The Effect of Solar Radiation in the Treatment of Swine Biofertilizer from Anaerobic Reactor

The intensive process of creating confined pigs generates large amounts of waste, character‐ ized as polluters of great impact to the environment. According to the Brazilian environ‐ mental legislation, Law No. 9.605/98, the amount of effluent produced by swine requires appropriate destination, and the producer may be held criminally responsible for damage caused to the environment, human health and animals.


Introduction
The intensive process of creating confined pigs generates large amounts of waste, characterized as polluters of great impact to the environment. According to the Brazilian environmental legislation, Law No. 9.605/98, the amount of effluent produced by swine requires appropriate destination, and the producer may be held criminally responsible for damage caused to the environment, human health and animals.
The diet used to feed swine has a high nutritional value, and what is effectively utilized by the animals is approximately 50% and the remainder is excreted in their feces. In relation to the organic load, the pig manure has a greater power of pollution than the domestic sewage. However, the effluent of these animals contains important chemicals that are necessary in agriculture which, when added to soil, can act as fertilizer, replacing part of chemical fertilizers. However, irrigation with wastewater from pig farms, especially in growing vegetables, generates constant concern about the risks of contamination by pathogenic organisms.
In this sense, the efficiency of a disinfection process to reduce these pathogens in water or wastewater is essential. The disinfection may be performed by chemical and physical processes. In chemical processes what is mainly used are: chlorine gas, sodium hypochlorite, chlorine dioxide and ozone. In the physical processes what is mainly used is the heat and Recent assessments have shown a high level of contamination of rivers and surface waters that supply both the rural and urban areas [2]. According to this author, using the concept of equivalent population, a pig, on average is equivalent to 3.5 people in terms of contamination by effluent. The pollutant capacity of a pig is higher than any other species. In other words a farm with a population of 1,000 animals pollutes the environment more than a city of 3,500 inhabitants.
The pig deject is composed of feces, urine, drinking and cleaning waste water, wasted feed, and dust caused by the breeding process [3]. The main causes of sewage pollution by swine effluents is due to its untreated release into waterways, which causes an imbalance due to the reduction of dissolved oxygen in water, the spreading of pathogens and soil and water contamination by nitrates, ammonia and other toxic elements [2].
However, the search for ways to reduce the impact on the environmental, such as the methanogenic fermentation of biodigesters, whose product is rich in nitrogen, phosphorus, potassium and biogas, still continues. [3,4].
The production of effluents by pig farms has bought great concern due to its high rate of contamination and its large volume as shown in Table 1. Table 2 shows the minimum, average and maximum for the physical-chemical characterization of pig manure obtained in the unity of the waste treatment system of Embrapa (Brazilian Agricultural Research Corporation) in the City of Concord in the State of Santa Catarina -Brazil.

Risks of pollution from pig manure
The improper disposal of pig waste can contaminate surface water with organic matter, nutrients, fecal bacteria and sediment. Nitrates and bacteria are components that affect the quality of underground water systems [2].  Table 2. Physical-chemical characterization of pig manure in Concordia, Santa Catarina Source: [5] Ceretta et al (2005), studying the importance of runoff as a phenomenon of loss of nitrogen and phosphorus applied through pig slurry in an area cultivated with the rotation oat / corn / turnip, concluded that losses by disposal of nitrogen and phosphorus for the nutrition of plants are considered small, but their concentrations in the major peaks are at risk of eutrophication sources of bodies of water.
Fertilization with excessive or continued swine waste can cause undesirable environmental impacts such as biological and chemical imbalances in the soil, water pollution, loss of productivity and quality of agricultural products and reduce the diversity of plants and soil organisms [8].
The production of pigs can generate other types of pollution such as the odor that occurs due to evaporation of volatile compounds that cause harmful effects to human welfare and animal. The types of airborne contaminants are more common in waste are ammonia, methane, volatile fatty acids, H 2 S, N 2 O, ethanol, propanol, dimethyl sulfidro sulfidro and carbon. The emission of gases can cause severe damage to the breathing airways of both man and animals, as well as the formation of acid rain through discharges of ammonia in the atmosphere and contribute to global warming [9,10].

