Skip to main content

Consortia-mediated bioprocessing of cellulose to ethanol with a symbiotic Clostridium phytofermentans/yeast co-culture

Abstract

Background

Lignocellulosic ethanol is a viable alternative to petroleum-based fuels with the added benefit of potentially lower greenhouse gas emissions. Consolidated bioprocessing (simultaneous enzyme production, hydrolysis and fermentation; CBP) is thought to be a low-cost processing scheme for lignocellulosic ethanol production. However, no single organism has been developed which is capable of high productivity, yield and titer ethanol production directly from lignocellulose. Consortia of cellulolytic and ethanologenic organisms could be an attractive alternate to the typical single organism approaches but implementation of consortia has a number of challenges (e.g., control, stability, productivity).

Results

Ethanol is produced from α-cellulose using a consortium of C. phytofermentans and yeast that is maintained by controlled oxygen transport. Both Saccharomyces cerevisiae cdt-1 and Candida molischiana “protect” C. phytofermentans from introduced oxygen in return for soluble sugars released by C. phytofermentans hydrolysis. Only co-cultures were able to degrade filter paper when mono- and co-cultures were incubated at 30°C under semi-aerobic conditions. Using controlled oxygen delivery by diffusion through neoprene tubing at a calculated rate of approximately 8 μmol/L hour, we demonstrate establishment of the symbiotic relationship between C. phytofermentans and S. cerevisiae cdt-1 and maintenance of populations of 105 to 106 CFU/mL for 50 days. Comparable symbiotic population dynamics were observed in scaled up 500 mL bioreactors as those in 50 mL shake cultures. The conversion of α-cellulose to ethanol was shown to improve with additional cellulase indicating a limitation in hydrolysis rate. A co-culture of C. phytofermentans and S. cerevisiae cdt-1 with added endoglucanase produced approximately 22 g/L ethanol from 100 g/L α-cellulose compared to C. phytofermentans and S. cerevisiae cdt-1 mono-cultures which produced approximately 6 and 9 g/L, respectively.

Conclusion

This work represents a significant step toward developing consortia-based bioprocessing systems for lignocellulosic biofuels production which utilize scalable, environmentally-mediated symbiosis mechanisms to provide consortium stability.

Background

In nature microbes rarely live in isolation, but rather exist in highly diverse and complex communities referred to as consortia [1]. These consortia are often capable of tasks that are far too complex for any single organism to complete themselves including some of the most important global biogeochemical cycles [2]. The organisms living in these communities interact in numerous ways ranging from cooperation to direct competition [3]. Microbiologists and engineers have come to appreciate the diversity and capacity of natural microbial communities and large efforts have been undertaken to understand natural consortia and to engineer synthetic consortia for biotechnological purposes [47].

Two of the key challenges in society today are to reduce energy dependence on petroleum and reduce greenhouse gas emissions [8]. The transportation sector is a prime candidate for addressing these two challenges because it relies on petroleum for approximately 93% of its energy and releases almost as much carbon dioxide as both the commercial and residential sectors combined [9]. Lignocellulosic biomass has become an increasingly feasible source of carbohydrates for biological production of alternative fuels such as ethanol [10]. Consolidated bioprocessing (the simultaneous biological hydrolysis and fermentation of biomass; CBP) is thought to be one of the most cost effective means of producing ethanol from lignocellulose [11, 12]. However, no single organism has been isolated or genetically engineered to reach high enough ethanol concentrations, yields and productivities from lignocellulose [13]. Natural microbial consortia, on the other hand, are innately capable of high conversion of lignocellulosic biomass [see Table one in reference [7] but the resultant products (e.g., organic acids, CO2, CH4) are not suitable large-scale liquid transportation fuels.

An elegant example of a naturally occurring, lignocellulose degrading microbial consortium is the symbionts of the termite hindgut. Complex macromolecules are deconstructed in a series of steps that are facilitated by specific microbial species [14]. Protists produce cellulases for cellulose hydrolysis, while nitrogen fixing bacteria (e.g., Clostridia) sequester atmospheric nitrogen to compensate for the low nitrogen content of wood. Fermentative organisms consume soluble sugars released from cellulose hydrolysis to produce organic acids, CO2 and H2 which are subsequently converted by methanogens to methane [15]. This, along with other examples of natural microbial communities, has prompted interest in utilization of microbial consortia for lignocellulosic biofuels production [5, 7]. However, unlike these natural systems, scientists are currently limited in our ability to generate stable, productive microbial communities. In order to successfully implement large scale consolidated bioprocessing of lignocellulosic materials for fuel ethanol production we must develop stable microbial consortia with the necessary functionality, process control and efficiency.

To transition from natural consortia which contain potentially hundreds of organisms to synthetic consortia containing several defined species, one must develop a mechanism for population control. Generating stable, controllable consortia has been a focus of recent work to genetically engineer mechanisms for establishing intra-species consortia [1619]. These approaches range from growth-controlling genetic circuits based on quorum sensing compounds [19] to complimentary auxotrophic amino acid exchange [17]. As proof-of-concept, these studies are quite elegant and encouraging but they may suffer on the large scale due to unstable and difficult genetic modifications in industrially relevant organisms. Others have demonstrated syntrophic interactions in a co-culture of Actinotalea fermentans with an engineered S. cerevisiae which produces methyl halides directly from cellulose [20]. S. cerevisiae relieves acetate inhibition by converting it to methyl halides, which are precursors for various fuel compounds. However, synthetic syntrophic interactions may be unstable since at least one organism does not necessarily rely on the other for survival. Without an additional level of control (e.g., spatial structure [2123]) the community may breakdown. Obligate mutualisms such as those described by You et al. 2004 and Shou et al. 2007 may be a more stable approach for consortia-mediated lignocellulosic ethanol production. With this in mind, symbiotic consortia of a wide range of organisms could be generated using various mechanisms based on both genetic and environmental control factors [7].

In this work we develop a symbiotic co-culture of the cellulolytic mesophile, Clostridium phytofermentans[24] and a cellodextrin fermenting yeast, Candida molischiana[25] or S. cerevisiae cdt-1 [26]. We establish a symbiosis (obligate mutualism) between C. phytofermentans and the yeast species by controlling the volumetric transport rate of oxygen. Both yeasts are capable of providing respiratory protection to the obligate anaerobe, C. phytofermentans, in return for soluble carbohydrates released from cellulose hydrolysis. The yeast converts these soluble carbohydrates to ethanol. At high substrate loading we noted a decreased conversion of cellulose by C. phytofermentans therefore endoglucanase was added to further evaluate the potential for improvements in the co-culture approach. In this cellulase-assisted format, the co-culture produces over twice as much ethanol and degrades two and three times as much α-cellulose as the S. cerevisiae cdt-1 and C. phytofermentans mono-cultures, respectively. This work represents a significant step in utilizing a scalable environmental control mechanism (i.e. oxygen transport) to induce a stable symbiosis in a consortium of two diverse organisms. This general approach to symbiosis development is applicable to a variety of organisms, substrates and products and can be used to explore diverse consortia-mediated bioprocesses.

