Systems analysis of ethanol production in the genetically engineered cyanobacterium Synechococcus sp. PCC 7002

Background Future sustainable energy production can be achieved using mass cultures of photoautotrophic microorganisms, which are engineered to synthesize valuable products directly from CO2 and sunlight. As cyanobacteria can be cultivated in large scale on non-arable land, these phototrophic bacteria have become attractive organisms for production of biofuels. Synechococcus sp. PCC 7002, one of the cyanobacterial model organisms, provides many attractive properties for biofuel production such as tolerance of seawater and high light intensities. Results Here, we performed a systems analysis of an engineered ethanol-producing strain of the cyanobacterium Synechococcus sp. PCC 7002, which was grown in artificial seawater medium over 30 days applying a 12:12 h day–night cycle. Biosynthesis of ethanol resulted in a final accumulation of 0.25% (v/v) ethanol, including ethanol lost due to evaporation. The cultivation experiment revealed three production phases. The highest production rate was observed in the initial phase when cells were actively growing. In phase II growth of the producer strain stopped, but ethanol production rate was still high. Phase III was characterized by a decrease of both ethanol production and optical density of the culture. Metabolomics revealed that the carbon drain due to ethanol diffusion from the cell resulted in the expected reduction of pyruvate-based intermediates. Carbon-saving strategies successfully compensated the decrease of central intermediates of carbon metabolism during the first phase of fermentation. However, during long-term ethanol production the producer strain showed clear indications of intracellular carbon limitation. Despite the decreased levels of glycolytic and tricarboxylic acid cycle intermediates, soluble sugars and even glycogen accumulated in the producer strain. The changes in carbon assimilation patterns are partly supported by proteome analysis, which detected decreased levels of many enzymes and also revealed the stress phenotype of ethanol-producing cells. Strategies towards improved ethanol production are discussed. Conclusions Systems analysis of ethanol production in Synechococcus sp. PCC 7002 revealed initial compensation followed by increasing metabolic limitation due to excessive carbon drain from primary metabolism. Electronic supplementary material The online version of this article (doi:10.1186/s13068-017-0741-0) contains supplementary material, which is available to authorized users.

years ago by ancient cyanobacteria and was later conveyed via endosymbiosis into eukaryotes giving rise to the development of diverse algal groups and land plants [1]. These photoautotrophic organisms are responsible for the production of most of the organic carbon and nitrogen to feed all heterotrophic organisms in the past as well as currently. Moreover, the fossil fuels, which presently dominate conventional energy production and lead to the rise in atmospheric CO 2 , also resulted from the accumulation of biomass of photoautotrophic organisms during ancient geological times.
Since photosynthesis efficiently converts solar energy into organic carbon that can be used for versatile purposes and needs only water and some inorganic nutrients, photoautotrophic organisms are increasingly applied for diverse biotechnological purposes. Initially, sugars produced by crop plants such as sugar cane were used for the fermentative production of ethanol by yeast, which is identified as a first-generation biofuel. However, this energy production directly competes with human nutrition with respect to biomass production and land use. Therefore, the alternative use of microalgae including cyanobacteria was suggested, since these organisms can be cultivated in large scale on non-arable land. In addition, cyanobacterial biofuel production can be combined with the reduction of CO 2 in emissions from conventional power plants [2]. Moreover, freshwater is becoming a globally limiting resource. Therefore, the future mass cultivation of microalgae and cyanobacteria should be performed in seawater to conserve freshwater resources and to minimize the growth of competing organisms [3,4].
Compared to microalgae, the biotechnological application of cyanobacteria offers many advantages since these prokaryotic organisms show high growth rates and many strains can be easily genetically modified. Ethanolproducing cyanobacterial strains were first generated by heterologous expression of the key enzymes pyruvate decarboxylase (PDC) and alcohol dehydrogenase (ADH) in the freshwater cyanobacterium Synechococcus elongatus PCC 7942 [5]. Subsequently, synthetic biology attempts were used to establish additional biosynthetic pathways in different cyanobacterial host cells, for example, to produce isoprene [6,7], isobutanol [8], ethylene [9], lactate [10] and sucrose [11] among a plethora of additional biofuels and industrial products that can be produced under autotrophic conditions in cyanobacteria [2,12,13]. Recent systems biology analyses revealed that the implementation of biofuel synthetic pathways into the cyanobacterial cell may have greater impact on central metabolism and gene expression than initially expected. Metabolomics combined with transcriptomics showed that cells of Synechocystis sp. PCC 6803 (hereafter Synechocystis 6803), which were generated to produce isoprene, showed limitations in precursor synthesis and signs of redox-stress [7]. In contrast, prolonged ethanol production by Synechocystis 6803 had only minor impact on the transcriptome besides a gradual growth decline of producer cells [14].
In addition to implementing optimized synthesis genes and gene expression control elements, the host strain itself can have a major impact on product yield, especially under mass culture conditions. Previous attempts to produce biofuels at laboratory scales often used the freshwater model strains S. elongatus PCC 7942 (e.g. [5,11,15]) or Synechocystis 6803 (e.g. [7,14,16]). Another attractive cyanobacterial host for biotechnological purposes is the strain Synechococcus sp. PCC 7002 (hereafter Synechococcus 7002). Synechococcus 7002 is a euryhaline, unicellular cyanobacterium, which tolerates high light intensities and can grow in a wide range of NaCl concentrations [17][18][19]. Moreover, the strain is characterized by very fast growth rates (doubling times of 2.6-4.0 h; [20]). In addition, Synechococcus 7002 is also amenable to genetic modification [21] and several systems for genetic complementation and gene overexpression are available [22]. These features make Synechococcus 7002 a promising platform for biotechnological applications, including the production of biofuels [20].
Here we performed a systems analysis of an ethanolproducing strain of Synechococcus 7002, which was grown in artificial seawater medium for over 30 days. Ethanol accumulated continuously in the medium over more than 2 weeks. During prolonged fermentation periods, the producer strain gradually ceased growth and ethanol production. Metabolomics revealed that the carbon drain due to ethanol production resulted in reduction of pyruvate-based intermediates. During long-term ethanol production, the producer strain showed clear indications of intracellular carbon limitation. Despite the decreased levels of glycolytic and tricarboxylic acid cycle intermediates, soluble sugars and even glycogen accumulated in the producer strain. The main conclusions drawn from metabolome analysis on changes in carbon assimilation are supported by our proteome data. In the following, we will present data on the observed limitations on intracellular carbon allocation generated by ethanol synthesis, the compensation reactions of the ethanol-producing strain, and discuss strategies towards improving ethanol production by cyanobacteria.

