technician, Water and Effluents Laboratory, UCD and Dr Dave Healy of University College Cork are also thanked for their assistances.
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible editor: Henner Hollert
Rights and permissions
About this article
Cite this article
Babatunde, A.O., Zhao, Y.Q. Leachability and leaching patterns from aluminium-based water treatment residual used as media in laboratory-scale engineered wetlands. Environ Sci Pollut Res 17, 1314–1322 (2010). https://doi.org/10.1007/s11356-010-0311-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-010-0311-5