Results and discussion

Design and development of C. phytofermentans/yeast symbiosis

Oxygen introduction was proposed as a mechanism for establishing a symbiosis between mixtures of organisms in which one organism “protects” the other from oxygen inhibition in return for soluble carbohydrates released from cellulose [7]. In this work we investigated this mechanism and the subsequent performance of a combination of the cellulolytic obligate anaerobic mesophile, C. phytofermentans, with one of two cellodextrin fermenting yeasts, C. molischiana or S. cerevisiae cdt-1. C. phytofermentans was chosen for its ability to hydrolyze and ferment pure cellulose and natural lignocellulosic materials. For example, under consolidated bioprocessing (CBP) conditions (i.e., simultaneous biological hydrolysis and fermentation), C. phytofermentans was shown to hydrolyze 76% of glucan and 88.6% of xylan in AFEX treated corn stover and ferment it to 2.8 g/L ethanol in 10 days [27]. C. molischiana is naturally able to ferment cellodextrins with degree of polymerization 2 to 6 to ethanol with yields of approximately 0.40 g ethanol/g substrate in 44 hours [28]. S. cerevisiae cdt-1 was engineered to import and cleave cellodextrins for subsequent fermentation (yield of approximately 0.44 g/g cellobiose in about 100 hours) through expression of cellodextrin transporters and β-glucosidase from Neurospora crassa[26]. Although similar, the yeasts do have some important differences. For example, S. cerevisiae cdt-1 transports and cleaves cellodextrins internally [26] while C. molischiana does so externally with extracytoplasmic β-glucosidase [29]. These yeasts were chosen for their unique ability to ferment cellodextrins (not only glucose) which was hypothesized to increase ethanol yield and relieve cellulase inhibition by the soluble sugar products. In addition, these two organisms provide a comparison across two genus and between engineered and naturally occurring strains. In this study we used α-cellulose (Sigma) as a model cellulosic substrate to study hydrolysis and fermentation since it avoids the presence of additional carbon sources (e.g., hemicellulose).

To test oxygen consumption and the resultant protection, cultures with 12 g/L cellobiose as a mutually accessible carbon source, were inoculated with 105 to 106 CFU/mL of C. molischiana or S. cerevisiae cdt-1 and 105 to 1010 CFU/mL C. phytofermentans. Dissolved oxygen was not removed from the medium at the beginning of the experiment however the cap was kept tight throughout the experiment aside from sampling. C. phytofermentans mono-cultures were unable to grow and viable cells dropped below detection (< 100 CFU/mL) almost immediately with low starting concentration (Figure 1A.1.) and after a short lag with higher starting concentration (Figure 1B.1). C. molischiana and S. cerevisiae cdt-1 in both mono- and co-culture grew relatively rapidly, showing increases in both viable cells and optical density (Figure 1A.2,3 and B.2,3). The discrepancy between the apparent length of the growth phase in optical density for C. molischiana mono-cutlures and viable cells is thought to be due to the insensitivity of CFU measurements and possibly a partial loss of viable cells which still contribute to OD. During rapid growth the yeast presumably consumed all available oxygen which, in co-culture, allowed for growth of C. phytofermentans (Figure 1A.3 and 1B.3). This result could be expected since similar relief of oxygen inhibition has been demonstrated in fungal/bacterial and bacterial/bacterial interactions [30, 31] and is generally observed in naturally occurring microbial consortia [32]. However, this is the first demonstration utilizing an anaerobic cellulolytic bacteria and cellodextrin fermenting yeast. These results confirm that yeast provide respiratory protection to the obligate anaerobe, C. phytofermentans as an important component of the symbiotic cooperation that would be required for growth on cellulose as the sole carbon source.

Figure 1
figure 1

Semi-aerobic mono- and co-culture growth on cellobiose. C. phytofermentans mono-culture (A.1 and B.1), C. molischiana mono-culture (A.2),C. phytofermentans/C. molischiana co-culture (A.3), S. cerevisiae cdt-1 mono-culture (B.2) and C. phytofermentans/S. cerevisiae cdt-1 co-culture (B.3) viable cell counts (left) and optical densities (right) in GS2 cellobiose fermentations. Results are representative of at least two independent experiments. Error bars are the standard deviation among drops for colony counting.

This microbial interaction was expanded to include the complimentary component of the proposed symbiosis by providing carbohydrate that is released from cellulose by C. phytofermentans. Mono- and co-cultures were inoculated into medium containing Whatman #1 filter paper strips under semi-aerobic conditions (i.e., initially oxygenated with tubes that allowed gas transfer). After approximately 15–40 days of static incubation at 30°C, only co-cultures showed degradation of filter paper (Figure 2). Here C. molischiana and S. cerevisiae cdt-1 provide respiratory protection to C. phytofermentans in exchange for soluble substrate provided from cellulose via C. phytofermentans hydrolysis. However, subsequent experimentation at increased oxygen transfer rates showed that these soluble products were a combination cellodextrins, glucose and ethanol produced by C. phytofermentans (data not shown). Protective mechanisms similar to this have been observed in mixed bacterial cultures [33] which supports the use of oxygen as a robust regulatory mechanism and suggests that flexibility exists in the selection of the facultative partner organism.

Figure 2
figure 2

Static mono- and co-culture hydrolysis of filter paper. Semi-aerobic cultures in non-degassed GS2 medium with Whatman No. 1 filter paper strips as the carbon source. C. molischiana and C. phytofermentans mono- and co-cultures (A) and S. cerevisiae cdt-1 and C. phytofermentans mono- and co-cultures (B). Photographs taken after 40 days (A) and 15 days (B) static incubation at 30°C with periodic agitation. Image is representative of at least two independent experiments each with two replicates (as shown in the photographs).

Low level oxygen transfer promotes symbiosis while maintaining ethanol production

To prevent ethanol consumption while maintaining sufficient oxygen to promote the symbiosis requires the use of controlled low level oxygen introduction. Submerged neoprene tubing with continuous internal air flow was used to transfer oxygen in two different scale reactor systems, 50 mL and 500 mL (Figure 3). Using this design, altering the submerged tubing length provides a simple means of altering the oxygen transfer rate. Assuming a constant driving force from air and a zero oxygen concentration in the culture (as determined visually by colorless resazurin) the oxygen transfer rate (OTR) through the tubing was estimated to be approximately 0.04 μmol O2/cm hour. With 10 cm of submerged tubing in 50 mL of medium the OTR = 8 μmol O2/L hour which corresponds to a culture volumetric transport rate of approximately 0.03 hour-1 (which is several orders of magnitude lower than typical shake flask fermentations [34]).

