EVALUATION OF STORAGE METHODS OF BEEF BY MICROBIOLOGICAL AND CHEMICAL INDICATORS

Meat and meat products are a major part of a person's ration. However, due to their high nutritional value, they are a favorable environment for the development of microorganisms and require refrigerated storage. The purpose of this work was to evaluate the storage methods for refrigerated and frozen beef by microbiological and chemical parameters and to suggest criteria for evaluating beef by the content of psychrotrophic microorganisms. It was found out that the storage of beef meat with an initial mesophilic bacterial content of about 4.88 log CFU.cm-2 of surface and psychrotrophic bacteria 3.79 log CFU.cm-2 at temperature 0 °C is only possible for 8 days, further, the microbiological indices exceed the acceptable standards. Investigation of the dynamics of microflora reproduction during the storage of beef in the frozen state at temperature -2 to -3 °C for 20 days established a decrease in 1.3 times the number of mesophilic bacteria in 10 days of storage. At the same time, the number of psychrotrophic microorganisms during this storage time was increased in 4.5 times, and 20 days in 7.9 times and amounted to 5.3 log CFU.cm-2 of surface area. This indicates that the storage of meat in the frozen state inhibits or completely stops the development of mesophilic microorganisms for 20 days. It was found out that storing of beef in the cooled state at a temperature of 0 ±0.5 °C for more than eight days is impractical, as its biochemical indices are worsening and signs of spoilage are appearing. At the same time, storing of beef in the frozen state at a temperature of -2 to -3 °C for 20 days does not cause such significant biochemical changes as in beef stored in the cooled state at a temperature of 0 ±0.5 °C for 16 days. Therefore, we have experimentally substantiated the quantitative indicators of the content of psychrotrophic microorganisms on the surface of beef intended for storage in a cooled or frozen state. The proposed microbiological criteria will improve the safety of beef.


INTRODUCTION
Meat and meat products are a significant part of a person's ration as they are a source of complete proteins. Due to its high nutritional value, meat is a favorable environment for the development of microorganisms (Alonso-Hernando, Alonso-Calleja and Capita, 2013; Dave and Ghaly, 2011; Gunvig, Hansen and Borggaard, 2013;Lerma et al., 2015). Therefore, during its storage, short-term (cooling), long-term (freezing), or long-term (freezing), different temperature regimes are used to stop microbiological and physico-chemical processes (Bruckner et al., 2012;Jeremiah, 1997; Pennacchia, Ercolini and Villani, 2011;Pothakos et al., 2014). According to the definition of the British Institute of Research in the field of food technology (UK Institute of Food Science and Technology, IFST) the storage date of the food is the time during which the product remains safe, ie, meets all the proper organoleptic, chemical, physical, microbiological properties, as well as food and nutritional requirements.
In the Commission Regulation ( Therefore, even if the microbiological parameters meet the standard requirements before cooling, freezing, or chilling the meat, they may well exceed these standards at the end of the storage period. Normally, after animals slaughtering, micro-organisms should be detected only on the surface of the carcasses, this is due to exogenous contamination and meets the sanitary and technological requirements (Bruckner et al., 2012;Kameník, 2013;Salata et al., 2017;Serraino et al., 2012). According to Commission Regulation (EC) No. 2073/2005, the number of colonies of aerobic mesophilic micro-organisms on cattle carcasses before cooling should be from log 3.5 CFU.cm -2 to log 5.0 CFU.cm -2 area, and the content of bacteria of Enterobacteriaceae ranges from log 1.5 CFU.cm -2 to log 2.5 CFU.cm -2 .
Scientific publications and regulatory documents pay more attention to the contamination of beef carcasses, mainly mesophilic aerobic facultative anaerobic microorganisms and bacteria of the genus Enterobacteriaceae, which are indicators of compliance with sanitation during the slaughter of animals It is believed that microbiological changes in meat occur due to the reproduction of psychrotrophic microflora when stored beef in a cooled and frozen state. However, in recent years there has been a tendency to increase consumption and use as raw material for the frosted meat food industry compared to frozen ( Robertson et al., 2013). However, the term of storage of any product cannot be implemented in the production technology without a comprehensive scientific justification for all parameters that influence safety. Therefore, a properly selected storage regime should ensure the maximum term of storage of the food product without disturbing its organoleptic, physico-chemical, and microbiological characteristics. With this in mind, it is relevant to study the content of psychrotrophic microflora during refrigeration storage of beef.
The purpose of this work was to evaluate the storage methods for refrigerated and frozen beef by microbiological and chemical parameters and to suggest criteria for evaluating beef by the content of psychrotrophic microorganisms.