Ethanol production by engineered Synechococcus 7002 in seawater passes through three phases
An ethanol producer of Synechococcus 7002 expressing heterologously the pyruvate decarboxylase (PDC) gene from Zymomonas mobilis and the alcohol dehydrogenase (ADH) gene from Synechocystis 6803 was cultivated over 30 days in CO 2 -enriched seawater batch culture and was compared to the wild type (WT) grown under identical conditions. To avoid any potential effect on cellular physiology by antibiotic exposure, antibiotics were omitted from the growth media. Genetic stability of the ethanologenic gene cassette was indirectly monitored by measurements of PDC and ADH activities in cell extracts of cyanobacterial cultures. Ethanol production data, cell growth and non-targeted metabolome analyses revealed three phases of ethanol production of the Synechococcus 7002 producer strain (Fig. 1). The heterologous ADH gene was constitutively overexpressed from the genetically engineered Prbc* (optRBS) promoter, whereas transcription of the heterologous PDC gene was induced on day 1. Therefore, synthesis of ethanol was initiated on day 1 of cultivation by PDC induction. Phase I coincided with early growth of the initial culture at 3-7 days post inoculation. During this phase the producer grew (as measured by change in optical density at 750 nm (OD 750 )) at a rate of 0.38 OD 750 day −1 . The ethanol production rate gradually increased during phase I and was on average 0.013% (v/v) ethanol day −1 (0.1 g L −1 day −1 ) as averaged across 4 photobioreactors ( Fig. 1a; Additional file 1). These rates, that we report for the ethanol producer of Synechococcus 7002 in our 12:12 h (day-night) cultivation system with 230 μmol photons m −2 s −1 , were only slightly less than half of the maximal rates that were reported for other genetically modified cyanobacteria grown under continuous light or much higher light intensities [12,14] and were highly enhanced relative to the non-optimized initial S. elongatus PCC 7942 ethanol production system [5]. Phase II comprised the period 10-14 days post inoculation. In this phase growth of the Synechococcus 7002 producer strain stopped (Fig. 1b), but the rate of ethanol production remained high. Ethanol concentration still increased approximately linearly with time. The high ethanol production rate is caused by high amounts of heterologously expressed ADH and PDC ( Fig. 1f-h). In phase III, 17-28 days post inoculation, growth remained stopped, and ethanol production of the producer line came to a standstill. PDC and ADH in vitro enzyme activities remained high throughout the entire cultivation (Fig. 1g, h), which strongly indicates a significant level of genetic stability of this ethanologenic gene cassette in Synechococcus 7002 for cultivation periods of at least 30 days. In contrast to the variable growth profile of the ethanol producer, Synechococcus 7002 WT maintained linear growth throughout the complete cultivation period. Suspensions of producer and WT cultivations differed in color. Chlorophyll content of the WT increased in phase I and declined in the further course of cultivation, whereas it did not increase in the producer strain and remained lower at 60-80% of the WT level (Fig. 1c). In addition, according to the Coomassie-stained SDS-PAGE (Fig. 1f ) the amount of phycobiliproteins was reduced in the producer strain, especially in phase III after prolonged cultivation.
During phase I, the producer cells showed a significantly higher (about 1.5-fold) maximum photosynthetic rate (P max ) than the WT ( Fig. 1d; Additional file 1). Such a stimulation of photosynthesis has been already reported for cells of S. elongatus PCC 7942, which produced and excreted sucrose into the medium [11]. While the stimulation of photosynthesis was stable for many days in sucrose-producing cells [11], the photosynthetic activity of ethanol-producing cells of Synechococcus 7002 decreased quickly from this early maximum rate with ongoing cultivation (Fig. 1d). In phase II, the maximum photosynthetic rate of producer cells declined to ~60% of the WT level and became even lower during phase III. This decline in photosynthetic rate and the decrease in growth of producer cells likely resulted from ethanol production, causing an imbalance in primary carbon metabolism within the cell. It should be noted, however, that ethanol production is generated by high levels of expression of PDC and ADH (Fig. 1g, h). As such, a direct but non-specific impact of this level of protein overexpression and/or intracellular ethanol accumulation could have also had a negative effect on growth and photosynthetic rate. However, any effect on physiological properties (performance) caused by ethanol accumulation in the culture medium can be excluded. The final ethanol concentration in phase III without vapor-liquid equilibrium (VLE) correction was on average 0.19% (v/v) and never exceeded 0.23% (v/v) in the medium (Additional file 1). This concentration is far below the ethanol tolerance limit of Synechococcus 7002. Synechococcus 7002 is more tolerant against ethanol than the freshwater strains such as Synechocystis 6803 or S. elongatus PCC 7942 and has been shown to tolerate up to 0.2 M (approximately 1.16% v/v) ethanol in the medium without significant growth decline [23]. Ethanol tolerance of the producer strain was further supported by the finding that the overall partition of newly fixed organic carbon into ethanol increased from about 50% in phase I to almost 80% at the end of phase II and in phase III ( Fig. 1e; Additional file 1). Thus, the relative carbon loss to ethanol relative to total organic carbon increased in parallel to decreased growth and photosynthetic activity of the producer.
Consistent with the physiological data, in phase I metabolism of WT and the producer strain were overall quite similar but beginning to show distinct differences (Fig. 2a). Over the course of phases II and III, producer and WT metabolism became increasingly divergent. This  trend is readily apparent through analysis of the differential metabolome profiles, i.e. log 2 -transformed ratios of producer over WT at each time point (Fig. 2b). Even though we differentiate three metabolic phases of ethanol production for the structured presentation of our results, it should be noted that these phases do not imply stepwise transitions between metabolic states. Instead, metabolic changes were continuous and in part overlapping. For example, glycolate-2-phosphate (2PG) and glucose-6-phosphate (Glc6P) transiently increased towards the end of phase II and at the beginning of phase III in a period 14-17 days post inoculation (Fig. 2b).