Figure 3
figure 3

Bioreactors designed and utilized for diffusive oxygen transfer. Controlled oxygen transfer reactor with 10 cm neoprene tubing fixed to stainless steel tubing inserted into a sealed 100 mL serum bottle (A). Infors 500 mL reactor containing 100 cm neoprene tubing fixed to stainless steel outlet ports (B). Infors 500 mL reactor in operation with tubing loops submerged in the cellulose-containing medium (C).

Using this OTR, C. molischiana and S. cerevisiae cdt-1 mono-cultures grew and fermented cellobiose with a lag phase of approximately 150–200 and 50–75 hours, respectively (Additional file 1B and F). C. phytofermentans mono-cultures displayed only slightly inhibited growth and ethanol production compared to no oxygen controls (Additional file 1D). Without oxygen, growth and/or cellobiose consumption were not observed in C. molischiana mono-cultures while gradual cellobiose consumption was observed in S. cerevisiae cdt-1 mono-cultures (Additional file 1A and E). In fact, even with the addition of Ergosterol and Tween 80 (two common anaerobic growth factors for yeast [35]) and replacement of cysteine with glutathione [36] we were unable to achieve growth of C. molischiana on cellobiose under completely anaerobic conditions. S. cerevisiae cdt-1, on the other hand, displayed growth under these conditions (Additional file 2). This observation agrees well with other reports that indicated only a small number of yeast are able to grow in the complete absence of oxygen [37].

As expected, in anaerobic cellobiose co-culture C. molischiana and S. cerevisiae cdt-1 were outcompeted; the viable cell counts fell below detection (< 100 CFU/mL) after about 100–200 hours (Additional file 3). On the other hand, co-cultures with oxygen transfer fermented all the cellobiose and supported the growth of both C. phytofermentans and C. molischiana or S. cerevisiae cdt-1 (Additional file 3). The ethanol yield of the co-culture was slightly lower than that of the yeast mono-cultures since a small amount of acetate was produced early in the fermentation. In contrast to Figure 1, C. phytofermentans benefited early in the culture since the media was initially anaerobic while the increase in yeast viable cell counts occurred after approximately 100–200 hours during which time oxygen was continuously diffused into the culture (Additional file 3). This OTR appeared suitable for inducing and maintaining a co-culture of C. phytofermentans and either C. molischiana or S. cerevisiae cdt-1 on cellobiose while allowing for high ethanol yield. Therefore, the same OTR was implemented in cellulose fermentations. In contrast to a recent co-culture CBP study which required sequential culturing conditions for complimentary function while selectively inhibiting growth [38], this approach allows simultaneous growth and fermentation of both organisms which drastically simplifies culturing techniques.

Stable co-culture cellulose fermentation

Using low oxygen transfer rates as the symbiosis mediator, co-cultures were performed with 25 g/L α-cellulose as the sole carbon source. S. cerevisiae cdt-1 was utilized in the remainder of the studies rather than C. molischiana due to its superior anaerobic growth and co-culture capabilities. C. phytofermentans dominated α-cellulose co-cultures during the first few hundred hours during which time yeast populations fell from about 106 viable cells per mL to below detection (Figure 4A and B). Without oxygen, the yeast population remained at or below detectable limits in both co-culture (Figure 4A) and mono-culture (Additional file 4A). In co-culture fermentations with added oxygen, the yeast population recovered to a maximum of about 104 – 105 CFU/mL presumably due to simultaneous oxygen and carbon availability (Figure 4B). In fact, soluble cellodextrin concentrations in co-cultures with oxygen were consistently lower than those without oxygen even though cellulose hydrolysis was essentially identical (data not shown). As expected due to their inability to utilize cellulose, S. cerevisiae cdt-1 mono-cultures did not grow with or without added oxygen (Additional file 4A). C. phytofermentans growth was relatively unaffected by co-culturing (Figure 4) and oxygen introduction (Additional file 4B). This confirms that oxygen can be used to generate a symbiotic relationship between C. phytofermentans which provides a soluble carbon source to S. cerevisiae cdt-1 from cellulose in return for preventing oxygen inhibition. However, for these treatments no significant improvements in ethanol production or cellulose hydrolysis were observed in oxygen supplemented co-cultures relative to anaerobic C. phytofermentans mono-cultures (data not shown).

Figure 4
figure 4

Co-culture population dynamics with diffusive oxygen transfer. Population dynamics for 50 mL, 25 g/L α-cellulose co-culture fermentations without added oxygen (A) and with added oxygen (B) and 500 mL, 100 g/L α-cellulose co-culture fermentation (C). Results in A and B are representative of at least 3 independent experiments. Results in C represent a single experiment. Error bars are plus and minus one standard deviation among the drops used for colony counting.

To investigate the scalability and attempt to improve performance of the co-culture, the fermentations were scaled up ten-fold (from 50 mL to 500 mL) to an Infors Sixfors bioreactor system (Figure 3C) with enhanced mixing, pH control and an α-cellulose concentration of 100 g/L. The OTR was maintained at approximately 0.4 μmol O2/hour by increasing the submerged tubing length by a factor of ten from 10 to 100 cm. Under these conditions, the population dynamics were essentially identical to the small scale reactors with only a slightly longer delay in S. cerevisiae cdt-1 re-growth (Figure 4C). Even with pH control, mixing and higher initial substrate concentration, the fermentation performance was not significantly improved compared to the small scale fermentations (data not shown). It is none-the-less encouraging that the population control mechanism based on oxygen transport rates could be readily scaled. In addition to increasing tubing length it is easy to envision that the OTR could be maintained by altering tubing thickness, internal oxygen concentration or with minimal gas sparging at a larger scale.

The long term population stability of the co-culture was determined by growing C. phytofermentans and S. cerevisiae cdt-1 in co-culture with and without oxygen for 50 days. Serum bottles with 25 mL GS2 medium and 150 g/L α-cellulose were inoculated with approximately equal cell concentration (about 105 CFU/mL) of C. phytofermentans and S. cerevisiae cdt-1. At 30, 40 and 50 days the individual cell concentrations were determined (Additional file 5A and B). The co-culture with added oxygen maintained C. phytofermentans and S. cerevisiae cdt-1 concentrations of 105 to 107 CFU/mL at every time point whereas, without oxygen, the yeast population fell below detection prior to the 30 day sample. The presence of yeast in the oxygen positive co-culture was also apparent in that no glucose was accumulated compared to almost 3 g/L glucose accumulation in the co-culture without oxygen (Additional file 5C and D).