Scientific hypothesis
It is possible to use the psychrotrophic group of microflora to evaluate the hygiene of the technological process of cattle slaughtering and beef processing and the suitability of meat for storage in a cooled and frozen state.

MATERIAL AND METHODOLOGY
A sampling of beef and carcass washes was carried out at meat processing enterprises of Lviv and Ternopil region, preparation for the investigation was performed according to ISO 6887-1:2017 and ISO 6887-2:2017 (ISO, 2017a; ISO, 2017b). One part of the beef (half-carcass) was stored in a refrigerated state at 0 ±0.5 °C for 16 days and the second in the frozen state at 2 -3 °C for 20 days. At the beginning of the experiment (cooled beef) and in 8, 16 days of storage in the cooled state and 10 and 20 days of storage in the frozen state, samples were taken and microbiological and biochemical parameters were determined.
Microbiological investigations were carried out in the laboratory of the Stepan Gzhytskyj Lviv National University of Veterinary Medicine and Biotechnologies. To determine the number of psychrotrophic microorganisms was sown 1 cm 3 of flushing or its ten-fold dilutions in Petri dishes, poured 15 cm 3 of molten and cooled to 45 ±5 °C MPA, incubation of crops was carried out at a temperature of +7.0 ±0.5 ºC for 10 days, and to determine aerobic mesophilic microorganisms, the crops were incubated at 30 ±1 °C for 72 ±1 h. The identification of pure cultures was performed according to the morphological, tinctorial, cultural, and biochemical properties, which are described in the Bergey bacteria determinant (Vos et al., 2011). Tests were also used for the biochemical identification of nonfermenting microorganisms "Neferm test-24" (Rlivalachema, Czech Republic).
The amount of volatile fatty acids was determined by a method based on the isolation of volatile fatty acids, which are accumulated in the meat during storage and determination by the titration amount of the distillate obtained with a solution of caustic potassium (or caustic soda). Herewith meat was considered fresh in terms of volatile fatty acids 4.0 mg KOH; -doubtful freshnessfrom 4.1 to 9.0 mg KOH; stale more than 9.1 mg KOH. The content of lipid peroxidation products in beef meat was determined by conventional methods, so the concentration of TBK-active products in tissue homogenates was determined by the method of Korobeinikova, 1989. To precipitate proteins to 1 mL of tissue homogenate was added 4.5 mL of 20% phosphoric acid and the samples were centrifuged. The supernatant was drained and 1.0 mL of 0.8 th thiobarbituric acid (TBK) solution was added to the precipitate and was kept for 1 h in a water bath at 100 °C. The tubes were then cooled and centrifuged. In the obtained centrifuge, the absorbance was measured at 535 and 580 nm against a control sample that contained bidistilled water instead of the homogenate. Double absorption measurement eliminates the absorption of colored complexes of thiobarbituric acid by substances of non-lipid nature. The content of TBK-active products was calculated by regression equation: С = 0.21 + 26.5ΔD where C is the concentration of TBK-active products; ΔD -indicator D535 -D580 in the centrifuge. Diene conjugates (DCs) in the meat were determined spectrophotometrically.

Statistical analysis
Statistical processing of the results was carried out using methods of variation statistics using the program Statistica 9.0 (StatSoft Inc., USA). Non-parametric methods of research were used (Wilcoxon-Mann-Whitney test). The arithmetic mean (x) and the standard error of the mean (SE) were determined. The difference between the comparable values was considered to be significant for p <0.05.