The carbon drain from the pyruvate pool limits pools of the pyruvate amino acid family
Ethanol production in Synechococcus 7002 diverts assimilated carbon from the pyruvate pool via acetaldehyde into ethanol. Between 50 and 80% of the organic carbon is irreversibly lost by diffusion of ethanol from the cell into the cultivation medium (Fig. 1e). This should decrease the pool size of pyruvate and all other pyruvate-based metabolites. Pyruvate was not detectable by routine non-targeted gas chromatography-electron impact ionization-mass spectrometry (GC/EI-TOF-MS) based metabolite profiling both in the WT and the producer strain, even by analysis of high biomass (approximately 15OD 750 equivalents of cultivated cells). For this reason we established multi-targeted gas chromatography-atmospheric pressure chemical ionization-mass spectrometry (GC/APCI-qTOF-MS) analysis with enhanced sensitivity. However, pyruvate still remained below the detection threshold of the enhanced method. As a consequence, we used pyruvate-dependent pathways and respective metabolite pools as proxies of the effects of the carbon drain from the pyruvate pool during phase I and subsequent cultivation (Fig. 3). The initial changes of primary metabolism in phase I are shown in Table 1. Metabolites with changed pool sizes are defined by T test significance P < 0.05 at day 3 and 7. Most of the metabolites with decreased pool sizes were either direct products of pyruvate, such as alanine and the branched chain amino acids isoleucine and valine, or dependent on carbon flux through the pyruvate pool and the 2-oxoglutarate (2OG) branch of the tricarboxylic acid (TCA) cycle, specifically glutamate, N-acetyl-glutamate, glutamine and pyroglutamate. Furthermore, succinate and succinate semialdehyde were significantly decreased in phase I. These metabolites are connected by the recently discovered alternative pathways, which close the cyanobacterial TCA cycle that lacks the 2OG dehydrogenase reaction [24][25][26]. In addition, the glycerate and glycerophosphoglycerol pools were decreased. Only the glycine pool and a yet non-identified metabolite were significantly increased in phase I (Table 1).
Based on the observed reprogramming of primary metabolism of ethanol production in phase I, we hypothesized that an excessive carbon drain from the pyruvate pool interfered immediately with biosynthesis of alanine and branched-chain amino acids (BCAAs), which all directly require pyruvate as building blocks. This hypothesis was supported by continued and increased deficiency of these amino acids in producer cells during phases II-III (Fig. 3), whereas pools of alanine, valine, isoleucine, and in the later phases also of leucine significantly increased in WT cells over time. These observations indicate a continued limitation for the pyruvate family of amino acids in ethanol-producing Synechococcus 7002 cells (Fig. 3), consistent with the enhanced carbon partitioning into ethanol in phase III.
In addition, major parts of nitrogen metabolism were down-regulated, most probably due to limitation of carbon precursors. A detailed analysis of the 2OG branch of the TCA cycle showed that the producer strain became significantly deficient for 2OG and isocitrate/citrate throughout phases II-III (Additional file 2; note that the available analyte of this GC-MS based metabolite profiling study monitored the sum of the isocitrate and citrate pools). In comparison, the glutamate/glutamine/pyroglutamate deficiency was present throughout phase I-II and increased further in phase III (Additional file 2). Deficiency in nitrogen metabolism extended towards the proline and N-acetyl-glutamate pools (Additional file 3). This global decrease in N-assimilation could reflect a general cellular carbon-limitation that in turn diminishes the GS/ GOGAT pathway for ammonia assimilation, as has been observed in cyanobacterial cells under inorganic carbon (Ci) limitation, i.e. after transfer from high to low CO 2 (See figure on previous page.) Fig. 2 Global evaluation of metabolome analyses of the time course of ethanol production in an engineered Synechococcus 7002 producer strain compared to WT. a Principal component analysis (PCA) of log 2 -transformed metabolite pool size changes of producer and WT relative to the mean of each metabolite across all samples. Principal components, PC1 and PC2 represent 51.1 and 26.9% of total variance in the data set. b Hierarchical cluster analysis (HCA) of differential profiles, i.e. log 2 -transformed ratios of producer over WT at each time point. HCA was performed using Euclidian distance and average linkage. Data are averages of two producer and two WT batch cultures, respectively. Cells from each culture were harvested 6 times at each time point in the middle of a 12 h light phase (±10 min) as described under "Methods" section. WT and producer were probed in parallel, not sequentially. Cultivation phases I-III were assigned according to the matching PCA and HCA results conditions (e.g. [27][28][29]). Succinate semialdehyde levels behaved similar to the metabolites of the 2OG branch, i.e. its level was about twofold lower in the producer during the entire fermentation experiment (Additional file 2). This compound is synthesized from the precursors glutamate and 2OG in two alternative pathways closing the TCA cycle [24,26], which also were diminished in producer cells. This consistent behavior indicates that the TCA cycle is less closed in ethanol-producing cells than in WT cells possibly due to the lowered overall carbon flux into the 2OG branch.
In contrast to glutamate, the aspartate pool remained unchanged in the producer strain compared to WT except towards the end of phase III (Additional file 4). This observation led us to the analysis of potential mechanisms that may compensate the effects of carbon drain from central metabolism. One mechanism that apparently contributes to aspartate homeostasis was the downregulation of the C4-branch of the TCA cycle including the malate, fumarate and succinate pools in phases I-II (Additional file 4). We interpreted the depletion of the C4-branch of the TCA cycle as both recruitment of oxaloacetate for aspartate synthesis and of malate for pyruvate anaplerosis via decarboxylating malate dehydrogenase (malic enzyme) if pyruvate production from PEP by ATP producing pyruvate kinase becomes limiting. This anaplerotic reaction has been shown before to be the main route of newly fixed carbon via phosphoenolpyruvate (PEP) carboxylase in Synechocystis 6803 [30]. The compensation appeared to become deregulated (limited) and fails at the end of phase III, because then malate and fumarate increased strongly, 8.3-and 7.7-fold, respectively, whereas the succinate pool aligned to WT levels. This change may be related to the late mobilization of glycogen reserves in producer cells (discussed below).
Due to the decrease of the 2OG, glutamate and succinate semialdehyde pools, the C4-branch of the TCA cycle cannot be replenished by reactions that allow closure of the cyanobacterial TCA cycle via the γ-aminobutyrate (GABA) shunt or the 2OG decarboxylase path [24,26]. The pool of succinate semialdehyde, which is a central intermediate of both pathways, was even more depleted than the succinate pool in the producer strain. This observation indicates that succinate is partly generated from fumarate in the C4-branch of the TCA cycle. Only in the WT, but not in the producer strain, was succinate semialdehyde highly correlated (Pearson's correlation coefficient r > 0.750) with 2OG and glutamate/ glutamine/pyroglutamate levels, but also with succinate pools (Additional file 5). These observations indicated that the TCA cycle was partly closed via succinate semialdehyde in the WT but was almost open in the producer strain due to the depletion of carbon flux into the TCA cycle.

The carbon drain from the pyruvate pool is initially compensated but ultimately extends into the Calvin-Benson-Bassham (CBB) cycle
To further understand the homeostasis of the aspartate pool in the producer strain, we investigated the PEP pool and the upstream glycolytic pathway. Aspartate is generated by aspartate aminotransferase from oxaloacetate that in turn is the product of PEP carboxylase. This reaction bypasses the pyruvate pool and assimilates an additional carbon atom via carboxylation. While oxaloacetate like pyruvate was not detectable by our methods, PEP, 2-phosphoglycerate (2PGA) and 3-phosphoglycerate (3PGA) were accessible. The producer strain compensated and at day 7 of cultivation even over-compensated the carbon loss by ethanol production in phase I, since the pools of 3PGA and 2PGA were similar or in the case of PEP slightly increased compared to WT (Fig. 4). However, starting with phase II, all three pools became depleted. This observation was in agreement with the low flux rate through the pyruvate kinase reaction compared to the equally high fluxes through the enolase and phosphoglycerate mutase reactions, which were modeled for Synechocystis 6803 under photoautotropic conditions [30]. 3PGA, PEP and pyruvate levels are strongly depleted under photomixotrophic compared to photoautotrophic conditions [31]. Therefore, photomixotrophic conditions are difficult to compare to our study. However, the flux rate through the pyruvate kinase reaction also remains lower compared to the enolase flux under photomixotrophic [32] and autotrophic conditions [33]. The joined depletion of PEP, 2PGA and 3PGA in our study was accompanied by a consistent increase of intracellular inorganic phosphate indicating an overall loss of phosphorylated intermediates in the producer strain (Fig. 4). In phase III, specifically at day 21, 3PGA decreased ~tenfold relative to WT and was the most depleted compound among all monitored metabolite pools (Additional file 3). At this point the enhanced ethanol production in Synechococcus 7002 seems to cause an increasingly unbalanced carbon drain from central metabolism, which was initially compensated for. This drain is not met by sufficiently enhanced carbon assimilation rates because photosynthetic activity continuously declined after phase I (see Fig. 1d). As a consequence this imbalance first leads to a cessation of growth, and subsequently, of ethanol accumulation.