These results demonstrate the ability to effectively generate a stable, symbiotic co-culture of C. phytofermentans and S. cerevisiae cdt-1 via diffusion of oxygen at a rate of approximately 8 μmol O2/L hour. The oxygen transfer mechanism was scalable from 50 mL to 500 mL. However, the fermentations were still limited in their hydrolytic capacity meaning the co-culture would not significantly out-perform C. phytofermentans mono-cultures.

Co-culture simultaneous saccharifcation and fermentation

The lack of increased performance of the co-culture relative to C. phytofermentans mono-culture appears to be due to an inability of C. phytofermentans to hydrolyze high solids loading cellulose to provide soluble substrate for the yeast partner. C. phytofermentans was repeatedly unable to fully utilize insoluble substrate concentrations in excess of approximately 30 g/L (unpublished observation). To explore the potential for improving the co-culture approach we sought to increase soluble sugar yield by fermenting α-cellulose with and without added endoglucanase from Trichoderma viride (3.2.1.4). This specific approach was taken to simulate additional hydrolysis capacity of C. phytofermentans while acknowledging the differences that exist between fungal and Clostridial cellulases.

Mono- and co-cultures were grown in 100 mL serum bottles with 100 g/L α-cellulose in 50 mL of ETGtGS2 medium. After about 400 hours, C. phytofermentans mono-cultures without oxygen hydrolyzed approximately 22% of the α-cellulose. With the addition of 0.4 g/L endoglucanase, or 3.8 IU/mL, conversion increased to about 42% but the majority of the released reducing sugars simply accumulated leaving almost 23 g/L reducing sugars in the final sample (Figure 5A). C. phytofermentans mono-cultures with and without added endoglucanase resulted in about 6 g/L ethanol suggesting a limitation in metabolic capacity of C. phytofermentans (Figure 5A). With oxygen, approximately 35% of the α-cellulose was hydrolyzed in S. cerevisiae cdt-1 mono-cultures (with enzyme) with about 1 g/L reducing sugars accumulated and 9 g/L ethanol produced. Co-cultures without added enzyme behaved essentially identical to C. phytofermentans mono-cultures consistent with hydrolysis-limited productivity. On the other hand, the co-culture with oxygen and endoglucanase produced more than two times more ethanol than either mono-culture with a final concentration of approximately 22 g/L and hydrolyzed twice as much cellulose with a conversion of about 72% (Figure 5). A single experiment was incubated further and with an additional 240 hours the co-culture reached almost 30 g/L ethanol and 90% cellulose conversion (Additional file 6). The C. phytofermentans mono-culture with and without endoglucanse failed to produce additional ethanol and the S. cerevisiae cdt-1 mono-cultures reached only 13 g/L after the additional 240 hours of incubation (Additional file 6).

Figure 5
figure 5

Mono- and co-culture performance under CBP and SSF conditions. C. phytofermentans mono- and co-culture CBP without added enzyme and SSF with 400 mg/L endoglucanase at 30°C. Performance is shown by ethanol, acetate and accumulated reducing sugar concentrations (A) and cellulose conversion (B). Bars represent the average of two independent experiments and error bars are plus and minus one standard deviation among experiments. C. phy indicates C. phytofermentans mono-culture, cdt-1 indicates S. cerevisiae cdt-1 mono-culture and C. phy + cdt-1 indicates C. phytofermentans/S. cerevisiae cdt-1 co-culture. + Endoglucanase indicates an SSF experiment with endoglucanase added as stated in the text. S. cerevisiae cdt-1 mono-cultures and C. phytofermentans/S. cerevisiae cdt-1 culture were grown with oxygen transfer while C. phytofermentans mono-cultures remained completely anaerobic throughout the experiment.

These results demonstrate that co-culture with C. phytofermentans significantly enhances simultaneous saccharification and fermentation of α-cellulose with S. cerevisiae cdt-1. It is important to note in Figure 5 that the maximum productivity was observed for the consortium relative to the mono-culture even when exogenous cellulase was provided. This suggests there is considerable room for optimizing the productivity, and contrary to concerns of complexity, the symbiotic consortium is inherently stable. This synergistic interaction produced a final ethanol concentration that was 30% greater than the sum of the mono-culture titers (22 g/L versus 15 g/L). The improvements shown here are likely due to the combination of endoglucanse and the enzyme repertoire of C. phytofermentans relative to the single enzyme (endoglucanase) used in S. cerevisiae cdt-1 mono-cultures. The relief of feedback inhibition on T. viride endoglucanase by consumption of accumulated sugars and decreased pH caused by C. phytofermentans acetate production also likely contributed to the observed improvements. It is important, however, to note that the media conditions are optimized for co-culture growth and not necessarily mono-culture SSF productivity so changes in culturing conditions could lead to improved mono-culture performance. Independent of these subtle interpretations, these results unambiguously demonstrate the power of symbiotic microbial consortia in cellulosic ethanol production. The results also suggest that with improvements in C. phytofermentans hydrolytic capacity, the co-culture has the potential to reach commercially relevant ethanol concentrations from α-cellulose.

Conclusions

We have demonstrated the development, verification and application of a symbiotic co-culture of a cellulolytic mesophile, C. phytofermentans, and the cellodextrin fermenting yeast, C. molischiana or S. cerevisiae cdt-1 for direct ethanol production from α-cellulose. Controlled oxygen transfer is used to induce a symbiosis between the two organisms in which the yeast removes oxygen, protecting C. phytofermentans, in return for soluble carbohydrates liberated from cellulose (Figure 6). The symbiotic co-cultures were stable for almost 2 months, hydrolyzed cellulose under semi-aerobic conditions and produced more ethanol from α-cellulose via SSF than C. phytofermentans or S. cerevisiae cdt-1 mono-cultures. The addition of a moderate level of cellulase 400 mg/L (3.2.1.4 from T. viride) to the co-cultures in SSF experiments improved ethanol production two-fold greater than S. cerevisiae cdt-1 mono-culture and approximately four-fold greater than C. phytofermentans mono-cultures giving a final concentration of approximately 22 g ethanol/L after 400 hours. These results suggest that C. phytofermentans hydrolysis rates are well-matched to its natural metabolic rates and increased cellulase activity is needed to support a highly productive symbiosis. In addition, oxygen introduction as a mechanism for symbiosis establishment in microbial consortia was scaled from 50 mL to 500 mL and can be readily scaled up by conventional gas transfer at low cost making it highly applicable to industrial fermentation.