RESULTS AND DISCUSSION
The results of research on the dynamics of the microflora of beef meat cooled during storage are shown in Figure 1.
As can be seen from Figure 1, that in compliance with all veterinary and sanitary requirements for the procurement of beef meat in meat processing plants, the microbiological indices of the meat meet the established standards of the Regulation EU No 2073/2005 (permissible content of mesophilic micro-organisms up to 5 log CFU.cm -2 of carcass surface). In 8 days of storage at 0 °C, the total number of mesophilic microorganisms on the surface of half-carcasses was increased into 16.6 times (p <0.05), and in 16 days -into 3 350 times (p <0.05) and exceeded the allowed level following the regulations by 1.3 times and 258 times, respectively. It can also be noted that the content of psychrotrophic microorganisms was increased into 350 times (p <0.05) in 8 days of meat storage and 52 thousand times (p <0.05) in 16 days. If you compare the content of psychrotrophic microorganisms with the number of mesophilic during the process of meat storage, you can find the following. Psychrotrophic microorganisms on the surface of the chilled meat are 12.4 times smaller than mesophilic, but due to the faster rates of reproduction at this temperature, their number in the eighth day of storage was already 1.7 times (p <0.05) higher. Psychotrophic microorganisms of chilled meat during the storage process have been the main dominant microflora, and this indicates its major role in the occurrence of microbiological defects in meat.
In Figure 2 results are given due to the microbiological investigations on the dynamics of microflora during the storage of beef in the frozen state at temperatures of -2 to -3 °C for 20 days.
As can be seen from Figure 2, that the content of mesophilic microorganisms beef meets the established requirements for 20 days of storage at temperatures of -2 to -3 °C. A decrease of 1.3 times (p <0.05) in the number of mesophilic bacteria were detected after 10 days of storage, and after 20 days of their content remained practically unchanged. This does not indicate that the storage of meat in the frozen state inhibits or completely stops the development of mesophilic microorganisms for 20 days. At the same time, psychrotrophs, which can withstand low ambient temperatures, under these conditions increased their number on the surface of the beef in 10 days of storage into 4.5 times (p <0.05). During the next 10 days of storage, that is, for 20 days, their number was increased into 7.9 times (p <0.05) and amounted to 5.3 log CFU.cm -2 of surface area.
To fully characterize the microbiological changes in frozen meat, we determined the generic composition of psychrotrophic microflora, which is dominant in the storage process of beef at low temperatures.
In Figure 3 the composition of the psychrotrophic microflora of chilled beef is shown.
The identification of psychrotrophic microflora revealed that most of the cooled meat were bacteria of the genus Acinetobacter spp. -55.1 ±2.2% and the smallest 14.6 ±0.7% of Pseudomonas spp. At the same time, an increase in the number of detected bacteria in the composition of psychrotrophic microflora of chilled beef was detected after 16 days of storage. Among the already identified three genera from the beef are bacteria of the genus Flavobacterium spp. and Aeromonas spp., which were not identified in the cooled meat, their number was 1.7 ±0.2% and 1.4 ±0.1%, respectively. This indicates the development of these bacteria during the storage of the beef in a chilled state. It is also seen that bacteria of the genus Acinetobacter spp. represent almost half of all psychrotrophic microflora of the cooled and chilled meat after 16 days of storage -55.1 ±2.2 and 42.4 ±1.7% respectively. Bacteria of the genus Alcaligenes spp. occupy a stable niche of microflora, both cold and frozen meatfrom 30.3 to 26.2%. However, bacterial growth of the genus Pseudomonas spp. Into 1.9 times (p <0.05) on the surface of chilled beef, compared to cooled was observed.
Identification of the composition of psychrotrophic microflora of frozen beef after twenty days of storage ( Figure 4) revealed an increase in bacteria of the genus Pseudomonas spp. into 1.3 times. At the same time, bacteria of the genus Alcaligenes spp. were consistently high in both cold and frozen meat -30.3 -31.7% respectively. Half of all psychrotrophic microflora accounted for bacteria of the genus Acinetobacter spp. 55.1 -48.6%.
The research of the chemical indices of refrigerated and frozen beef during storage is shown in Figure 5.
As can be seen from the data of Figure 5, that the beef, which was stored in chilled state for 8 days in the content of volatile fatty acids, was of dubious freshness, indicating the beginning of the fat hydrolysis process. After 16 days of chilled beef storing at 0 ±0.5 °C, a certain indicator indicates the deterioration of the meat. In particular, the number of volatile fatty acids was increased into 5.1 times (p <0.05), indicating that the course of intensive biochemical processes of enzymatic hydrolysis of fat and beef with such indicators is characterized as not fresh.
Thus, researches indicate that storing beef in chilled state at 0 ±0.5 °C for more than eight days is impractical, as its chemical characteristics are getting worse and there are signs of spoilage.
Research of beef stored in a frozen state at the temperature -2 to -3 °C revealed that, after 10 days, the number of volatile fatty acids remained at the level characteristic of fresh meat. In 20 days of meat storage, an increase in the amount of volatile fatty acids was found to be 2.3 times (p <0.05). According to these indicators, meat is characterized as doubtful freshness.
