Enzymatic Hydrolysis of Various Pretreated Dried Distillers ’ Grains with Solubles

Dried Distillers’ Grains with Solubles (DDGS) is a popular animal feed that is mainly fed to ruminant livestock (i.e., cattle). However, because of its high fiber content, DDGS is limited in monogastric livestock (i.e., swine and poultry) and aquaculture diets. This causes low inclusion rates and reduced economic value of DDGS for these species. But there is possibility of breaking down the fibers using commercial enzymes. But the high cost associated with the use of commercial enzymes is a challenge with the industrial application of enzymes in feed application. Pretreatment (physical, chemical, and/ or biological) of high fiber containing feedstocks and/or lignocellulosic feedstocks prior to enzymatic saccharification can improve the overall fiber digestibility. Therefore, ranges of commercial enzymes were tested in this study. It was found the commercial enzyme that performed well at low enzyme dosages was Viscozyme L. The effectiveness of the Viscozyme L was significantly high (~280% increase in sugar recovery as compared to the untreated DDGS) when supplemented with the dilute acid pretreated DDGS as compared to the untreated DDGS. Citation: Baldwin EL, Karki B, Iten L, Gibbons WR (2018) Enzymatic Hydrolysis of Various Pretreated Dried Distillers’ Grains with Solubles. Adv Ind Biotechnol 1: 004.


Introduction
Dried Distillers' Grains with Solubles (DDGS) is the major byproduct of corn-based ethanol industry.In 2016, 25.4 million metric tons of DDGS were produced from ethanol plants [1].DDGS is sold as animal feed, mainly to ruminant livestock (i.e., cattle).Ruminants are able to metabolize the fiber, which can serve as a good source of energy when properly formulated in the animals' diet [2].However, because of the high fiber content, DDGS is limited in monogastric livestock (i.e., swine and poultry) and aquaculture diets.The low inclusion rate of DDGS in these diets lower the economic value of DDGS for these species [2].The problem associated with the high fiber content of the DDGS can be overcome either by solubilizing the carbohydrates with commercial enzymes and/or pretreating the DDGS with physical and chemical processes prior to enzyme treatments.
The environmentally-friendly process of using commercial enzymes to solubilize fibers can achieve high sugar yields in lignocellulose biomass (lignin, hemicellulose, and cellulose).However, enzymes cost is of a significant barrier in producing an economical product [3].One way to overcome the high cost of enzymes is by lowering the enzyme loading rates or dosages.Additionally, application of pretreatment techniques prior to enzymatic saccharification can enhance the digestibility of the lignocellulosic fibers.Pretreatments should ideally use minimal amounts of energy and chemicals to limit the cost of the pretreatment process [4].Mechanical process reduces the particle size and crystallinity by chipping, grinding, and milling to increase the surface area and reduce the degree of polymerization [5].Milling alters the ultrastructure of lignocellulose and degree of crystallinity, causing cellulose to be more readily accessed and hydrolyzed by cellulase [6].Liquid Hot Water (LHW) pretreatment is where the lignocellulosic biomass is saturated in water before it is heat treated under pressure to ensure the water stays in the liquid state and dissolves the hemicellulose fraction of the biomass into soluble oligosaccharides.Dilute acid pretreatment is where lignocellulose biomass is saturated with 0.2-2.5% w/w of acid and heat treated [7,8].This process removes the hemicellulose and thus enhances the cellulose digestibility by providing the greater enzyme accessibility [9][10][11][12].Dilute alkali pretreatment can be performed using low alkali concentration (i.e., 0.5-4%) and high temperatures [13,14].This pretreatment will disrupt the lignin and xylan cross-linking ester bonds, increasing the porosity of the lignocellulose biomass [15].This results in enriched fractions of cellulose and hemicellulose [16].
In this study, we analyzed the saccharification yields of the monosaccharides from pretreated DDGS using various commercial enzyme preparations and dosages.The goal was to screen various commercial enzymes at different dosages on pretreated and untreated DDGS to identify the best enzyme and lowest dosage needed to achieve the high amounts of monosaccharides from DDGS.Therefore, preliminary experiments were conducted to test the different commercial enzymes at various dosages on untreated DDGS.Once the enzyme and dosage were established, DDGS was pretreated by various physical and chemical treatments prior to enzyme saccharification.

Enzymatic saccharification of untreated DDGS
Enzymatic hydrolysis was performed in a 250 ml Erlenmeyer flask (100 ml working volume, pH 4.8) using DDGS at 10% Solid Loading Rate (SLR) on dry basis (DM).To prevent from the possible contamination during saccharification period, each flask was supplemented with 500 µl of 500 ppm BioTrol.Enzymes were added individually at dosage of 2, 4 and 6 mg protein/dry gram of DDGS.The enzymes were added to the slurries and put into a shaker incubator set at 50°C (enzyme optimal temperature) and 200 rpm.Samples (5 ml) were taken after 4 and 24 hours of saccharification and immediately stored in freezer until processed for the sugar analysis using HPLC.Details of the sample processing are listed in a later section.