The producer strain accumulates major carbohydrates
Based on the observed progressive and joined depletion of the 3PGA, 2PGA and PEP pools we asked the question whether the major carbohydrate metabolism was equally affected by the carbon drain. An initial correlation analysis, however, indicated an inverse correlation of major carbohydrates to 3PGA in the WT (Table 2). This inverse correlation of glucose or fructose, for example, was still present in the producer strain but attenuated. In detail, we unexpectedly found increased glucose, fructose, sucrose and Glc6P levels from phase II onwards (Additional file 6). We verified sucrose accumulation in phase III by independent cultivation experiments for exact quantification of pool sizes and found in addition significant glycogen accumulation in the producer strain in phases II-III (Fig. 5). Glycogen serves as the main carbon storage molecule in cyanobacteria, which is typically Table 1 Phase I changes of primary metabolism comparing the Synechococcus 7002 producer to WT Log 2 -transformed initial changes, i.e. response ratios of producer over wild type (WT), at low ethanol concentration (Fig. 1), were calculated and significance tested P < 0.05 using the t test (italics font: P < 0.0001) a Pyroglutamic acid represents the sum of the glutamine, pyroglutamic and glutamic acid pool accumulated in cells at excess carbon assimilation, for example, under conditions of nitrogen deprivation and iron deficiency. Glycogen is subsequently degraded under carbon-deficient conditions, such as dark periods to provide carbon precursors and energy [34,35]. Contrary to our expectations, the Synechococcus 7002 producer strain did not efficiently mobilize glycogen and soluble carbohydrates for 3PGA anaplerosis and thus for the maintenance of the CBB cycle. The producer strain rather intensified the 3PGA deficiency by further withdrawing carbon for carbohydrate, specifically glycogen, accumulation. This behavior indicates that the ethanol-producing cells may not be generally limited by Ci assimilation but rather by the regulation of carbon allocation into different carbon pools. Specifically, a yet unknown regulatory mechanism linking major carbohydrate metabolism to the CBB cycle seems to be affected by ethanol production. This is in distinct contrast to CO 2 -limited cells of S. elongatus PCC 7942 and Synechocystis 6803 where we observed a coordinated decrease of CBB cycle intermediates, soluble carbohydrates and glycogen [29,36].

The producer strain maintains high osmolyte concentrations in phases I and II
Because Synechococcus 7002 cultivation was performed in artificial seawater at 35 practical salinity units (PSU), we assumed that osmolyte biosynthesis presents a possibly competing mandatory carbon sink, since it is required for survival under the chosen culture conditions. Synechococcus 7002 accumulated the main compatible solute glucosylglycerol (GG) under our cultivation conditions to a level of 30-50 nmol mL −1 OD −1 750 ( Fig. 5; Additional file 3). GG is synthesized from glycerol-3-phosphate and ADPglucose [4,37]. The producer strain maintained almost WT levels of GG up to the end of phase II (Fig. 5). In parallel glycerol-3-phosphate levels were slightly increased relative to WT, whereas glycerol levels in the producer did not differ from WT (Additional file 3). However, in phase III the GG pool continuously decreased in producer cells, while it was kept constant in the WT (Fig. 5). At the same time, amounts of sucrose, fructose and glucose levels increased. We hypothesized that the Synechococcus 7002 producer strain used sucrose and possibly glucose and fructose as secondary osmolytes, when GG levels could not be maintained in phase III ( Fig. 5; Additional file 6). But the total pool of osmotic active substances such as GG and soluble sugars was clearly lower than in WT cells during phase III. Thus, the requirement for osmolytes and survival may represent one reason why anaplerosis of the CBB cycle from soluble carbohydrate pools in the Synechococcus 7002 ethanol producing strain is not effective under seawater conditions. The observed imbalance in osmoregulation in the ethanol producer strain of Synechococcus 7002 could additionally contribute to the decrease in ethanol productivity, growth and maximum photosynthetic rate starting from phase II.

The producer strain accumulates aromatic amino acids
Tyrosine and phenylalanine pools and to a smaller degree lysine were increased in phases II and III. In contrast, the shikimate pool was depleted throughout all phases even though the PEP pool was initially maintained or even increased (Additional file 7). Thus, the accumulation of aromatic amino acids was unlikely caused by de novo synthesis. As a consequence we hypothesized that the accumulation of aromatic amino acids was caused by compensatory protein degradation, which is used to refill the decreased amino acid pools (see Table 1; additional file 3). Proposed protein degradation is consistent with the decreased amount of phycobilisomes in the producer cells (Fig. 1f ). We argue that aromatic amino acids are less readily catabolized than other amino acids and cannot rapidly be used for anaplerosis of central metabolism.

The metabolome of the producer strain indicates increased photorespiration
Because the ethanol-producer strain showed increasing 3PGA deficiency, we asked the question of whether the photorespiratory C2-cylce was activated, which converts  (mean values and standard deviation of two independent experiments with three technical repeats each). Sucrose: nmol mL −1 OD −1

750
(mean values and standard deviation of two independent experiments with three technical repeats each) two molecules of the oxygenase product 2PG into one molecule of 3PGA [38]. 2PG was found at increased levels throughout all phases of ethanol production, whereas glycolate levels increased from phase II onwards (Additional file 8). In addition, the amino acid pools of glycine and serine increased significantly and peaked in phase I. These changes of photorespiratory C2-cycle intermediates did not extend into the glycerate pool which was depleted throughout (Additional file 3). Our previous analyses of acclimation processes during Ci limitation revealed the photorespiratory burst as central response in Synechocystis 6803. The photorespiratory burst characterizes a transient followed by a longer term adjustment of the 2PG, glycolate, glycine, serine pools, but not of glycerate [28,39,40] in CO 2 -limited WT cells. Similar changes were detected in photorespiratory mutants of Synechocystis 6803 that either lack essential enzymes of the photorespiratory C2-cycle [36,41] or proteins to form carboxysomes [42]. These mutants already increased the pools of the photorespiratory C2-cycle intermediates under CO 2 -supplemented conditions. Here we found the similar accumulation of photorespiratory intermediates in the Synechococcus 7002 producer strain when cultivated under high CO 2 conditions (10%, v/v). Therefore, we concluded that ethanol production induced increased photorespiration, which could be due to the decreased pools of specific organic carbon intermediates that may act in WT cells as signal molecule(s) for inducing the response to Ci limitation, or due to an increased permeability of carboxysomes for oxygen in the presence of cellular ethanol.