Disinfection of waste
During effluent treatments, the pathogen reduction is essential and this process can be chemic, with the use of disinfectant, or by physical process, destroying or inactivating these agents [11]. The efficient disinfection of the water supply and waste effluent can considerably reduce the transmission of diseases by water [12].
Chlorine is widely used to treat waste water. However, reacting with natural organic matter, this chemical agent generates sub products as chloroform, monochloroacetic acid, trichloroacetic and dichloroacetic. These compounds are considered potentially harmful to human health [13].
It is therefore necessary to develop ways of disinfection without risk to the environment and to humans, while at the same time, maintaining the efficiency provided by chlorine disinfection [14].
Alternative methods of disinfection are being developed in order to replace chemical products, reducing the formation of precursors of trihalomethanes or other byproducts with carcinogenic potential [15].
The use of ultraviolet radiation is an alternative to chemicals in the process of disinfection of drinking water and also wastewater [16], with the advantage of not generating unwanted byproducts and it does not keep waste that could affect the balance of the ecosystem where the effluent is being released [14].

Ultraviolet
Ultraviolet radiation corresponds to the portion of the electromagnetic spectrum which lies between the X-rays and visible light [14]. Ultraviolet radiation can be an alternative to using traditional chemicals in the process of disinfection of drinking water and wastewater [15].
The effect of ultraviolet light on living beings can be divided into UV-A, UV-B, UV-C and UV-vacuum. The UV-A radiation has wavelength between 315 nm (90.8 kcal / einstein) and 400 nm (71.5 kcal / einstein). UV-B has a wavelength between 280 nm (102 kcal / einstein) and 315 nm (90.8 kcal / einstein). The UV-A radiation is less harmful to humans because has low energy and the "black light" be present. This radiation is used to produce florescence in materials, in phototherapy and artificial tanning [17].
According to Ryer (1997) quoted by [17], UV-B radiation is the most destructive form of light, by having enough energy to cause damage in biological tissues, and the minimum amount that is not completely absorbed in the atmosphere. This radiation is responsible for causing skin cancer.
UV-C has a wavelength ranging from 200 nm (143 kcal / einstein) at 280 nm (102 kcal / einstein), is the ultraviolet radiation used as a germicide. The photons of light in this range concentrate significant amounts of energy in collisions with oxygen, resulting in the formation of ozone and are absorbed in a few hundred meters [17]. The range of the wavelength used as a germicide high-power deactivation of microorganism is between 245 nm (116.7 kcal / einstein) and 285 nm (100.4 kcal / einstein).
The vacuum-UV radiation has a wavelength 40 to200 nm. The first scientists to report the germicidal effect of sunlight were the British Downes and Blunt in 1877 [18]. Initially, this radiation was used for disinfection of air, pharmaceuticals products and compact stations of drinking water treatment, especially on shipping vessels [14]. The bactericidal effects of UV radiation were proven more accurate form by Barnard and Morgan in 1903, who utilized electrical currents to produce radiation with a wavelength between 226 nm and 328 nm [17].

Mechanism with ultraviolet disinfection
The main mechanism of action of ultraviolet radiation in the disinfection process, using the wavelength in sunlight, is by interfering in the biosynthesis and cell reproduction. The microorganisms are inactivated by ultraviolet radiation as a result of photochemical damage caused to nucleic acids, hampering the normal functioning [16,15].
The UV radiation does not inactivate the microorganisms by chemical reaction, as with most of the disinfecting agents used in water. The inactivation of microorganisms occurs by the absorption of high-energy, which promotes photochemical reactions with the fundamental components of cells, disrupting the mechanism of duplication or killing the same [18].
The ultraviolet disinfection occurs due to absorption of radiation by proteins and nucleic acids DNA and RNA. With the UV absorption of proteins present in the cell membranes there is a rupture of these membranes and consequently cell death. The absorption of low doses of ultraviolet radiation by DNA can just interrupt the reproduction of microorganisms, preventing them from contaminating the environment [15].
Frequently the absorption of ultraviolet light present in the DNA molecules, such as purines and pyrimidines, becomes more reactive. The maximum absorption of ultraviolet radiation by DNA occurs at 260 nm, suggesting that inactivation by radiation is measured by direct absorption of the purine and pyrimidine molecules, leading to the formation of dimers and hydrates [15]. The ultraviolet radiation passes through the cell wall and is absorbed by nucleic acids and to a lesser extent, by the proteins and other molecules that are biologically important [12].
Ultraviolet radiation absorbed by DNA nitrogen bases may result in the formation of pyrimidine dimers. These molecules deform the helical structure of DNA and impair the replication of the nucleic acid. If replication occurs, the new cells will be mutant descendants unable to replicate (WEF, 1995 quoted by [17]. According to Daniel et al. (2001) this is the fundamental mechanism of disinfection by ultraviolet radiation as shown in Figure 1.