Therefore, storage of beef in the frozen state at a temperature of 2 to -3 °C for 20 days does not cause such significant biochemical changes as in beef stored in the cooled state at a temperature of 0 ±0.5 °C for 16 days.
The next part of our research was to determine the content of lipid peroxidation (POL) products in chilled and frozen beef. It is well known (Vega et al., 2009) that the content of POL in meat is increasing with prolonged storage, which negatively affects its quality -smell, taste, structure. The results of researches on the content of TBK-active products (TBKAP) and diene conjugates (DCs) in chilled beef during storage are shown in Figure 6.   As can be seen from Figure 6, that when the meat was kept refrigerated at 0 ±0.5 °C, no significant increase in the amount of TBKAP and DC on the eighth day was observed. On the 16 th day of storage, there is a probable increase (p <0.05) in the number of TBKAP and DC compared to the first day. When storing beef in the frozen state at a temperature of -2 to -3 °C, a probable increase into 1.3 times (p <0.05), compared to the first one, was noted only by the amount of DC for 20 days (Figure 7).
Thus, the obtained data are shown in Figure 6 and Figure  7 indicate that as the temperature of the refrigeration treatment of beef decreases, its resistance to oxidation increases, in particular the growth of TBKAP and DC.
The results indicate that the initial amount of microflora, especially the content of psychrotrophs, is crucial for the choice of beef storage temperature. Therefore, we are offered to evaluate the suitability of beef for storage in a cooled and frozen state according to the following hygiene criteria of the technological process (Table 1).
If a microbiological investigation of five beef samples before cooling from one batch reveals at least one sample of psychrotrophic microorganisms over 4 log CFU.cm -2 of area (≥M), then such beef is used immediately, and measures are taken to improve the hygiene of the technological process.
If three beef samples are detected, the number of psychrotrophic microorganisms from 3 log CFU.cm -2 area to 4 log CFU.cm -2 , (between m and М), then keep such batch in the cooled state at a temperature of 0 ±0.5 °C for not more than 8 days, or in the frozen state at a temperature of 2 to -3 °C for up to 20 days.
If a microbiological examination of five beef samples reveals a number of psychrotrophic microorganisms less than 3 log CFU.cm -2 of area (m), then such a batch is stored in chilled state at 0 ±0.5 °C for up to 16 days, or in the frosted state for 2 -3 °C up to 20 days.
Thus, the proposed criteria for evaluating beef before storage allowed to scientifically justify the optimal cooling or freezing temperature to obtain, at the end of the storage period, meat with satisfactory organoleptic, physicochemical and microbiological parameters.
The urgency of the issue of fresh meat and increasing the storage term is the primary purpose for meat industry professionals. Meat has a limited storage term, creating difficulties for both producers and consumers for whom a defective product is potentially dangerous ( Our investigations have found that the number of mesophilic microorganisms on fresh (24 h) beef carcasses was 12.4 times higher than the number of psychrotrophic microorganisms. During storage of the beef in chilled state at temperature 0 °C for 8 days, the number of aerobic mesophilic microorganisms was increased on the surfaces of the half-carcass by 16.6 times, and in 16 days -into 3 350 times and exceeded the admissible level (up to 5 log CFU.cm -2 of the carcass surface) into 1.3 times and 258 times respectively. At the same time, the psychrotrophic microflora during this period of storage increased 350 times in 8 days and in 52 thousand times in 16 days. That is, on the 8 th day, the amount of psychrotrophic microflora already in 1.7 times outweighed the content of mesophilic microflora. In research Overall, our results indicate that storage of beef meat with an initial mesophilic bacterial content of about 4.88 log CFU.cm -2 of surface and psychrotrophic bacteria 3.79 log CFU.cm -2 at temperature 0 °C is only possible for 8 days, further, the microbiological indices exceed the acceptable standards and half-corpuscles are unusable. Therefore, we believe that when storing chilled meat at temperature 0 °C, it is necessary to achieve a reduction in the initial inoculation of the carcasses by microorganisms by improving the sanitation conditions of meat provision at meat processing plants.
Investigation of the dynamics of microflora reproduction during the storage of beef in the frozen state at temperature -2 to -3 °C for 20 days established a decrease in 1.3 times the number of mesophilic bacteria in 10 days of storage. At the same time, the number of psychrotrophic microorganisms during this storage time was increased in 4.5 times, and 20 days in 7.9 times and amounted to 5.3 log CFU.cm -2 of surface area. This indicates that the storage of meat in the frozen state inhibits or completely stops the development of mesophilic microorganisms for 20 days. Therefore, we support the opinion of scientists (Alonso-Hernando, Capita and Alonso-Calleja, 2013;Bruckner et al., 2012;Cerveny, Meyer and Hall, 2009;Jeremiah, 1997;Kameník, 2013;Pennacchia, Ercolini and Villani, 2011;Pothakos et al., 2014), which indicate that the temperature of refrigeration processing of meat has a significant influence on its storage term.
Thus, even though the meat complies with the standards by the content of mesophilic bacteria, the presence and development of psychrotrophic microorganisms in frozen meat is an integral part of the safety and quality control of beef.