Primary metabolism of ethanol production by enhanced Synechococcus 7002 partially phenocopies Ci limitation
Because enhanced ethanol production in the Synechococcus 7002 producer strain pointed in many aspects to intracellular carbon limitation, we performed a metaanalysis of the differential metabolome profiles of the producer over WT compared to Ci limitation of Synechocystis 6803 when shifted from high 5% CO 2 -to low 0.04% CO 2 -supply [36,39]. We also included the data of a recently characterized Synechocystis 6803 mutant that can serve as model of engineered intracellular inorganic carbon (Ci) limitation, i.e., the ∆4 quadruple mutant (∆ndhD3/ndhD4/cmpA/sbtA-∆sll1733/sll0027/slr0040/ slr1512), which lacks 4 of the 5 Ci-uptake systems [40,43,44]. This meta-analysis was enabled by the high CO 2 cultivation system used in our study and by the fact that the previous studies of Synechocystis 6803 described the carbon limitation induced changes of metabolism relative to the respective high CO 2 -acclimated WT.
The meta-analysis supported the view that many of the metabolic changes caused by ethanol production in Synechococcus 7002 mimic metabolic responses to Ci limitation that were previously observed in Synechocystis 6803 (Fig. 6). Specifically, the increase of photorespiratory intermediates, the parallel decrease of nitrogen metabolism and of TCA cycle intermediates as well as the increase of aromatic amino acids and lysine and finally the initial but transient compensatory increase of PEP, 2PGA and 3PGA all mirrored metabolic effects of Ci limitation. Differences were observed: (1) in pyruvate dependent branched-chain amino acids, which were depleted in the Synechococcus 7002 producer strain but increased by Ci limitation in Synechocystis 6803; (2) in the increased glycogen levels in the ethanol producing cells of Synechococcus 7002 compared to the lowered pool in Ci-limited Synechocystis 6803 cells (e.g. [36]); and (3) in the likely seawater cultivation dependent accumulation of soluble carbohydrates that decreased in freshwater cultivated Synechocystis 6803 (Fig. 6).

Proteome analysis supports the notion of decreased carbon metabolism in the producer strain
The changes in the metabolome could result from changed enzyme abundances and/or regulation of enzyme activities at the post-translational level, for example via protein phosphorylation [45,46]. For identification of changes in protein accumulation proteome analysis was performed using the 2-dimensional gel electrophoresis (2-DE) based method of protein separation with subsequent spot identification via mass spectroscopy (MS). This method does not represent the entire proteome, for example membrane proteins and proteins of low abundance are missing, whereas soluble proteins of the primary metabolism are well displayed (e.g. [47]). For analysis, sampling points at the transition from phase I to II (day 8) and at the transition into phase III (day 22) were selected. About 1700 spots were detected on the 2-DE gels. 192 spots showed potentially increased or decreased levels; however, 60% of those spots exhibited non-treatment specific variations, such as significant variations between replicates. Hence, only 75 spots showing reproducible treatment-related alterations were picked and the proteins identified. In this analysis we have focused our discussion on proteins with altered abundance ( Table 3) that represent enzymes related to primary carbon metabolism or are involved in the cyanobacterial stress tolerance.
Only few proteins showed increased abundances in producer cells compared to WT. As expected, the engineered PDC converting pyruvate into acetaldehyde was strongly over-expressed at protein level in the producer. Furthermore, the producer accumulated both, the core protein CcmM and the shell protein CcmK of carboxysomes [48] early and late in cultivation in comparison to WT (Table 3). This observation indicates that producer cells try to compensate the internal organic carbon limitation or carboxysome instability by an increased accumulation of carboxysomal proteins to maintain high photosynthetic CO 2 assimilation. This interpretation is also supported by the metabolic data of phase I and the initially elevated maximum photosynthetic rate of the producer (Fig. 1d). The glycerol dehydrogenase was the only enzyme involved in primary carbon metabolism that increased in abundance in producer cells, which also accumulate higher levels of glycerol-phosphate. Interestingly, producer cells increased the abundance of several proteins that are involved in the general stress response of cyanobacterial cells. For example, the flavoprotein Flv3 (ACA99318) was highly up-regulated. This protein is known to catalyze the transfer of electrons from reduced ferredoxin towards * represents the sum of the metabolites in brackets log 2 (Response RaƟos) Fig. 6 Meta-analysis of the differential profiles of the Synechococcus 7002 producer relative to WT compared to extracellular carbon limitation of the Synechocystis 6803 WT 3 h (WT_3 h LC) and 24 h (WT_24H LC) after shift from high (5%) to low (0.04%) CO 2 supply [39,40] and to intracellular carbon limitation under high CO 2 conditions of the ∆4 quadruple mutant of Synechocystis 6803 (∆4_24 h HC), which lacks 4 of the 5 Ci-uptake systems [40,43,44]. Note that all response ratios represent differential profiles of log 2 -transformed ratios calculated relative to the paired high CO 2acclimated WT of the respective study (Additional file 11) O 2 producing H 2 O in a Mehler-like reaction, which is assumed to function as energy dissipation system under high light or redox stress conditions [49][50][51]. In addition, the stress-induced chaperonins, GroEL, GroES and GroE-LII increased especially at the early time point. These proteins are involved in the assembly and repair of soluble proteins in the course of diverse stress treatments. For example, the GroEL and GroES chaperonins are induced by heat [52] and salt shock [47]. These observations may indicate that producer cells face a general stress situation possibly due to the imbalanced carbon metabolism. In addition, the lower cell density of the producer culture most probably enhances cell stress because of higher light intensity reaching these cells compared to WT (Fig. 1b). Similar results were found with cells of Synechocystis 6803 producing isoprene [7]. In contrast to our proteomic analysis, Qiao et al. [53] have examined changes in the proteome of Synechocystis 6803 in response to externally supplied ethanol. In this study, much higher concentrations of ethanol were used than the ethanol producer characterized in our study was able to accumulate. It is not surprising that there is only limited overlap between the two studies in terms of proteome response. For example, the heat shock protein GroES became elevated both by ethanol production as well as external ethanol application. In addition several metabolic proteins and surprisingly, photosynthesis proteins were found at decreased levels in response to ethanol, but only the amount of pyruvate dehydrogenase was also found to be decreased in our study.
Most of the observed and identified proteins show a lower abundance in the producer strain (Table 3). Among them are many enzymes involved in primary carbon metabolism. This finding is consistent with the observed intracellular carbon limitation. Specifically, the CBB enzymes phosphoribulokinase (Prk) and glyceraldehyde-3-phosphate dehydrogenase (GapI) are strongly downregulated at protein level in agreement with the metabolic depletion of 3PGA. In terms of pyruvate metabolism we found pyruvate dehydrogenase I with lower levels in the producer strain. This observation is consistent with a compensation reaction that potentially counteracts pyruvate depletion. Likewise, PEP synthase is not up-regulated at day 22 in the producer in comparison to WT. Again the missing activation of PEP synthesis from pyruvate is in agreement with pyruvate depletion.
Interestingly, the regulatory PII protein (GlnB), which has been identified as the central regulator of cyanobacterial nitrogen assimilation [54], also showed lower protein levels that are consistent with the generally decreased nitrogen metabolism found by our metabolome analysis. In addition, the GG-phosphatase synthase (GgpS) is lowered in the producer at both time points and thus reflects the lowered GG production. The P-protein subunit of glycine decarboxylase (GcvP) that is the active subunit for the glycine cleavage [55] is lowered in the producer contrary to expectations. Based on the metabolic indications of enhanced photorespiration one would expect intensified detoxification/recycling through the C2-cycle, but the glycine cleavage system protein P is decreased in the producer in comparison to WT. While the protein abundance of GcvP increased in WT from day 8 to day 22, this is not the case for the producer. This observation may explain why glycine remains highly increased in the producer.

