Skip to main content
SpringerLink
Log in

Kinetic Testing and Sorption Studies by Modified Weathering Cells to Characterize the Potential to Generate Contaminated Neutral Drainage

  • Technical Article
  • Published:
Mine Water and the Environment Aims and scope Submit manuscript

Abstract

Techniques developed for acid mine drainage (AMD) prediction might not be suitable for contaminated neutral drainage (CND) generating sites. The Tio mine waste is known to generate Ni contaminated neutral drainage in some of the piles, but humidity cell tests fail to generate the Ni concentrations observed in the field. Weathering cell tests (small-scale humidity cell tests) were performed on fresh and weathered (produced 25 years ago) waste rock samples from the Tio mine containing various levels of hemo-ilmenite ore, and results were compared to humidity cell results on similar samples. The main constituents of the waste rock are the hemo-ilmenite ore and the plagioclase gangue; these minerals were purified from the waste rocks and the purified fractions were also submitted to weathering cell tests. The fresh waste rock samples were also submitted to sorption cells (modified weathering cells), which showed that the waste rocks have an important Ni sorption potential and that the sorbed phases are stable under weathering cell conditions. Even though the Ni concentrations obtained from the laboratory tests remain significantly lower than those obtained in field conditions (from field test pads and from waste rock piles), the results from the present study give important insight into the geochemical processes implicated in CND generation.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9

Similar content being viewed by others

References

  • Benzaazoua M, Bussière B, Dagenais AM, Archambault M (2004) Kinetic tests comparison and interpretation for prediction of the Joutel tailings acid generation potential. Environ Geol 46:1086–1101

    Article  Google Scholar 

  • Blake RE, Walter LM (1999) Kinetics of feldspar and quartz dissolution at 70–80°C and near-neutral pH: effects of organic acids and NaCl. Geochim Cosmochim Acta 63:2043–2059

    Article  Google Scholar 

  • Blum AE, Stillings LL (1995) Feldspar dissolution kinetics. Rev Mineral Geochem 31:291–351

    Google Scholar 

  • Brunauer S, Emmett PH, Teller E (1938) Adsorption of gases in multimolecular layers. J Am Chem Soc 60:309–319

    Article  Google Scholar 

  • Bussière B (2007) Colloquium 2004: Hydrogeotechnical properties of hard rock tailings from metal mines and emerging geoenvironmental disposal approaches. Can Geotech J 44:1019–1052

    Article  Google Scholar 

  • Carroll SA, Knauss KG (2005) Dependence of labradorite dissolution kinetics on CO2(aq), Al(aq), and temperature. Chem Geol 217:213–225

    Article  Google Scholar 

  • Casey WH, Westrich HR, Massis T, Banfield JF, Arnold GW (1989) The surface of labradorite feldspar after acid hydrolysis. Chem Geol 78:205–218

    Article  Google Scholar 

  • Cruz R, Mendez BA, Monroy M, Gonzalez I (2001) Cyclic voltammetry applied to evaluate reactivity in sulfide mining residues. Appl Geochem 16:1631–1640

    Article  Google Scholar 

  • Demers I, Bussière B, Benzaazoua M, Mbonimpa M, Blier A (2008) Column test investigation on the performance of monolayer covers made of desulphurized tailings to prevent acid mine drainage. Miner Eng 21:317–329

    Article  Google Scholar 

  • Frost MT, Grey IE, Harrowfield IR, Mason K (1983) The dependence of alumina and silica contents on the extent of alteration of weathered ilmenites from Western Australia. Mineral Mag 47:201–208

    Article  Google Scholar 

  • Grey IE, Reid AF (1975) The structure of pseudorutile and its role in the natural alteration of pseudorutile. Am Mineral 60:898–906

    Google Scholar 

  • Grey I, MacRae C, Silvester E, Susini J (2005) Behaviour of impurity elements during the weathering of ilmenite. Mineral Mag 69:437–446

    Article  Google Scholar 

  • Hellmann R (1995) The albite-water system: part ii. The time-evolution of the stoichiometry of dissolution as a function of pH at 100, 200, and 300°C. Geochim Cosmochim Acta 59(9):1669–1697