Figure 6
figure 6

Proposed symbiotic consortium design. C. phytofermentans-yeast symbiotic consortium design based on cellulose hydrolysis to soluble cellodextrins which are utilized by yeast. Both C. phytofermentans and yeast produce ethanol from cellodextrins. Cellodextrins feedback inhibit cellulose hydrolysis, oxygen inhibits anaerobic bacterial growth while yeast oxygen consumption relieves inhibition.

This work represents a significant advancement in establishing and controlling a microbial consortium of diverse organisms for biochemical production. In contrast to other approaches for generating symbiotic consortia that require genetic engineering, oxygen introduction is a simple, scalable technique that could be applied to organisms where genetic engineering tools are not yet available. However, both approaches have significant merit and genetic modification combined with an environmental control mechanism, like oxygen tension, could be an extremely powerful approach to consortia-mediated bioprocessing. The successful development of controllable, stable and productive engineered microbial consortia is likely to be a key advancement in many aspects of biotechnology. This approach combines complex functionality that is distributed across numerous organisms that can be independently optimized for a specific function. To gain better understanding, control and predictive capabilities, community mass and energy balance and metabolic models [3941] may prove quite useful. Modeling combined with ecological theory could be applied to predict the fate of the populations in a consortium and the relative fitness and/or productivity of the individuals within the overall community.

Oxygen-facilitated symbiosis should be pursued as a mechanism for generating stable consortia of various other organisms including other cellulolytic bacteria and fungi as well as pentose and hexose fermenting yeasts and bacteria. In addition, other products, interactions and processes can be explored by incorporating other naturally occurring or genetically engineered organisms that have unique metabolic properties such as the production of biofuel molecules with improved energy density. As a model system, this symbiotic consortium can be used to explore the structural and functional aspects of cellulose degrading microbial communities. The work described herein used pure cellulose as a substrate but more complex lignocellulosic substrates must be investigated. The appropriate combination of organisms in a symbiotic consortium could result in an efficient consortia-mediated bioprocess which could improve the economic feasibility of lignocellulosic biofuels.

Methods

Media and chemical sources

GS2 medium [42] was used in all experimental cultures with the following composition per liter: 6 g Yeast Extract (BD), 2.9 g K2HPO4 (JT Baker), 2.1 g Urea (Sigma), 1.5 g KH2PO4 (JT Baker), 3 g Tri-Na Citrate H2O (Fischer), 2.33 g Cysteine HCl H2O (MP Biomedical), 1 g MOPS (Sigma), 0.1 g MgCl2 6H2O (JT Baker), 0.0113 g CaCl2 Annhydrous (Fischer), and 0.000125 g FeSO4 7H2O (Fischer) and 0.01% Resazurin (Aldrich). The salts solution (MgCl2 6H2O, CaCl2 Annhydrous and FeSO4 7H2O) and resazurin solution were made and sterilized separately and added after autoclave. The pH of the basal components was adjusted to 7 prior to sterilization. The concentration of α-Cellulose (Sigma) was as described in the text. For inoculum cultures α-Cellulose was replaced with 3 g/L Cellobiose. The GS2 medium was modified for α-cellulose co-cultures to contain 10 mg/L Ergosterol and 420 mg/L Tween 80 and 4.09 g/L Glutathione in place of 2.33 g/L Cysteine HCl H2O (termed ETGtGS2). Either GS2 medium without cysteine and/or glutathione or YPC (5 g/L yeast extract, 10 g/L peptone and 3 g/L cellobiose) was used for cultivation of C. molischiana and S. cerevisiae cdt-1. Half strength Sabouraud medium contained (per liter) 5 g Casien Digest (Sigma), 5 g Dextrose (EM Sciences) and 10 g Agar (BD).

Inoculation

Initial cultures of Clostridium phytofermentans ISDgT were prepared from cryogenically (−80°C) frozen stocks in 7.5 mL screw cap tubes with 5 mL GS2 medium. Oxygen was removed from C. phytofermentans culture medium by degassing (until de-pinked) in a Coy Anaerobic Chamber with a 1.5% H2/98.5% N2 atmosphere. C. phytofermentans inoculum cultures were allowed to grow at 30°C to an OD600 of about 0.3. Cultures were then restarted by placing 100 μL of the initial culture into 4.9 mL of fresh GS2 medium. Experiments were inoculated by injecting approximately 2–3 mL of restarted cultures (OD600 of about 0.2-0.3) to give an initial OD600 of approximately 0.0125-0.025. The amount of substrates and products in the inoculum was determined by HPLC and was subtracted from the final concentrations in the cultures to determine true yields.

For cellobiose co-culture experiments and filter paper degradation experiments yeast cultures were grown in GS2 medium without cysteine and/or glutathione under aerobic conditions at 30°C until reaching an OD600 of at least 0.3 then restarted. The cultures were then restarted and the restarted cultures were used as inoculum to obtain an initial OD600 of approximately 0.0125-0.025. For the α-cellulose experiments yeast cultures were grown in YPC medium at 30°C until reaching an OD600 of at least 0.5, were restarted in YPC and allowed to grow until reaching an OD600 of approximately 1 and were then concentrated and used to inoculate with an initial OD600 of about 0.05.

Experimental cultures

Fermentations were conducted in 100 mL serum vials sealed with butyl rubber stoppers and incubated at 30°C with 200 rpm agitation or in the 500 mL Infors Sixfors bioreactor system at 30°C with 300 rpm stirring. In the Sixfors bioreactor system, pH was controlled using addition of 1 N sodium hydroxide. Cultures were degassed in an anaerobic chamber to remove oxygen at the beginning of the experiment as described previously. A loop of neoprene tubing (OR = 3.175 mm, IR = 1.45 mm) was submerged in the culture medium and attached at each end to stainless steel tubing inserted through the butyl stopper. In oxygen positive cultures, air was allowed to flow through the neoprene tubing at a flow rate of about 100 L/hr using an aquarium pump. The stainless steel tubing was fashioned in a loop for oxygen negative cultures so that no oxygen could enter the culture.

Static hydrolysis experiments were conducted in 30 mL flat-bottom test tubes and incubated at 30°C with periodic agitation. Experimental media was not degassed prior to inoculation and residual carbon was not removed from the inoculum. Resazurin was not included in the media.

Simultaneous saccharification and fermentation experiments were conducted in 100 mL serum vials sealed with butyl rubber stoppers and incubated at 30°C with 200 rpm agitation as previously described. Endoglucanase (3.2.1.4 from Trichoderma viride) was suspended in phosphate buffered saline, degassed and injected to reach a final concentration of 400 mg/L. Cultures without endoglucanase received degassed, phosphate buffered saline only. One way valves attached to needles were inserted through the butyl stopper to release the gas produced via fermentation.

Dry weight measurements

Cellulose dry weight samples (1 mL) were removed from reactors with a syringe and placed into pre-tared 1.7 mL eppi-tubes (VWR). The samples were centrifuged at 14,000 x g for 10 minutes and the supernatant was removed (used as HPLC sample as described in the following section). The cellulose pellet was washed with DI H2O and again centrifuged at 14,000 x g for 10 minutes. The supernatant was removed and the tube was placed, open, in a drying oven at 70°C. The samples were dried until reaching a constant mass and then weighed. The difference between the final and initial weight of the tube was assumed to be the dry mass of cellulose neglecting cellular mass.

Fermentation product determination

Cellobiose, glucose, ethanol and acetate concentrations were determined from supernatant (as described previously) taken from each culture and frozen immediately at −20°C. Following the completion of the experiment the samples were thawed and filtered into 1.5 mL screw cap vials (Agilent) using 0.45 μm nylon syringe filters (Whatman). Samples were analyzed on an Agilent 1100 HPLC with a Jasco RI-1531 refractive index detector (RID) using an Aminex HPX-87H Cation exchange column (BioRad) with the appropriate guard column. Filtered (through 0.22 um filter) 0.01 M sulfuric acid was used as the mobile phase, the column temperature was set at 65°C and the RID was set at 30°C. Samples were injected at a volume of 25 uL and the operating flow rate was 0.6 mL/min. Product formation reflects correction to the initial concentration in the medium immediately following inoculation. Therefore, carryover of low concentrations of fermentation products and subsequent consumption of these products (e.g., ethanol) may lead to negative production values.

Soluble carbohydrate determination

Soluble carbohydrates were determined using the anthrone-sulfuric acid colorimetric assay of Dreywood (Dreywood, 1946) adapted to a 96-well plate (Leyva et al. 2008). Breifly, 50 μL of appropriately diluted sample was mixed with 150 μL anthrone reagent (2 g/L anthrone in 98% sulfuric acid) in a polypropylene 96-well plate and covered with a nylon adhesive cover. The 96-well plates were incubated at 4°C for 10 minutes, 100°C for 20 minutes and room temperature for 20 minutes. The nylon cover was then removed and the plate was read in a Spectramax 384 Plus spectrophotometer at 620 nm. The soluble carbohydrate concentration was determined using a known concentration standard curve that was run with each 96-well plate used.

Colony forming unit determination

C. phytofermentans and yeast populations were determined by performing serial dilutions of experimental samples in 96-well plates and subsequent drop plating of each dilution on the appropriate medium. C. phytofermentans was plated on GS2 medium with 6 g/L lactose and was incubated at 30°C in an anaerobic chamber. C. molischiana and S. cerevisiae cdt-1 were plated on ½ Sabouraud medium and incubated at 30°C under aerobic conditions. Co-culture samples were plated on both types of plates and incubated under their respective conditions. Colonies were counted on dilutions that contained approximately 3 to 30 colonies per drop. Due to the non-soluble nature of cellulose which may act to trap, attach to or reject cells, colony counts often displayed significant variability but trends were found to be consistent across experiments.

Author contributions

TZ and WC conceived and designed the study. TZ carried out the majority of the experiments and drafted the manuscript. SX conducted the C. phytofermentans/C. molischiana static hydrolysis experiments and analysis as well as participated in media design. TZ and WC edited the draft. All authors read and approved the final manuscript.

Abbreviations

AFEX:

Ammonia fiber expansion

OD600:

Optical density at 600 nm

CBP:

Consolidated bioprocessing

OTR:

Oxygen transfer rate

HPLC:

High performance liquid chromatography

CFU:

Colony forming unit

IU:

International units

SSF:

Simultaneous saccharificaiton and fermentation

References

  1. Davey ME, O’toole GA: Microbial biofilms: from ecology to molecular genetics. Microbiol Mol Biol R 2000, 64: 847-867. 10.1128/MMBR.64.4.847-867.2000

    Article  CAS  Google Scholar 

  2. Prosser JI, Bohannan BJM, Curtis TP, Ellis RJ, Firestone MK, Freckleton RP, Green JL, Green LE, Killham K, Lennon JJ, Osborn AM, Solan M, van der Gast CJ, Young JPW: The role of ecological theory in microbial ecology. Nat Rev Microbiol 2007, 5: 384-392. 10.1038/nrmicro1643

    Article  CAS  Google Scholar 

  3. Hibbing M, Fuqua C: Bacterial competition: surviving and thriving in the microbial jungle. Nat Rev Microbiol 2009, 8: 15-25. 10.1038/nrd2758

    Article  Google Scholar 

  4. Bader J, Mast-Gerlach E, Popović MK, Bajpai R, Stahl U: Relevance of microbial coculture fermentations in biotechnology. J Appl Microbiol 2010, 109: 371-387. 10.1111/j.1365-2672.2009.04659.x

    Article  CAS  Google Scholar 

  5. Shong J: Jimenez Diaz MR, Collins CH: Towards synthetic microbial consortia for bioprocessing. Curr Opin Biotech 2012, 2: 1-5.

    Google Scholar 

  6. Brenner K, You L, Arnold FH: Engineering microbial consortia: a new frontier in synthetic biology. Trends Biotechnol 2008, 26: 483-489. 10.1016/j.tibtech.2008.05.004

    Article  CAS  Google Scholar 

  7. Zuroff TR, Curtis WR: Developing symbiotic consortia for lignocellulosic biofuel production. App Microbiol Biot 2012, 93: 1423-1435. 10.1007/s00253-011-3762-9

    Article  CAS  Google Scholar 

  8. U.S. Deparmtent of Energy Strategic Plan DOE/CF-0067. 2011.

  9. Annual Energy Review DOE/EIA-0384(2011). 2011.

  10. Lynd LR, Laser MS, Bransby D, Dale BE, Davison B, Hamilton R, Himmel M, Keller M, McMillan JD, Sheehan J, Wyman CE: How biotech can transform biofuels. Nat Biotechnol 2008, 26: 169-172. 10.1038/nbt0208-169

    Article  CAS  Google Scholar 

  11. Lynd LR, Weimer PJ, Zyl WHV, Pretorius IS: Microbial cellulose utilization: fundamentals and biotechnology. Microbiol Mol Biol R 2002, 66: 506-577. 10.1128/MMBR.66.3.506-577.2002

    Article  CAS  Google Scholar 

  12. Lynd LR, van Zyl WH, McBride JE, Laser M: Consolidated bioprocessing of cellulosic biomass: an update. Curr Opin Biotech 2005, 16: 577-583. 10.1016/j.copbio.2005.08.009

    Article  CAS  Google Scholar 

  13. Olson DG, McBride JE, Shaw JA, Lynd LR: Recent progress in consolidated bioprocessing. Curr Opin Biotech 2011, 23: 396-406.

    Article  Google Scholar 

  14. Ohkuma M: Termite symbiotic systems: efficient bio-recycling of lignocellulose. Int Microbiol 2003, 61: 1-9.

    CAS  Google Scholar 

  15. Kudo T: Termite-microbe symbiotic system and its efficient degradation of lignocellulose. Biosci Biotech Bioch 2009, 73: 2561-2567. 10.1271/bbb.90304

    Article  CAS  Google Scholar 

  16. Kerner A, Park J, Williams A, Lin XN: A programmable Escherichia coli consortium via tunable symbiosis. PLoS ONE 2012, 7: e34032. 10.1371/journal.pone.0034032

    Article  CAS  Google Scholar 

  17. Shou W, Ram S, Vilar JMG: Synthetic cooperation in engineered yeast populations. PNAS 2007, 104: 1877-1882. 10.1073/pnas.0610575104

    Article  CAS  Google Scholar 

  18. Balagaddé FK, Song H, Ozaki J, Collins CH, Barnet M, Arnold FH, Quake SR, You L: A synthetic Escherichia coli predator–prey ecosystem. Mol Syst Biol 2008, 4: 1-8.

    Article  Google Scholar 

  19. You L, Cox RS, Weiss R, Arnold FH: Programmed population control by cell–cell communication and regulated killing. Nature 2004, 428: 868-871. 10.1038/nature02491

    Article  CAS  Google Scholar 

  20. Bayer TS, Widmaier DM, Temme K, Mirsky EA, Santi DV, Voigt CA: Synthesis of methyl halides from biomass using engineered microbes. J Am Chem Soc 2009, 131: 6508-6515. 10.1021/ja809461u

    Article  CAS  Google Scholar 

  21. Kim HJ, Boedicker JQ, Choi JW, Ismagilov RF: Defined spatial structure stabilizes a synthetic multispecies bacterial community. PNAS 2008, 105: 18188-18193. 10.1073/pnas.0807935105

    Article  CAS  Google Scholar 

  22. Habets MGJL, Rozen DE, Hoekstra RF, de Visser JAGM: The effect of population structure on the adaptive radiation of microbial populations evolving in spatially structured environments. Ecol Lett 2006, 9: 1041-1048. 10.1111/j.1461-0248.2006.00955.x

    Article  Google Scholar 

  23. Saxer G, Doebeli M, Travisano M: Spatial structure leads to ecological breakdown and loss of diversity. P R Soc B 2009, 276: 2065-2070. 10.1098/rspb.2008.1827

    Article  Google Scholar 

  24. Warnick Thomas A, Methe Barbara A, Leschine Susan B: Clostridium phytofermentans sp. nov., a cellulolytic mesophile from forest soil. Int J Syst Evol Micr 2002, 52: 1155-1160. 10.1099/ijs.0.02125-0

    Article  CAS  Google Scholar 

  25. Freer SN: Utilization of glucose and cellobiose by Candida molischiana . Can J Microbiol 1995, 41: 177-185. 10.1139/m95-024

    Article  CAS  Google Scholar 

  26. Galazka JM, Tian C, Beeson WT, Martinez B, Glass NL, Cate JHD: Cellodextrin transport in yeast for improved biofuel production. Science 2010, 330: 84-86. 10.1126/science.1192838

    Article  CAS  Google Scholar 

  27. Jin M, Balan V, Gunawan C, Dale BE: Consolidated bioprocessing (CBP) performance of Clostridium phytofermentans on AFEX-treated corn stover for ethanol production. Biotechnol Bioeng 2011, 108: 1290-1297. 10.1002/bit.23059

    Article  CAS  Google Scholar 

  28. Gondé P, Blondin B, Leclerc M, Ratomahenina R, Arnaud A, Galzy P: Fermentation of cellodextrins by different yeast strains. Appl Environ Microb 1984, 48: 265-269.

    Google Scholar 

  29. Freer SN, Skory CD: Production of β-glucosidase and diauxic usage of sugar mixtures by Candida molischiana . Can J Microbiol 1996, 42: 431-436. 10.1139/m96-059

    Article  CAS  Google Scholar 

  30. Veal D, Lynch J: Associative cellulolysis and dinitrogen fixation by co-cultures of Trichoderma harzianum and Clostridium butyricum . Nature 1984, 310: 695-696. 10.1038/310695a0

    Article  CAS  Google Scholar 

  31. Kato S, Haruta S, Cui ZJ, Ishii M, Igarashi Y: Network relationships of bacteria in a stable mixed culture. Microb Ecol 2008, 56: 403-411. 10.1007/s00248-007-9357-4

    Article  CAS  Google Scholar 

  32. Paerl H, Pinckney J: A mini-review of microbial consortia: their roles in aquatic production and biogeochemical cycling. Microb Ecol 1996, 31: 225-247.

    Article  Google Scholar 

  33. Kato S, Haruta S, Cui ZJ, Ishii M, Igarashi Y: Effective cellulose degradation by a mixed-culture system composed of a cellulolytic Clostridium and aerobic non-cellulolytic bacteria. FEMS Microbiol Ecol 2004, 51: 133-142. 10.1016/j.femsec.2004.07.015

    Article  CAS  Google Scholar 

  34. Maier U, Büchs J: Characterisation of the gas–liquid mass transfer in shaking bioreactors. Biochem Eng J 2001, 7: 99-106. 10.1016/S1369-703X(00)00107-8

    Article  CAS  Google Scholar 

  35. Andreasen AA, Stier TJ: Anaerobic nutrition of Saccharomyces cerevisiae unsaturated fatty acid requirement for growth in a defined medium. Yeast 1950.

    Google Scholar 

  36. Kumar A, John L, Alam MM, Gupta A, Sharma G, Pillai B, Sengupta S: Homocysteine- and cysteine-mediated growth defect is not associated with induction of oxidative stress response genes in yeast. Biochem J 2006, 396: 61-69. 10.1042/BJ20051411

    Article  CAS  Google Scholar 

  37. Visser W, Scheffers WA: Batenburg-van der Vegte WH, van Dijken JP: Oxygen requirements of yeasts. Appl Environ Microb 1990, 56: 3785-3792.

    CAS  Google Scholar 

  38. Park EY, Naruse K, Kato T: One-pot bioethanol production from cellulose by co-culture of Acremonium cellulolyticus and Saccharomyces cerevisiae . Biotechnol Biofuels 2012, 5: 64. 10.1186/1754-6834-5-64

    Article  CAS  Google Scholar 

  39. Taffs R, Aston JE, Brileya K, Jay Z, Klatt CG, Mcglynn S, Mallette N, Montross S, Gerlach R, Inskeep WP, Ward DM, Carlson RP: Microbial consortia: a syntrophic case study. Systems Biol 2009, 16: 1-16.