Conclusions
Our study revealed progressive intracellular organic carbon limitation caused by excessive carbon drain from central metabolism via ethanol loss. This conclusion is supported by the general trend of down-regulation of many associated enzymes. The pyruvate pool emerged as a likely limiting factor of ethanol production in Synechococcus 7002. The carbon drain was initially compensated for, but ultimately 3PGA depletion as a result of ethanol synthesis apparently interfered with efficient carbon assimilation through the CBB cycle and with the production of GG. GG, the main carbohydrate-based osmolyte of Synechococcus 7002, needs to be accumulated at a salinity-proportional level to maintain growth and cellular activity in seawater [37]. These metabolic imbalances transfer the producer cells into a stressful situation. Our systems analysis and the discovery of the three ethanol production phases lays the groundwork for future flux analyses experiments that require precise timing of the stable isotope pulse to unravel the paths of carbon utilization [33,41]. Such experimental approaches and 13 C metabolic flux analysis will allow identification of new design strategies for cyanobacterial metabolism [56,57] and help to define limitations, such as the tradeoff between photosynthetic and metabolic robustness that apparently needs to be taken into account when engineering light-driven metabolic production processes [58]. On the basis of these observations, improvements in ethanol production could be accomplished by increasing the photosynthetic capacity of the cyanobacterial cell. Similar attempts have been reported, where the main carboxylating enzyme ribulose 1,5-bisphosphate carboxylase/oxygenase (RubisCO) has been over-expressed to improve the biofuel production with S. elongatus PCC 7942 [59]. Recent modeling studies suggested that adjustment of the relative intracellular ATP and NADPH concentrations according to the demands of biofuel production could substantially boost productivity [60]. Specifically, a lowered ATP to NADPH ratio than that generated by linear photosynthetic electron transport chain was predicted to increase ethanol yields. It is possible that this advantageous lower ratio and the anticipated increase in ethanol production could be achieved in vivo by moderately increasing ATP turnover through the addition of ATP wasting mechanisms, such as futile cycling [56]. In conclusion, a better understanding of the regulatory mechanisms of primary carbon metabolism that integrates ATP and NADPH cofactor demands will be helpful for the specific re-directing of newly assimilated carbon to rate-limiting or survival relevant metabolic pools.
The ethanologenic plasmid #1449 contains the pyruvate decarboxylase gene from Zymomonas mobilis (zmPDC) under control of the Co 2+ inducible promoter PcorT from Synechocystis 6803. CorR, encoding the transcriptional activator of corT was also cloned on plasmid #1449 (corR sll0794 and corT slr0797). In addition, the ethanologenic gene cassette of the ethanol-producing strain #1449 contains the Synechocystis 6803 alcohol dehydrogenase (slr1192) under the transcriptional control of the genetically engineered P rbc*(optRBS) promoter. The plasmid #1449 (Additional file 9) is based on pVZ322a, which is a derivative of pVZ321 [61]. Plasmid #1449 was generated by cloning the corR-PcorT-zmPDC-TdsrA cassette into plasmid pVZ322a using SalI/SbfI sites for restriction and ligation. This cloning step removes the chloramphenicol resistance cassette (CmR) from the pVZ322a backbone and adds a unique SpeI restriction site between the TdsrA terminator and the SbfI site by insertion of the corR-PcorT-zmPDC-TdsrA expression cassette. The Prbc*(optRBS)-synADH-Toop expression cassette was inserted subsequently via SpeI/SbfI to form the final ethanologenic construct #1449 (Additional file 9).

Cultivation conditions and sampling of Synechococcus 7002 ethanol producer and WT
WT and ethanol producer were cultivated in four replicates, each for 32 days, in 9-L vertical bioreactors. The bioreactor vessels are of 5 cm diameter. Cultures of WT and ethanol producer were grown under identical conditions in marine ASW (artificial seawater) medium, which is based on ASN-III medium [62] and adjusted to a salinity of 35 PSU (practical salinity unit). ASW is very similar to the cultivation medium used in Dienst et al. [14], where essentially BG11 medium [63] was supplemented with 35 g L −1 instant-ocean seawater salts (Aquarium Systems Inc, France) resulting also in 35 PSU. For growth of Synechococcus 7002 Vitamin B12 was added to the media (0.004 mg L −1 ). The cultivation vessel was fitted with ports for incoming pH-and temperature-sensors as well as sampling ports and connections to in-and out-gas. Cells were grown under day-night cycle conditions with a 12-h photoperiod. The light intensity was 230 μmol m −2 s −1 throughout this study. The culture temperature was controlled in a day-night cycle with a 37 °C daytime and 25 °C nighttime temperature. The cultures were continuously mixed by aeration, applying a gas flow rate of 250 mL min −1 , to avoid settling of cells and the generation of sub-populations with different illumination. For the provision of sufficient CO 2 , the liquid phase was aerated with CO 2-enriched air (10% CO 2 ), by a pH-dependent and computer-controlled system. Induction of ethanol synthesis from the P corT promoter in #1449 was triggered by adding 5 µM Co(NO 3 ) 2 to the reactor directly after inoculation on day 1 of cultivation.

Monitoring of growth, chlorophyll content, ethanol production and total organic carbon (TOC)
Optical density (OD) was recorded at 750 nm 5 days per week. Chlorophyll contents were measured 3 times per week by spectrophotometry after extraction in 90% methanol [64]. Quantification of ethanol in the liquid phase was accomplished by head-space gas chromatography (GC) using a Shimadzu GC 2014 gas chromatograph as described by Dienst et al. [14]. To monitor ethanol production, the ethanol concentration in the liquid phase of the cultures was determined 5 days per week. In addition, the ethanol loss due to evaporation was calculated and experimentally verified. The ethanol concentration that is corrected for ethanol loss is called vapor-liquid equilibria (VLE) corrected ethanol. VLE-corrected and non-corrected data are given in Additional file 1.
The total carbon (TC) and the total inorganic carbon (TIC) were measured with a TOC analyzer TOC-VCPH equipped with an autosampler ASI-V and a combustion catalytic oxidation/non-dispersive infrared (NDIR) gas analyzer (Shimadzu Deutschland GmbH, Duisburg, Germany). The total organic carbon (TOC) was calculated using the differential method subtracting TIC from TC (TOC = TC − TIC). The calibration was made with commercially available standards (Bernd Kraft GmbH, Duisburg, Germany) and automatic dilution of standards using MilliQ water. The calibration range was from 5 to 500 mg C L −1 for TC and from 1 to 100 mg C L −1 for TIC. TOC was determined using whole culture volumes (cells plus medium). Samples were diluted with MilliQ water to a concentration of 20-180 mg C L −1 (estimated based on culture OD and ethanol content) in volumetric 50 mL flasks using volumetric pipettes. The diluted samples were transferred into 40 mL screw cap glass vials containing a magnetic stir bar (length: 1.2 cm) and sealed with a cap. For the measurement, a sample volume of 60 μL was injected into the TOC analyzer. Injections were repeated 3-5 times per measurement to obtain a mean value with a maximum standard deviation of 0.1.