    Article  Google Scholar 

  • Hodgkinson J, Cox ME, McLoughlin S (2008) Coupling mineral analysis with conceptual groundwater flow modelling: the source and fate of iron, aluminium and manganese in a back-barrier island. Chem Geol 251:77–98

    Article  Google Scholar 

  • Inskeep WP, Nater EA, Bloom PR, Vandervoort DS, Erich MS (1991) Characterization of laboratory weathered labradorite surfaces using x-ray photoelectron spectroscopy and transmission electron microscopy. Geochim Cosmochim Acta 55:787–800

    Article  Google Scholar 

  • Janßen A, Golla-Schindler U, Putnis A (2008) The mechanism of ilmenite leaching during experimental alteration in HCl-solution. In: Proceedings of EMC 14th European Microscopy Congress, Aachen, Germany. pp 825–826

  • Klein C, Hurlbut CS Jr, after Dana JD (1977) Manual of Mineralogy, 20th edit, John Wiley and Son, New York City. NY, USA, p 596

    Google Scholar 

  • Lawrence RW, Wang Y (1997) Determination of neutralization potential in the prediction of acid rock drainage. Proc, 4th International Conf on Acid Rock Drainage (ICARD). Vancouver, Canada, pp 451–464

    Google Scholar 

  • Lener EF (1997) Mineral chemistry of heavy minerals in the Old Hickory Deposit, Sussex and Dinwiddie Counties, Virginia. PhD Thesis, Virginia Polytechnic Institute and State University, Blacksburg, VA, USA

  • MEND (2004) Review of Water Quality Issues in Neutral pH Drainage: Examples and Emerging Priorities for the Mining Industry in Canada. Report 10.1, Ottawa, Canada

  • Merkus HG (2009) Particle size measurements: fundamentals, practice, quality. Particle Technology Series, vol 17, Springer Science Business Media BV, ISBN: 978-1-4020-9015-8 (Print), 978-1-4020-9016-5 (Online). doi:10.1007/978-1-4020-9016-5_6, 536 pp

  • Mücke A, Bhadra Chaudhuri JN (1991) The continuous alteration of ilmenite through pseudorutile to leucoxene. Ore Geol Rev 6:25–44

    Article  Google Scholar 

  • Muir IJ, Nesbitt HW (1992) Controls on differential leaching of calcium and aluminum from labradorite in dilute electrolyte solutions. Geochim Cosmochim Acta 56(11):3979–3985

    Article  Google Scholar 

  • Muir IJ, Nesbitt HW (1997) Reactions of aqueous anions and cations at the labradorite-water interface: coupled effects of surface processes and diffusion. Geochim Cosmochim Acta 61:265–274

    Article  Google Scholar 

  • Muir IJ, Bancroft MG, Nesbitt WH (1989) Characteristics of altered labradorite surfaces by SIMS and XPS. Geochim Cosmochim Acta 53:1235–1241

    Article  Google Scholar 

  • Muir IJ, Bancroft MG, Shotyk W, Nesbitt WH (1990a) A SIMS and XPS study of dissolving plagioclase. Geochim Cosmochim Acta 54:2247–2256

    Article  Google Scholar 

  • Muir IJ, Bancroft GM, Nesbitt HW (1990b) Analysis of dissolved plagioclase mineral surfaces. Surf Interface Anal 16:581–582

    Article  Google Scholar 

  • Nair AG, Suresh Babu DS, Damodaran KT, Shankar R, Prabhu CN (2009) Weathering of ilmenite from Chavara deposit and its comparison with Manavalakurichi placer ilmenite, southwestern India. J Asian Earth Sci 34:115–122

    Article  Google Scholar 

  • Nesbitt HW, Skinner WM (2001) Early development of Al, Ca, and Na compositional gradients in labradorite leached in pH 2 HCl solutions. Geochim et Cosmochim Acta 65(5):715–727

    Article  Google Scholar 

  • Nicholson RV (2004) Overview of near neutral pH drainage and its mitigation: results of a MEND study. MEND Ontario workshop, Sudbury, Canada

    Google Scholar 

  • Oelkers EH, Schott J (2001) An experimental study of enstatite dissolution rates as a function of pH, temperature, and aqueous Mg and Si concentration, and the mechanism of pyroxene/pyroxenoid dissolution. Geochim Cosmochim Acta 65:1219–1231

    Article  Google Scholar 

  • Oelkers EH, Golubev SV, Chairat C, Pokrovsky OS, Schott J (2009) The surface chemistry of multi-oxide silicates. Geochim Cosmochim Acta 73:4617–4634

    Article  Google Scholar 

  • Pepin G (2009) Évaluation du comportement géochimique de stériles potentiellement générateurs de drainage neutre contaminé à l’aide de cellules expérimentales in situ. MS degree, Dépt des génies civil, géologique et des mines. École Polytechnique de Montréal, Montreal, Québec, Canada

  • Pepin G, Bussière B, Aubertin M, Benzaazoua M, Plante B, Laflamme D, Zagury GJ (2008) Field experimental cells to evaluate the generation of contaminated neutral drainage by waste rocks at the Tio mine, Quebec, Canada. Proc, 10th International Mine Water Assoc (IMWA) Congress on Mine Water and the Environment, Czech Republic, pp 309–312

  • Pettit CM, Scharer JM, Chambers DB, Halbert BE, Kirkaldy JL, Bolduc L (1999) Neutral mine drainage. Proc,Sudbury 1999 Mining and the Environment International Conference. vol 2, pp 829–838

  • Plante B (2005) Comparaison des essais statiques et évaluation de l’effet de l’altération pour des rejets de concentrateur à faible potentiel de génération d’acide. Dépt des génies civil, géologique et des mines. École Polytechnique de Montréal. Montréal, Québec, Canada

    Google Scholar 

  • Plante B (2010) Prédiction du drainage neutre contaminé en Ni: cas de la mine Tio. Ph.D. thesis, Université du Québec en Abitibi-Témiscamingue (UQAT), Québec, Canada

  • Plante B, Benzaazoua M, Bussière B, Pepin G, Laflamme D (2008) Geochemical behaviour of nickel contained in Tio mine waste rocks. In: Rapantova, N., Hrkal, Z. (Eds) Proc, 10th International Mine Water Assoc (IMWA) Congress on Mine Water and the Environment, Czech Republic, pp 317–320

  • Plante B, Benzaazoua M, Bussière B (2010a) Predicting Geochemical Behaviour of Waste Rock with Low Acid Generating Potential Using Laboratory Kinetic Tests. Mine Water Environ (in press) doi:10.1007/s10230-010-0127-z

  • Plante B, Benzaazoua M, Bussière B, Biesinger MC, Pratt AR (2010b) Study of Ni sorption onto Tio mine waste rock surfaces. Appl Geochem (in press). doi:10.1016/j.apgeochem.2010.09.010

  • Price WA, Kwong YTJ (1997) Waste Rock Weathering, sampling and analysis: observations from the British Columbia Ministry of Employment and Investment database. Proceedings of 4th International Conf on Acid Rock Drainage (ICARD). Vancouver, Canada, pp 31–45

    Google Scholar 

  • Rietveld HM (1993) The Rietveld Method. Oxford Univ Press, London, UK

    Google Scholar 

  • Sapsford DJ, Bowell RJ, Dey M, Williams KP (2009) Humidity cell tests for the prediction of acid rock drainage. Min Eng 22:25–36

    Article  Google Scholar 

  • Schroeder PA, Le Golvan JJ, Roden MF (2002) Weathering of ilmenite from granite and chlorite schist in the Georgia Piedmont. Am Mineral 87:1616–1625

    Google Scholar 

  • Schweda P, Sjöberg L, Södervall U (1997) Near-surface composition of acid-leached labradorite investigated by SIMS. Geochim Cosmochim Acta 61:1985–1994

    Article  Google Scholar 

  • Sobek AA, Schuller WA, Freeman JR, Smith RM (1978) Field and laboratory methods applicable to overburdens and minesoils. EPA-600/2–78-054. Washington, DC, USA, pp 47–50

