Skip to main content
SpringerLink
Log in

Determination of metastable zone width and the primary nucleation kinetics of sodium sulfate

  • Published:
Theoretical Foundations of Chemical Engineering Aims and scope Submit manuscript

Abstract

The saturation curve, metastable zone width (MSZW) and primary nucleation kinetics were measured and estimated during sodium sulfate cooling crystallization process. The MSZW is commonly used to characterize crystal nucleation and determine the operation window for crystallization process. The MSZW is the difference between the saturation temperature and the temperature at which crystals are formed at different temperatures, cooling rates and agitating rates. The approach to interpret the MSZW obtained by polythermal method using the classical nucleation theory by Nyvlt was extended. Interfacial energy was determined for the growth of sodium sulfate crystals. Nucleation parameters such as surface entropy factor, radius of critical nucleus, Gibbs free energy, and critical energy barrier were investigated. The nucleation order was established based on the measurements of MSZW dependence on cooling rate and agitating rate. It was experimentally observed that there is rise of solubility with increase of temperature. When the temperature becomes higher, solubility gradually declines. In this investigation, MSZW was observed to enhance with increase of cooling rate and decrease with increase of agitating rate.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Braatz, R.D, Advanced control of crystallization processes, Annu. Rev. Control, 2002, vol. 26, pp. 87–89.

    Article  Google Scholar 

  2. Wohlgemuth, K., Kordylla, A., Ruether, F., and Schembecker, G, Experimental study of the effect of bubbles on nucleation during batch cooling crystallization, Chem. Eng. Sci., 2009, vol. 64, pp. 4155–4163.

    Article  CAS  Google Scholar 

  3. Lubelli, B. and Rooij, M.R, NaCl crystallization in restoration plasters, Constr. Build. Mater., 2009, vol. 23, pp. 1736–1742.

    Article  Google Scholar 

  4. Lorenzo, M.L. and Silvestre, C, Non-isothermal crystallization of polymers, Prog. Polym. Sci., 1999, vol. 24, pp. 917–950.

    Article  Google Scholar 

  5. Selvaraju, K., Valluvan, R., and Kumararaman, S, Experimental determination of metastable zone width, induction period, interfacial energy and growth of nonlinear optical 1-glutamic acid hydrochloride single crystals, Mater. Lett., 2006, vol. 60, pp. 1565–1569.

    Article  CAS  Google Scholar 

  6. Kwang-Joo, K., and Alfons, M, Estimation of metastable zone width in different nucleation processes, Chem. Eng. Sci., 2001, vol. 56, pp. 2315–2324.

    Article  Google Scholar 

  7. Titiz-Sargut, S. and Ulrich, J, Application of a protected ultrasound sensor for the determination of the width of the metastable zone, Chem. Eng. Process., 2003, vol. 42, pp. 841–846.

    Article  CAS  Google Scholar 

  8. Trifkovic, M., Sheikhzadeh, M., and Rohani, S, Determination of metastable zone width for combined anti-solvent/cooling crystallization, J. Cryst. Growth, 2009, vol. 311, pp. 3640-3650.

    Article  CAS  Google Scholar 

  9. Kubota, N.A, Unified interpretation of metastable zone widths and induction times measured for seeded solutions, J. Cryst. Growth, 2010, vol. 312, pp. 548–554.

    Article  CAS  Google Scholar 

  10. Sullivan, B.O., The application of in situ analysis to crystallization process development, PhD Thesis, Dublin: Univ. College Dublin, 2005.

    Google Scholar 

  11. Myerson, A.S. and Jang, S.M, The effect of calcaneal osteotomy on contact characteristics of the tibiotalar joint, Foot, 1995, vol. 5, pp. 137–142.

    Article  Google Scholar 

  12. Gurbuz, H. and Ozdemir, B, Experimental determination of the metastable zone width of borax decahydrate by ultrasonic velocity measurement, J. Cryst. Growth, 2003, vol. 252, pp. 343–349.

    Article  CAS  Google Scholar 

  13. Barrett, P. and Glennon, B, Characterizing the metastable zone width and solubility curve using Lasentec FBRM and PVM, Trans. IChemE, Part A: Eng. Res. Des., 2002, vol. 80, pp. 799–805.

    CAS  Google Scholar 

  14. Kubota, N, Effect of sample volume on metastable zone width and induction time, J. Cryst. Growth, 2012, vol. 345, pp. 27–33.

    Article  CAS  Google Scholar 

  15. Azimi, G. and Papangelakis, V.G, The solubility of gypsum and anhydrite in simulated laterite pressure acid leach solutions up to 250, Hydrometallurgy, 2010, vol. 102, pp. 1–13.

    Article  CAS  Google Scholar 

  16. Marliacy, P., Solimando, R., Bouroukba, M., and Schuffenecker, L, Thermodynamics of crystallization of sodium sulfate decahydrate in H2O–NaCl–Na2SO4: Application to Na2SO4 · 10H2O-based latent heat storage materials, Thermochim. Acta, 2000, vol. 344, pp. 85–94.

    Article  CAS  Google Scholar 

  17. Rodriguez-Navarro, C., Doehne, E., and Sebastian, E, How does sodium sulfate crystallize? Implications for the decay and testing of building materials, Cem. Concr. Res., 2000, vol. 30, pp. 1527–1534.

    Article  CAS  Google Scholar 

  18. Steiger, M. and Asmussen, S., Crystallization of sodium sulfate phases in porous materials: The phase diagram Na2SO4–H2O and the generation of stress. Geochim. Cosmochim. Acta, 2008, vol. 72, pp. 4291–4306.

    Article  CAS  Google Scholar 

  19. Genkinger, S. and Putnis, A, Crystallization of sodium sulfate: Supersaturation and metastable phases, Environ. Geol., 2007, vol. 52, pp. 329–337.

    Article  CAS  Google Scholar 

  20. Qiaoli Chen, Jingkang Wang, and Ying Bao, Determination of the crystallization thermodynamics and kinetics of L-tryptophan in alcohols–water system, Fluid Phase Equilib., 2012, vol. 313, pp. 182–189.

    Article  Google Scholar 

  21. Heinrich, J. and Ulrich, J, Crystallization kinetics of a-ammonium chloride monitored by in-situ measurement techniques, Adv. Powder Technol., 2011, vol. 22, pp. 190–196.

    Article  CAS  Google Scholar 

  22. Nyvlt, J, Kinetics of nucleation in solutions, J. Cryst. Growth, 1968, vol. 3, pp. 377–383.

    Article  Google Scholar 

  23. Chen Xia and Li Hong, Effects of ultrasound on crystal nucleation of Na2SO4, J. Tianjin Univ., 2011, vol. 44, pp. 835–839.

    CAS  Google Scholar 

  24. Nielsen, A.E. and Söhnel, O, Interfacial tensions electrolyte crystal-aqueous solution, from nucleation data, J. Cryst. Growth, 1971, vol. 11, pp. 233–242.

    Article  CAS  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Key Laboratory of Jiangxi Province for Persistent Pollutants Control and Resources Recycle, School of Environment and Chemical Engineering, Nanchang Hangkong University, Nanchang, 330063, China

    Guisheng Zeng, Hui Li, Sheng Huang & Xianyong Wang

  2. Department of Mechanical Engineering, University of Wisconsin-Milwaukee, Milwaukee, Wisconsin, 53211, United States

    Guisheng Zeng & Junhong Chen

Authors
  1. Guisheng Zeng
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Hui Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Sheng Huang
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Xianyong Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Junhong Chen
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Guisheng Zeng.

Additional information

The article is published in the original.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zeng, G., Li, H., Huang, S. et al. Determination of metastable zone width and the primary nucleation kinetics of sodium sulfate. Theor Found Chem Eng 49, 869–876 (2015). https://doi.org/10.1134/S0040579515050309

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1134/S0040579515050309

Keywords

Search

Navigation