Figure 4
Generic composition of psychrotrophic microflora of beef during storage in the frozen state at temperatures -2 to -3 °C.

Figure 5
Changes in the content of volatile fatty acids during storage of beef in a cooled and frozen state at temperature. Note: KOH; -doubtful freshness -from 4.1 to 9.0 mg KOH; stale more than 9.1 mg KOH. Therefore, investigations indicate that bacteria of genus Pseudomonas spp. during the storage of beef in the cooled and frozen state show the highest intensity of development. An assessment of the volatile fatty acid content of chilled beef found that after 8 days of storage, the meat was of dubious freshness, and after 16 days it was not fresh. In particular, the amount of volatile fatty acids was increased in 5.1 times by 16 days, indicating the course of intensive biochemical processes on enzymatic hydrolysis of fat and spoilage of meat. An investigation of frozen beef was found that after 10 days the amount of volatile fatty acids did not increase, and on the 20 th day their storage their number was 2.3 times higher compared to the content in the cooled meat. With so many volatile fatty acids, the meat is considered to be of doubtful freshness.
Literary data (   Before staging for refrigerated storage improvement of slaughter hygiene and reviewing process control measures Note: 1 n -number of samples taken from one carcass; 2 c -number of samples, parametric values, which are between m і М; 3 m -normative value of the content of microorganisms per 1 cm 2 of the carcass surface; 4 M -maximum content of microorganisms per 1 cm 2 of the surface.

CONCLUSION
Our investigations found that while storing meat in a refrigerated state, a probable increase in the amount of TBKAP and DC was detected by only 16 th day compared to the first one. When storing beef in the frozen state, a probable increase in 1.3 times, compared to the first day, was noted only by the amount of DC on the 20 th day. This indicates that active oxidation of polyunsaturated fatty acids in cell membrane phospholipids occurs in chilled beef meat after the eighth day of storage.
Thus, the investigations indicate that storing of beef in the cooled state at a temperature of 0 ±0.5 °C for more than eight days is impractical, as its biochemical indices are worsening and signs of spoilage are appearing. At the same time, storing of beef in the frozen state at a temperature of -2 to -3 °C for 20 days does not cause such significant biochemical changes as in beef stored in the cooled state at a temperature of 0 ±0.5 °C for 16 days. Also, to prevent the occurrence of organoleptic and biochemical beef defects during refrigeration, it is necessary to stop the development of psychrotrophic proteolytic and lipolytic microflora, which is possible by lowering the temperature. Therefore, we have experimentally substantiated the quantitative indicators of the content of psychrotrophic microorganisms on the surface of beef intended for storage in a cooled or frozen state. The proposed microbiological criteria based on European approaches will improve the safety of beef.