    Google Scholar 

  • Stefánsson A (2001) Dissolution of primary minerals of basalt in natural waters: I. calculation of mineral solubilities from 0°C to 350°C. Chem Geol 172:225–250

    Article  Google Scholar 

  • Trivedi P, Axe L, Tyson TA (2001) Xas studies of ni and zn sorbed to hydrous manganese oxide. Environ Sci Technol 35(22):4515–4521

    Article  Google Scholar 

  • Villeneuve M, Bussière B, Benzaazoua M, Aubertin M, Monroy M (2004) The influence of kinetic test type on the geochemical response of low acid generating potential tailings. Proc, Tailings and Mine Waste ‘03, Sweets and Zeitlinger. Vail, CO, USA, pp 269–279

    Google Scholar 

  • Weibel R (2003) Alteration of detrital Fe-Ti oxides in Miocene fluvial deposits, central Jutland, Denmark. Bull Geol Soc Den 50:171–183

    Google Scholar 

  • Zakaznova-Herzog VP, Nesbitt HW, Bancroft GM, Tse JS (2008) Characterization of leached layers on olivine and pyroxenes using high-resolution XPS and density functional calculations. Geochim Cosmochim Acta 72(1):69–86

    Article  Google Scholar 

Download references

Acknowledgments

The authors thank the NSERC Polytechnique-UQAT Chair in Environment and Mine Wastes Management and the NSERC Collaborative Research and Development Grants for funding of this project. The authors also thank Donald Laflamme of Rio Tinto, Iron and Titanium, Inc., for the funding and constant support of this project, as well as Genevieve Pepin for providing samples and insight in the project. Alain Perreault, Mélanie Bélanger, and Mathieu Villeneuve of URSTM, UQAT are also acknowledged for their laboratory support during this project.

Author information

Authors and Affiliations

  1. Univ du Québec en Abitibi-Témiscamingue (UQAT), 445, boul de l’Université, Rouyn-Noranda, QC, J9X5E4, Canada

    B. Plante, M. Benzaazoua & B. Bussière

  2. NSERC-Polytechnique-UQAT Chair, Environment and Mine Waste Mgmt, 445, boul de l’Université, Rouyn-Noranda, QC, Canada

    B. Plante, M. Benzaazoua & B. Bussière

  3. Canada Research Chair on Integrated Mgmt of Mine Waste, UQAT, 445, boul de l’Université, Rouyn-Noranda, QC, Canada

    M. Benzaazoua

  4. Canada Research Chair on the Restoration of Abandoned Mine Sites, UQAT, 445, boul de l’Université, Rouyn-Noranda, QC, Canada

    B. Bussière

Authors
  1. B. Plante
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. M. Benzaazoua
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. B. Bussière
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to B. Plante.

Electronic Supplementary Material

Below is the link to the electronic supplementary material.

10230_2010_131_MOESM1_ESM.pdf

Electronic Supplementary Material 1: Cumulative normalized loadings for waste rock samples submitted to weathering cells (PDF 60 kb)

10230_2010_131_MOESM2_ESM.pdf

Electronic Supplementary Material 2: Weathering cell results of cumulative normalized loadings on pure minerals (PDF 345 kb)

10230_2010_131_MOESM3_ESM.pdf

Electronic Supplementary Material 3: Weathering cell results of cumulative normalized loadings of S (a), Ni (b) and Co (c) on pure minerals (PDF 74 kb)

10230_2010_131_MOESM4_ESM.pdf

Electronic Supplementary Material 4: Compared cumulative normalized loadings for waste rock samples by weathering cells (PDF 37 kb)

10230_2010_131_MOESM5_ESM.pdf

Electronic Supplementary Material 5: Compared cumulative normalized loadings for pure minerals samples in weathering cells (PDF 198 kb)

Rights and permissions

Reprints and permissions

About this article

Cite this article

Plante, B., Benzaazoua, M. & Bussière, B. Kinetic Testing and Sorption Studies by Modified Weathering Cells to Characterize the Potential to Generate Contaminated Neutral Drainage. Mine Water Environ 30, 22–37 (2011). https://doi.org/10.1007/s10230-010-0131-3

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10230-010-0131-3

Keywords

Search

Navigation