    Google Scholar 

  40. Zomorrodi AR, Maranas CD: OptCom: A multi-level optimization framework for the metabolic modeling and analysis of microbial communities. PLoS Comput Biol 2012, 8: e1002363. 10.1371/journal.pcbi.1002363

    Article  CAS  Google Scholar 

  41. Biliouris K, Babson D, Schmidt-Dannert C: Stochastic simulations of a synthetic bacteria-yeast ecosystem. BMC Syst Biol 2012, 6: 58. 10.1186/1752-0509-6-58

    Article  Google Scholar 

  42. Cavedon K, Leschine SB, Canale-Parola E: Cellulase system of a free-living, mesophilic Clostridium (strain C7). J Bacteriol 1990, 172: 4222-4230.

    CAS  Google Scholar 

Download references

Acknowledgements

We are grateful to Dr. Jamie Cate at the University of California, Berkeley for providing Saccharomyces cereivisae strain cdt-1, Dr. Susan Leschine at the University of Massachusetts, Amherst for Clostridium phytofermentans ISDg10 and the USDA NRRL for Candida molischiana (Y-2237). We thank Patrick Hillery, Jessica Bigham and Taylor Maher who assisted in sample collection and analysis and Mark Signs who supported analytical work. We would like to thank Thomas K. Wood at The Pennsylvania State University for his comments on the research and manuscript. This material is based upon work done by TR Zuroff supported by the National Science Foundation Graduate Research Fellowship under Grant No. DGE-0750756. TR Zuroff also received funding for this work from the Pennsylvania State University Department of Chemical Engineering John and Jeanette McWhirter Graduate Research Fellowship. Any opinions, findings, and conclusions or recommendations expressed in this material are those of the author(s) and do not necessarily reflect the views of the National Science Foundation.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Wayne R Curtis.

Additional information

Competing interests

The authors declare that they have no competing interests.

Electronic supplementary material

13068_2012_282_MOESM1_ESM.pdf

Additional file 1: Mono-culture growth and cellobiose fermentation performance with and without diffusive oxygen transfer. Representative OD (top figures) and consumption/production profiles (bottom figures) for C. molischiana mono-cultures without oxygen (A), C. molischiana mono-cultures with oxygen (B), C. phytofermentans mono-cultures without oxygen (C),C. phytofermentans mono-cultures with oxygen (D), S. cerevisiae cdt-1 without oxygen (E) and S. cerevisiae cdt-1 with oxygen (F). Cellobiose (filled diamonds) and ethanol (open circles) are in grams per liter. Other products (e.g., glucose and acetate) are not shown for simplicity. Data is representative of at least two independent experiments. (PDF 158 KB)

13068_2012_282_MOESM2_ESM.pdf

Additional file 2: Growth of S. cerevisiae cdt- 1 and C. molischiana in improved media under anaerobic conditions. Growth of S. cerevisiae cdt-1 (squares) and C. molischiana (circles) in GS2 medium containing ergosterol, Tween 80 and glutathione in place of cysteine. Closed and open symbols represent two different experimental trials where each symbol is the average of two replicates. Error bars denote plus and minus one standard deviation between the replicates. Note that aerobic controls of both organisms grew well under these conditions. (PDF 141 KB)

13068_2012_282_MOESM3_ESM.pdf

Additional file 3: Co-culture growth and cellobiose fermentation performance with and without diffusive oxygen transfer. Representative CFU/mL (top figures) and consumption/production profiles (bottom figures) for C. phytofermentans/C. molischiana co-cultures (A) and C. phytofermentans/S. cerevisiae cdt-1 co-cultures (B) Cellobiose (filled diamonds) and ethanol (open circles) are in grams per liter. Data is representative of at least two independent experiments. (PDF 125 KB)

13068_2012_282_MOESM4_ESM.pdf

Additional file 4: Mono-culture population dynamics with and without diffusive oxygen transfer. Population dynamics for 50 mL, 25 g/L α-cellulose S. cerevisiae cdt-1 mono-culture fermentations (A) and C. phytofermentans mono-culture fermentations (B). Results are representative of at least 3 independent experiments and error bars are plus and minus one standard deviation among the drops used for colony counting. (PDF 111 KB)

13068_2012_282_MOESM5_ESM.pdf

Additional file 5: Co-culture populations and soluble sugar accumulation when grown on α- cellulose with and without oxygen. Viable cell counts at 30, 40 and 50 days for C. phytofermentans/S. cerevisiae cdt-1 co-cultures without oxygen (A) and with oxygen (B). Accumulated soluble sugars (including glucose) and glucose concentration at 30, 40 and 50 days for C. phytofermentans/S. cerevisiae cdt-1 co-cultures without oxygen (C) and with oxygen (D). Bars are the average of two replicates and error bars represent plus and minus one standard deviation. (PDF 127 KB)

13068_2012_282_MOESM6_ESM.pdf

Additional file 6: Mono- and co- culture performance under CBP and SSF conditions after 640 hours. C. phytofermentans mono- and co-culture CBP without added enzyme and SSF with 400 mg/L endoglucanase at 30°C. Performance is shown by ethanol and acetate concentrations (A) and cellulose conversion (B). Bars represent the average of two replicates in a single experiment and error bars are plus and minus one standard deviation among replicates. C. phy indicates C. phytofermentans mono-culture, cdt-1 indicates S. cerevisiae cdt-1 mono-culture and C. phy + cdt-1 indicates C. phytofermentans/S. cerevisiae cdt-1 co-culture. + Endoglucanase indicates an SSF experiment with endoglucanase added as stated in the text. S. cerevisiae cdt-1 mono-cultures and C. phytofermentans/S. cerevisiae cdt-1 culture were grown with oxygen transfer while C. phytofermentans mono-cultures remained completely anaerobic throughout the experiment. (PDF 120 KB)

Authors’ original submitted files for images

Rights and permissions

Open Access This article is published under license to BioMed Central Ltd. This is an Open Access article is distributed under the terms of the Creative Commons Attribution License ( https://creativecommons.org/licenses/by/2.0 ), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Reprints and permissions

About this article

Cite this article

Zuroff, T.R., Xiques, S.B. & Curtis, W.R. Consortia-mediated bioprocessing of cellulose to ethanol with a symbiotic Clostridium phytofermentans/yeast co-culture. Biotechnol Biofuels 6, 59 (2013). https://doi.org/10.1186/1754-6834-6-59

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/1754-6834-6-59

Keywords