Advantages and disadvantages of ultraviolet
The advantages of using ultraviolet radiation as a disinfectant agent in water treatment are [14]: • Ultraviolet radiation is effective for wide range of bacteria and viruses, using relatively small doses; • Minimum health risks -the formation of byproducts is minimal; • Gives no residual action, which could react with organic substances in commercial or industrial applications -for example, discoloration is not produced, or a change of flavor, when using ultraviolet radiation in the food industry; • Safety and acceptance by the operators and the public -no toxic chemical is transported, stored or handled; • Simplicity and low costs of operation and maintenance -ultraviolet radiation equipment is simpler than the equipment for generating ozone and chlorine dioxide; • Short contact time, therefore, does not require huge tanks of contact, effective disinfection doses are achieved in a few seconds, compared to the period of 10 to 60 minutes for other disinfecting technologies, being that it is system with an external power source.
Among the disadvantages of disinfection with ultraviolet radiation, are: • The repair mechanisms of damage DNA caused of microorganisms, if a sub lethal dose is employed; • The material dissolved or suspended reduces the intensity of radiation as it passes through the water depth; • It doesn't confer effect to the distributed water because its action is immediate.
However, the fact that ultraviolet radiation does not leave a disinfectant residual in the water has arguably been appointed as an argument for the use of chlorine, because in reality, there is potential for biofilm formation in water distribution networks. If the water contains nutrients (mainly, assimilable organic carbon), these can accumulate around the pipes, supporting microbiological growth and, furthermore, the presence of 1 mg / L free chlorine residual does not guarantee that the biofilm is not formed on the surfaces of pipes and coliforms at 45 o C are not found in drinking water [19].
According to Daniel et al. (2001), the disinfection with ultraviolet radiation is most effective for water with a small value of color and turbidity due to the need of light penetration in the center, therefore the quality of water to be treated is an important factor in using this process.

Materials and methodology
This study was conducted at the Experimental Farm Professor Hamilton Abreu Navarro (FEHAN), Institute of Agricultural Sciences (ICA) of the Federal University of Minas Gerais, Regional Campus Montes Claros / MG. The FEHAN is located 7 km from the city center and has an area of 232 ha. Montes Claros is situated at latitude 16 ° 43 '41'' South and longitude 43 ° 52' 54'' west ( Figure 2). For this municipality, the average altitude is 646 meters in an area of 3568.93 km2 and a population estimated at 361.9 thousand inhabitants [20]. At FEHAN, the number of pigs is of 180 animals raised in an intensive production system with complete cycle, i.e., raise, reraise and fatten. The animals are confined to bays, gestation cages and birthing cages. The slaughter age is around six months, weighing on average 100 kg. The animals' diet is based on ground corn, soybean and vitamins / minerals. Water is provided in abundance through troughs in the form of a pacifier.
The cleaning of the swine area happens in the morning with the scraping of excrements and high pressure hose. The effluent is directed by gravity to the digester Indian model with functional load capacity of 17.42 m 3 for treatment ( Figure 3).
After treatment in the biodigester, for a period of 45 days, samples were collected from 40 liters of effluent and placed in the disinfection device, that we developed, made from recyclable transparent "Pet" bottles, as Figure 4, with the principle of thermosyphon, given the denomination of Ultraviolet Radiation Treatment System (SITRU), the samples were then exposed to ultraviolet radiation for eight consecutive days. The SITRU consists of five columns of transparent 2 liter containers of "Pet" each, connected by drainpipes (200 mm) and silicone. Connections are of 32 mm PVC whose function is to link the five columns of "Pet". A 20 liter container is at the top as a reservoir of effluent, which is connected to SITRU through a pipe of 32 mm at the top and a pipe of 32 mm at the bottom, as can be seen in Figure 4. The SITRU was placed towards the west at an inclination of 30°. The temperatures of the effluent in the ultraviolet treatment system were collected at two periods ( Figure 5, Table 3).  The laboratory tests were conducted with the aim of verifying the disinfecting power of solar radiation. Analyzed, the presence of helminth eggs protozoa and oocysts per gram of feces in the biofertilizer in triplicate, at the start of the treatment in the SITRU and at the end of treatment in the SITRU, i.e. parasitological tests were carried out in two stages.  The disinfection efficiency of the biofertilizer by solar radiation was assessed in parasitological and microbiological analyzes in the laboratories of the Institute of Agricultural Sciences -UFMG.
Parasitological analyzes were performed at the Parasitological laboratory and the method used was the sedimentation technique for counting eggs per gram of feces / biofertilizer in a Sedgewick Camera for the detection of helminth eggs and protozoan oocysts [21]. In the first stage, the tests evaluated the biofertilizer at the beginning of the treatment in the SITRU; in the second step, analyzes were performed at the end of eight days of treatment in the SI-TRU. The results of the parasitological analyzes were transformed into log (x + 1) and the means compared the test "t" Student with significance level of 5%.
Microbiological analyzes were performed in the Microbiology laboratory in accordance with [22] using the method of most probable number (MPN / mL) achieved from the application of the multiple tube technique, which consists in the inoculation of decreasing volumes of sample in a suitable environment for growth of the target organisms, each volume being inoculated in a series of 3 tubes for total coliforms count at 35 °C, fecal coliforms count at 45 °C and for the identification of E. coli in the sample of biofertilizer.
Following APHA (2001), another method used the Agar Mac Conckey. The samples were transferred to plates containing this medium to obtain isolated colonies. Each plate colonies were used for confirmatory biochemical analyzes. The colonies that had characteristics of presumptive E. coli, were analyzed, taking into consideration its aspects. For confirmatory biochemical tests, tubes were used, containing Middle Rugai modified with lysine. The collected samples were taken daily in a volume of 200 mL, refrigerated and sent to laboratories. Analyses were performed immediately after collection.

Results and discussion
Tests of the microbiological samples of disinfection with solar radiation in the SITRU were performed in two steps. In the first step the determination results of the MPN / ml of total coliforms and fecal coliforms are shown in Table 4. It was not possible to perform the test for E. coli using the NMP / mL, considering that no gas was formed in the pipes of Durham present in the E.C. As shown in Table 4. In the second stage, the research results obtained from E. coli are shown in Table 5. The ability to resist ultraviolet radiation, for any microorganism, reduces with the increase of applied dose and among microorganisms, even within of the same species; there are large differences in resistance [14]. These results agree with [15] who claims that ultraviolet radiation is more effective in waters with color and turbidity of limited value due to the need of light penetration in the middle. Therefore, the quality of water to be treated is an important factor in using this process. The effect of suspended solids in the efficiency of the disinfection process, which besides increasing absorbance of the effluent, hide bacteria on its inside. Therefore it was recommended a pre-filtration for a better efficiency in disinfection [11].
According to [16], it was possible to observe that a system equipped with a reactor of UV lamps, had a very efficient operation in terms of E. coli inactivation for the conditions of the experiments with retention times of 3 and 5 minutes, both in clearer water, as for turbid waters.
The results for the parasitological analysis are presented in Tables 6, 7 and 8.  Table 8. Trichostrongylideos egg count of effluents in the biodigester before and after the treatment system by ultraviolet radiation. Statistical analysis of data showed that there was no significant reduction, with 5% significance for the results presented in tables 6, 7 and 8. However, it may be noted reduction of 62.32%, 61.43% and 72% of Ascaris sp., protozoa and oocyst trichostrongylideos eggs, respectively, before and after the treatment system by ultraviolet radiation.
According [17], in general, bacteria and viruses are sensitive to ultraviolet radiation, needing only effective doses of 20 mWs/cm² to inactivate most species. However, the same cannot be reported for protozoa and helminths, endowed with natural protection that allows for their survival in harsh environments. The shapes of the encysted protozoa and helminths eggs are resistant to ultraviolet radiation, requiring extremely high doses and, in most cases, too costly economically to result in efficient inactivation.
During the disinfecting process of biofertilizer in the SITRU, in this present study, it can be observed that the temperature for the experiment ranged between 19 °C to 34 °C. The thermotolerant coliforms are still alive even at 44 °C and for the most coliforms best growth occurs to 35 °C, therefore in this study it was observed that the temperature did not influence the reduction of these bacteria.
According to [16], with respect to the analysis in terms of efficiency, it should be noted that the inactivation of E. coli does not determine the safety of the system as a sanitary barrier. For this, it should be the object of verification not only the pathogenic microorganisms of greatest resistance to the process of disinfection by ultraviolet radiation, such as viruses and protozoan cysts, but also those whose dimensions provide a greater protective effect exerted by the particles dispersed in water to the action of ultraviolet radiation. Thus, by establishing a system of disinfection by ultraviolet radiation, it is evident the need to undertake in a comprehensive manner the water's physical-chemical and microbiological characteristics, the dispersed particle size characterization and evaluation of the permanence of these parameters in different seasons of the year.

Conclusion
Despite the color, turbidity and suspended solids high values, the ultraviolet radiation treatment system -SITRU was efficient in the reducing the presence of Escherichia coli, but less efficiently for Ascaris sp egss, Trichostrongylideos eggs and oocysts protozoa.