Assays to determine PDC and ADH activities in cell extracts of cyanobacterial cultures
For measurements of PDC and ADH activities in cell extracts of the ethanol producer strain, 1-20 mL cultures with a total OD 750 of 10 were spun down (4500×g, 10 min at 4 °C). After cell lysis and centrifugation (13,000×g, 10 min at 4 °C), the supernatant was transferred into a fresh pre-chilled tube and the activities of PDC and ADH measured by opto-enzymatic assays.
To measure PDC activity a coupled enzyme assay was used: pyruvate (CAS 113-24-6, Sigma-Aldrich, Munich, Germany), added to the assay is converted in the presence of thiamine pyrophosphate (CAS 154-87-0, Sigma-Aldrich, Munich, Germany) by PDC in the cell extract of the ethanol producer to acetaldehyde. Acetaldehyde is then reduced to ethanol by ADH from Saccharomyces cerevisiae, added in excess to the reaction (CAS 9031-72-5, Sigma-Aldrich, Munich, Germany). The reaction consumes nicotinamide adenine dinucleotide (NADH). The PDC activity is determined by measuring the decrease in absorbance of NADH at 340 nm min −1 .
To measure ADH, both, acetaldehyde and NADPH are added to the assay (CAS 75-07-0 and 2646-71-1, respectively, Carl Roth GmbH, Karlsruhe, Germany). Acetaldehyde is converted by the ADH in the cell extract of the producer to ethanol, oxidizing NADPH. The ADH activity is determined by measuring the decrease in absorbance of NADPH at 340 nm min −1 . The specific activity of PDC and ADH was calculated by normalizing the activity to the total soluble protein concentration (mg mL −1 ) of the centrifuged lysate supernatant as determined by the method of Lowry et al. [65] and expressed as units of enzyme activity (µmol*min −1 *mg (protein) −1 ).

Photosynthetic measurements
Rates of photosynthetic oxygen evolution and oxygen consumption rates were measured with a Clark-type oxygen electrode (Rank Brothers, diameter 1 cm) at 37 °C. PI (photosynthesis irradiance) curves of the bicarbonate dependent photosynthetic oxygen evolution were measured for the WT and ethanol-producing culture at several days of cultivation. The cultures were diluted to the same amount of chlorophyll (2.5 µg) per mL in fresh medium supplemented with 5 mM NaHCO 3 . Light intensities were varied in the range 0-600 μmol photons s −1 m −2 . The PE curves were analyzed according to Webb et al. [66] for P max (oxygen evolution at saturating light intensities).

Quantification of glucosylglycerol, sucrose and glycogen
Low molecular mass solutes were extracted from the cell pellets with 80% ethanol (HPLC grade, Roth, Germany) at 68 °C for 2 h. To quantify the internal amount of the molecular mass solutes, a defined amount of sorbitol was added to the samples as an internal standard. The extracts were centrifuged (13,000g, 5 min, 20 °C) and the supernatant was lyophilized. Dried pellets were suspended in distilled water and centrifuged (13,000g, 5 min, 20 °C) again. The supernatant was transferred to a new tube and lyophilized again. The final lyophilized extract was dissolved in pyridine, silylated and analyzed by gas chromatography (GC) according to Hagemann et al. [67].
Intracellular glycogen content was quantitatively measured using a colorimetric biochemical assay. Cells from 2 mL of culture were harvested and the pellet was re-suspended in 500 µL 80% ethanol (HPLC grade, Roth, Germany) and incubated for 2 h at 68 °C. The extracts were centrifuged (13,000g, 5 min, 20 °C) and the supernatant was used for the analysis of organic low molecular mass solutes, whereas the cell pellet was used for the glycogen determination. Then, the cell pellet was dried by lyophilization and re-suspended in 500 µL 30% (w/v) KOH. After incubation for 1 h at 100 °C the samples were cooled down and 625 µL of 95% (v/v) ethanol (HPLC grade, Roth, Germany) was added. The samples were again incubated at 100 °C for 15 min and afterwards centrifuged at 14,000 rpm for 10 min (20 °C). The resulting pellet was suspended in 500 µL deionized H 2 O at 100 °C for 15 min. After cooling on ice, 1 mL of freshly prepared anthrone reagent (200 mg anthrone in 100 mL 95% H 2 SO 4 ) was added to the samples. The dye complex developed at 100 °C for 15 min, which was measured at 625 nm after a last cooling step. The resulting absorbance values were evaluated after comparison to a glycogen standard curve.

Non-targeted metabolite profiling by gas chromatography-time of flight-mass spectrometry (GC/ EI-TOF-MS)
6 technical replicates from two independent cultures of WT and producer, respectively, were harvested within less than 30 s until metabolic inactivation [36,41] by fast filtration onto 25 mm diameter glass microfiber filters with 1.2 µm pore size (GE Healthcare, Little Chalfont, England), followed by immediate shock freezing [41]. Sampling by filtration was chosen instead of a freezequenching method because metabolic inactivation of cyanobacteria by freeze-quenching leads to a massive loss of intracellular metabolites during preparation [68]. Sampling was in the middle of the 12-h light phase over a period of 20 min. WT and producer cultures were sampled in parallel, not sequentially. Due to the changing OD in the course of cultivation, OD 750 was measured at each sampling time before harvest and a respective volume was harvested (approx. 15 mL of an OD 750 = 1.0 culture). Exact OD 750 equivalents were recorded of each sample.
GC-MS based metabolite profiling including retention index (RI) standardization and chemical derivatization for GC analysis was performed as specified by Dethloff et al. [69]. One microlitre of standardized and chemically derivatized sample was injected onto a 30 m length, 0.25 mm inner diameter and 0.25 μm film thickness Varian Fac-torFour (VF-5 ms; Varian-Agilent Technologies, Waldbronn, Germany) capillary column coupled to electron impact ionization time-of-flight mass spectrometry (GC/ EI-TOF-MS). GC/EI-TOF-MS was performed using an Agilent 6890N24 (Agilent Technologies, Waldbronn, Germany) gas chromatograph hyphenated to a LECO Pegasus III time-of-flight mass spectrometer as described [69]. Chromatograms were acquired and baseline corrected by ChromaTOF software (LECO Instrumente GmbH, Mönchengladbach, Germany). Metabolites were identified manually supervised using the TagFinder [70], the NIST08 software (http://chemdata.nist.gov/) and the mass spectral and retention time index (RI) reference collection of the Golm Metabolome Database [71].

