Abstract
Silicon oxynitride films have been deposited with SiCl4 by remote-plasma enhanced chemical vapor deposition (PECVD) at a substrate temperature of 250°C. Different mixtures of O2 and NH3 were used to obtain different oxynitride compositions ranging from SiO2 to an stoichiometry close to that of silicon nitride. Rutherford backscattering spectrometry was used to determine the chemical composition of the SiOxNy films. The behavior of the IR absorption spectra as well as the refractive index measured by ellipsometry were used to estimate the effect of the different deposition parameters. It was found that the IR spectra show a shift of the characteristic peak associated with the stretching vibration mode of the Si-O-Si bonds towards lower wavenumbers as the relative concentration of ammonia was increased with respect oxygen. No double peaks associated with silicon oxide and silicon nitride were observed, indicating the formation of an homogeneous alloy. The IR spectra did not show any presence of water or hydrogen related impurities in the film. Also the effect of a hydrogen flow added during the deposition process on the structural characteristics of the deposited films was studied using dielectric spectroscopy and atomic force microscopy measurements showing that the hydrogen flow added during deposition results in a reduction of the film roughness and a planarization effect, which is very interesting for the application of these films in microelectronics devices.
Similar content being viewed by others
References
R. C. Sun, J. T. Clements and J. J. Nelson, 18th Annual Proc. Reliability Phys (IEEE, Las Vegas, 1980) p. 244.
A. Ortiz, S. Lopez, C. Falcony, M. Farias, L. Cota-Araiza and G. Soto, J. Electronic Materials 19 (1990) 1411.
J. C. Alonso, A. Ortiz, C. Falcony and M. Garcia, J. Vac. Sci. Technol. A 13 (1995) 244.
S. Fujita and A. Sasaki, J. Electrochem. Soc. 135 (1988) 2566.
Dissado and R. M. Hill, Nature 279 (1979) 685; R. M. HILL, Thin Solid Films 125 (1985) 277.
A. Ortiz, J. C. Alonso, C. Falcony, M. H. Farias, L. Cota-Araiza and G. Soto, J. Electrochem. Soc. 140 (1993) 3014.
L. R. Doolite, Nucl. Instrum. Methods B9 (1985) 344.
R. M. Hill, Thin Solid Films 125 (1985) 277.
Idem., J. Mater. Sci. 16 (1981) 118.
A. K. Joncher, Thin Solid Films 100 (1983) 329.
Idem., “Dielectric Relaxation in Solids” (Chelsea Dielectric Press Ltd., London, 1983) p. 10.
D. V. Tsu, G. Lucovsky, M. J. Mantini and S. S. Chao, J. Vac. Sci. Technol. A 5 (1987) 1998.
D. Schalch, A. Scharmann and R. Wolfrat, Thin Solid Films 124 (1985) 301.
Y. Ma and G. Lucovsky, J. Vac. Sci. Technol. B 12 (1994) 04.
C. H. Ling, C. I. Y. Kevok and K. Prasad, J. Vac. Sci. Technol. A 5 (1987) 1874.
M. Hernandez Velez, O. Sanchez Garrido C. GÓmez Aleixandre, J. Sanchez Olias, F. Fernandez Gutierrez and J. M. Albella, J. Mater. Sci.: Materials in Electronics 7 (1996) 297.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Sanchez, O., Martinez-Duart, J.M., Gomez-Sanroman, R.J. et al. SiOxNy Films deposited with SiCl4 by remote plasma enhanced CVD. Journal of Materials Science 34, 3007–3012 (1999). https://doi.org/10.1023/A:1004620409994
Issue Date:
DOI: https://doi.org/10.1023/A:1004620409994