Pretreatments
DDGS samples were sent to the USDA laboratory at Peoria (IL) for conducting pretreatments prior to enzymatic saccharification.Hot water cook, dilute acid, and alkali pretreatments (1 and 4% ammonium hydroxide) were conducted using a stainless steel steam jacketed reactor tube in 8-10 l batch-wise increments on homogenized, 15% w/w (DM) slurries at 160°C for 20 min.For the dilute acid pretreatment, 0.5% w/w sulfuric acid was used while for the alkali pretreatment, 30% ammonium hydroxide was used at the concentration of 1 and 4% (w/w) basis.Similarly, Kady mill pretreatment was carried out using a 12 L jacketed vessel and 4" diameter homogenizing head (Model # OOPS-10).The mill was operated at 8000 rpm at 160ºC and 70 psi pressure.The mill was operated at two different conditions, 1) 8000 rpm at 100°C, and atmospheric pressure and it was called "Kady mill"; 2) DDGS slurry was homogenized at 160°C and 70 psi pressure, which was called "treated Kady mill".After pretreatments, slurries were frozen and stored until use.

Enzymatic saccharification of the pretreated DDGS
Enzymatic saccharification of pretreated DDGS samples were conducted according to the method as described in the section above.Based on the preliminary results as obtained on the untreated DDGS samples, only Ronozyme VP and Viscozyme L were chosen for the further study.To optimize the enzyme dosage for each pretreatment, Ronozyme VP and Viscozyme L were added at the 5 different levels of enzyme dosages (0, 0.125, 0.25, 0.5, 0.75, and 1 mg protein/ dry gram of pretreated samples).Samples were drawn at 0, 4, and 24 hours of saccharification to determine the sugar yields.

Sugar analysis
An HPLC was used to measure the sugars released from the enzymes.The samples were boiled for 15 minutes to inactivate the enzyme.Samples were then centrifuged at 4,000 rpm for 10 minutes before the supernatant was poured into new centrifuge tubes and frozen overnight.The supernatant was thawed to be re-centrifuged again at 4,000 rpm for 10 minutes to remove any precipitants.Then the supernatant was poured into a 2 ml microcentrifuge tube and allowed to freeze overnight.The final supernatant was thawed before it was filter through a 0.2 μm filter and into a HPLC vial and frozen until analysis.A high performance liquid chromatography system (Agilent Technologies, Santa Clara, CA, USA) equipped with refractive index detector (Model G1362A) was used to measure the sugars.The sugars were eluted using a 50 Mm sulfuric acid (de-ionized water) as a mobile phase at a flow rate of 0.6 ml/min and a column temperature of 65°C using an Aminex HPX-87H (300 x 7.8 mm) organic acid column (Bio-Rad Laboratories, Hercules, CA).The sugars quantified included glucose, cellobiose, galactose, xylose, mannose, and arabinose.

Statistical analysis
The enzyme saccharification of untreated and pretreated trials was completed in triplicates.Statistical significance and effect size evaluation were used to provide complementary information of practical significance.Using practical significance aids in the evaluation of whether the results will be applicable in industrial settings.The significance test indicates the likelihood that the observed effect is due to chance, while the effect size indicates the magnitude of the observed effects between variables [17].Effect size value was determined using Hedges' g, rather than Cohen's d, which eliminates bias by putting weight on the pooled standard deviation based on its small sample size (n = 3) [18].Hedges, however, still uses Cohen effect sizes classification which are: small (0.2), medium (0.5), and large (≥0.8) units of differing standard deviations between group means [19].The equation to find Hedges' g is as follows; M = Mean, SD = Standard Deviation, and n = Sample size: Significant difference was found in the sugars by one-way Analysis of Variance (ANOVA) by using a R statistical power analysis program and package 'agricolae' [20,21].Tukey's Honestly Significant Difference (HSD) was used for post hoc tests of significant difference between means [22].

Preliminary screening of commercial enzymes on untreated DDGS
During the primary trials, four commercial enzymes were screened (Figure 1).These trials were meant to select the enzyme that performed the best at low enzyme loading.The total sugars represent all the sugars quantified: glucose, cellobiose, galactose, xylose, mannose, and arabinose.Ronozyme VP did the best out of all the enzymes across all enzyme dosages and time.The next enzyme that performed well was Superzyme L and Viscozyme L. Superzyme L at 4 hours had an effect size value of g equal to 2.10 when comparing 2 and 6 mg/g dosage.So Superzyme L had a high practical significance at 6 mg/g but was not effective with a lower enzyme dosage.Viscozyme L at 4 hours had an effect size value of g equal to 0.71 when comparing 2 and 6 mg/g dosage.So Viscozyme L had a medium practical significance at 2 mg/g, so having a low enzyme dosage was effective.Superzyme L and Viscozyme L at 4 hours were compared at 2 mg/g dosage and had an effect size value of g equal to 0.84.Viscozyme L had high practical significance versus Superzyme L at a lower dosage.
Next, Viscozyme L at 2 mg/g dosage r was compared between 4 hours and 24 hours with 8.65 ± 0.36 mg/ml and 10.29 ± 0.18 mg/ml, respectively.The carbohydrate concentration increased only by ~ 1.64 mg/ ml when enzymatic hydrolysis was conducted for additional 20 hours.

Enzymatic saccharification of pretreated DDGS
Total sugars data of pretreated DDGS showed no significant change between 4 hours and 24 hours.So, when sugars of pretreated DDGS are discussed, it is represented by hour 4. The total sugars concentration enzyme treated DDGS were higher than pretreated samples without enzymes at all levels of enzyme dosages (Table 1).But the pretreatment that performed the best was 0.5% sulfuric acid, followed by liquid hot water, treated Kady mill, Kady mill, 4% ammonium hydroxide, and 1% ammonium hydroxide (Table 1).The two alkali pretreatments did not perform well, especially when comparing with 0.5% sulfuric acid without enzymes.The total sugars yields of sulfuric acid pretreated without the enzyme additions were similar with that of alkali pretreatments at high enzyme dosages (0.75 and 1 mg/g).
As seen in table 1, all the Viscozyme L dosages of 0.5% sulfuric acid total sugars were significantly different from the other pretreatments, but not between the different dosages.To determine the best dosage, glucose was compared from all pretreated DDGS.0.5% sulfuric acid at 1 mg/g of Viscozyme L was significantly higher than all the other pretreatments.

Discussion
This study was conducted in two different series, where firstly  commercial enzymes were tested on untreated DDGS to select the enzyme that performed well at low dosages.Then the DDGS was treated by various physical and/or chemical pretreatments and tested with the best selected enzyme from primary experiments on untreated DDGS.The low enzyme dosages were used (less than 2 mg/dry gram of DDGS).Lower enzyme dosages on pretreated DDGS were tested versus the untreated DDGS because the pretreatment would have liberated more sugars, resulting in less enzymes to be used.
Ronozyme VP performed the best out of all the enzymes tested.However, this enzyme is very low in protein content and is a powder feed enzyme that is meant to go on solid-state materials and not submerged-state materials.This was most prevalently seen as the powder had hydrophobic qualities, causing difficulties of completely dissolving the enzyme and evenly distributing it throughout the entire media.And since this was also a multienzyme complex, another enzyme was selected to be tested on the pretreated DDGS.Superzyme L and Viscozyme L were the next candidates and it was determined that Superzyme L did well at high dosages while Viscozyme L did well at low dosages.Viscozyme L also has known lignocellulose enzymes versus Superzyme L, which is a multienzyme complex.
Viscozyme L was continued on the pretreated DDGS with lower dosages.Overall, 0.5% sulfuric acid at 1 mg/g of Viscozyme L was the most effective when total sugars and glucose was taken into consideration.0.5% sulfuric acid with Viscozyme L at 1 mg/g resulted in the total sugar yields of 33.22 ± 3.32 mg/ml while untreated DDGS at 2 mg/g produced 8.65 ± 0.36 mg/ml total sugars.This is a ~280% increase with a lower enzyme dosage.The pretreatment that did not have significant impact on total sugar yields was the dilute alkali pretreatment.One of the reason for this is monosaccharides, like galactose, mannose, and glucose, are rapidly destroyed by the hot aqueous alkaline solution used with dilute alkali pretreatment [23].This was also reflected by the low amount of glucose on both the dilute alkali pretreated DDGS.

Conclusion
Overall, pretreatment followed by enzyme saccharification improved the carbohydrate yields of DDGS.Viscozyme L was determined to perform well at low enzyme dosages on untreated DDGS.Pretreated DDGS of 0.5% sulfuric acid with 1 mg/g of Viscozyme L resulted in the greatest improvement with an increase of ~280% of total sugars versus untreated DDGS at 2 mg/g.

Figure 1 :
Figure 1: Enzymatic saccharification of untreated DDGS using different enzymes at three different enzyme dosages.The control represents the DDGS without enzymes.Each data point represents the average of three replications and the error bars represent the standard deviation.

Table 1 :
Carbohydrate concentrations (mg/ml) of pretreated DDGS with Viscozyme L at 4 hours of saccharification.