Enhanced targeted metabolite profiling by gas chromatography-atmospheric pressure ionization-quadrupole time of flight-mass spectrometry (GC/APCI-qTOF-MS)
Chemical derivatization and GC analysis were performed as described above. For RI calibration alkanes were replaced by a fatty acid methyl ester (FAME) mixture [72]. GC coupled to atmospheric pressure chemical ionization quadrupole time-of-flight mass spectrometry (GC/APCI-qTOF-MS) was performed using an Agilent 6890N24 gas chromatograph hyphenated to a Bruker impact II mass spectrometer (Bruker Daltonik GmbH, Bremen, Germany For the purpose of multi-targeted datamining by Profile Analysis software, raw data analysis of positive mode line spectra was performed with spectral background subtraction and MS recalibration. MS recalibration setting were: Internal recalibration-calibration ESI, calibration list perfluortributylamin (PFTBA), Mode HPC, search range 0.01 m/z, intensity threshold 1000, retention time of the calibrant started at 0.07 min and ended at 0.08 min. So-called bucket generation parameters were: Rangesretention time range start-end (min), mass range startend (m/z); bucketing-rectangular bucketing delta (min) delta (m/z). The retention time (RT) range of each metabolite was defined by manual supervision with RT deviation set to ±0.5-1.0 min. The mass range of the expected molecular mass or fragment(s) was manually supervised expecting Gaussian shaped mass distributions and m/z deviation set to ±40 mDa. Analyte annotation was based on expected elution times calculated from Golm Metabolome Database retention indices using a FAME mixture [72]. In addition, the recorded APCI spectra were manually matched to EI reference spectra and to monoisotopic masses of expected protonated molecular ions and fragment ions. Ions used for relative quantification are listed in Additional file 3.

Statistics and data visualization
Metabolite intensities were corrected for exact OD 750 equivalents of each sample and normalized by ISTD intensity resulting in metabolite responses with units mL −1 OD −1 750 . 13 C 6 -sorbitol was used as default internal standard except when metabolite-specific internal standards were available as listed in Additional file 3. Dimensionless response ratios were calculated comparing producer to WT at each time point of the cultivations and subsequently log 2 -transformed. Hierarchical cluster analysis with Pearson´s correlations distance and complete linkage and heat map visualizations were performed using the multi-experiment viewer software, MeV (Version 4.6.2; http://www.tm4.org/mev/; [73]). Principal component analysis (PCA) was performed using log 2transformed response ratios via the MetaGeneAlyse web application (Version 1.7.1; http://metagenealyse.mpimpgolm.mpg.de) with missing value substitution as was described earlier [74].

SDS-and blue native (BN)-PAGE analysis
Whole-cell extracts of Synechococcus 7002 were prepared as described previously [75] and proteins were separated by SDS-PAGE [76] or BN-PAGE using precast NativePAGE Novex 4-16% Bis-Tris gels (Thermofisher, Germany). Preparation of thylakoid membranes for BN-PAGE analysis (Additional file 10) and gel electrophoresis was performed according to Lassen et al. [77].

Proteomic analysis Preparation of protein extracts preparation for proteomics
Cells corresponding to 120-150 OD 750 -units were spun down and the resulting cell pellets weighed. After resuspension in PBS buffer (140 mM NaCl; 2.5 mM KCl; 10 mM Na 2 HPO 4 ; 2 mM KH 2 PO 4 , pH 7.4) suspensions containing 80-120 mg cell material were transferred to a new 2 mL tube and washed twice with PBS. Finally, the pellet was resuspended in PF-Buffer (6 M urea; 3 M thiourea; 70 mM DTT; 12.5 mM Tris, pH 7.5 including the cOmplete Protease Inhibitor Cocktail, Sigma-Aldrich, St. Louis, Missouri, USA). 800 µL glass beads (size 0.1-0.25 mm) were added to the samples and cells broken by bead-beating. Afterwards unbroken cells and cell debris were pelleted by a 3-min spin with 6000 rpm at 4 °C. The supernatant fraction was collected in a 15-mL tube and kept on ice. To the remaining pellet 1 mL of PF buffer was added and another cycle of bead-beating was performed. After another 3 min spin with 2500 rpm both supernatants were combined and a last bead-beating of the pellet with subsequent centrifugation for 1 min with 5000 rpm was conducted. Finally, the collected supernatant fraction was sonicated for 5 × 10 s at 50% with incubation on ice in between cycles. At last, remaining debris was pelleted after 2 min at 3000 rpm, the supernatant was collected and stored at −20 °C overnight. To solubilize proteins from membranes Triton X-100 (end concentration 0.5%) was added to the slowly thawed sample and incubated at room temperature on a shaker for 30 min. Debris was pelleted during a 30-min spin at 13,000 rpm at 4 °C, and the resulting supernatant was digested with Benzonase ® Nuclease (Sigma-Aldrich, St. Louis, Missouri, USA; 250 units/µL) in a 1:8000 dilution for 15 min at room temperature. After that, using Amicon Ultra Filter 10 K (Merck-Millipore, Darmstadt, Germany) samples were concentrated to an approximate end volume of 600 µL. Finally, after performing a precipitation with 10% trichloroacetic acid overnight at 4 °C with two subsequent washing steps with acetone, the pellet was re-suspended in PF buffer and used for analysis via twodimensional electrophoresis.

Protein identification by liquid chromatography-mass spectrometry
Protein identification using nanoLC-ESI-MS/MS was performed by Proteome Factory (Proteome Factory AG, Berlin, Germany). The MS system consisted of an Agilent 1100 nanoLC system (Agilent, Waldbronn, Germany), PicoTip electrospray emitter (New Objective, Woburn, USA, MA) and an Orbitrap XL or LTQ-FT Ultra mass spectrometer (ThermoFisher, Bremen, Germany). Protein spots were in-gel digested by trypsin (Promega, Mannheim, Germany) and applied to nanoLC-ESI-MS/ MS. Peptides were trapped and desalted on the enrichment column (Zorbax SB C18, 0.3 × 5 mm, Agilent) for 5 min using 2.5% acetonitrile/0.5% formic acid as eluent, then peptides were separated on a Zorbax 300 SB C18, 75 µm × 150 mm column (Agilent) using an acetonitrile/0.1% formic acid gradient from 5 to 35% acetonitrile within 40 min. MS/MS spectra were recorded data-dependently by the mass spectrometer according to manufacturer's recommendations. Proteins were identified using MS/MS ion search of the Mascot search engine (Matrix Science, London, England) and the protein database (National Center for Biotechnology Information, Bethesda, USA) Cyano_SP7002 (18,695 sequences). Ion charge in search parameters for ions from ESI-MS/MS data acquisition were set to "1+, 2+ or 3+" according to the instrument's and method's common charge state distribution. Further search parameters were the following: