Abstract
A trial test method is introduced to form and magnify regular interface. Through researching on the carbonation of the magnifying interfacial transition zone (ITZ), the practical carbonation of the concrete can be simulated. Because the diffusion rate of CO2 in the ITZ is several times greater than that in the bulk paste, the diffusion rate and direction of CO2 will change and form a new carbonation front line. An interfacial effect zone caused by the ITZ will change the distribution of the complete carbonation zone and the partial carbonation zone. One of the important reasons for the formation of the partial carbonation zone was the existence of the interfacial effect zone. Consequently, the method mentioned in this paper provides a new way for researching on the microstructure of the cement based materials during the carbonation process.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Wang L, Ueda T. Mesoscale Modeling of Water Penetration into Concrete by Capillary Absorption[J]. Ocean Engineering, 2011, 38 (5): 19–28
Yu H, Hartt W H. Modeling Corrosion Initiation of Reinforcing Steel in Concrete: Effect of Non-diffusive Coarse Aggregate[J]. Composite Material, 2011, 45(1): 53–69
MASO J C. The Bond Between Aggregates and Hydrated Cement Pastes[C]. in: Proceedings of 7th International Congress on the Chemistry of Cement, 1980
Vivian WY, Tam C M, Gao X F. Carbonation Around Near Aggregate Regions of Old Hardened Concrete Cement Paste[J]. Cement and Concrete Research, 2005, 35 (6): 1180–1186
Scrivener K L, Bentur A, Pratt P L. Quantitative Characterization of the Transition Zone in High Strength Concretes[J]. Advances in Cement Research, 1988, 1 (4): 230–237
Breton D, Ballivy G. Correlation Between the Transport Properties of the Transition Zone and Its Mineral Composition and Microstructure [C]. The Modelling of Microstructure and Its Potential for Studying Transport Properties and Durability, 1994
Yang C C, Su J K. Approximate Migration Coefficient of Interfacial Transition Zone and the Effect of Aggregate Content on the Migration Coefficient of Mortar[J]. Cement and Concrete Research, 2002, 32 (10): 1559–1565
Sun G W, Sun W. Influence of Aggregates on Chloride Ion Diffusion Coefficient in Cement-Based Composite Materials[J]. Journal of the Chinese Ceramic Society, 2011, 39(4): 662–669
Basheer L, Basheer P A M, Long A E. Influence of Coarse Aggregate on the Permeation, Durability and the Microstructure Characteristics of Ordinary Portland Cement Concrete[J]. Construction and Building Materials, 2005, 19(4): 682–690
Morandeau A, Thiéry M, Dangla P. Investigation of the Carbonation Mechanism of CH and C-S-H in Terms of Kinetics, Microstructure Changes and Moisture Properties[J]. Cement and Concrete Research, 2014 (56): 153–170
Huang Q H, Jiang Z L, Zhang W P, et al. Numerical Analysis of the Effect of Coarse Aggregate Distribution on Concrete Carbonation[J]. Construction and Building Materials, 2012 (37): 27–35
Xu Y X. Research on Several Problems about the Carbonation Resistance of the Concrete[D]. Nanjing: Southeast University, 2011
Li Q Q. Investigation on Microstructure of Concrete under Carbonation and Coupling Action of Load and Carbonation[D]. Nanjing: Southeast University, 2012
Delagrave A, Bigas J P, Olivier J P, et al. Influence of the Interfacial Zone on the Chloride Diffusivity of Mortars[J]. Advanced Cement Based Material, 1997, 5(3-4): 81–92
Thiery M, Villain G, Dangla P, et al. Investigation of the Carbonation Front Shape on Cementitious Materials: Effects of the Chemical Kinetics[J]. Cement and Concrete Research, 2007 (37): 1047–1058
Papadakis V G, Vayenas C G, Fardis M N. Fundamental Modeling and Experimental Investigation of Concrete Carbonation[J]. ACI Materials Journal, 1991, 88(4): 363–373
Villain G, Platret G. Two Experimental Methods to Determine Carbonation Profiles in Concrete[J]. ACI Materials Journal, 2006, 103(4): 265–371
Wan K S, Xu Q, Wang Y D, et al. 3D Spatial Distribution of the Calcium Carbonate Caused by Carbonation of Cement Paste[J]. Cement and Concrete Composites, 2014 (45): 255–263
Breton D, Olivier J P, Ballivy G. Diffusivity of Chloride Ions in the Transition Zone Between Cement Paste and Granite[C]. Interfaces Between Cementitious Composites, 1992
Bourdette B, Ringot E, Olivier J P. Modeling of the Transition Zone Porosity[J]. Cement and Concrete Research, 1995, 25(4): 741–751
Zheng J J, Zhou X Z. Prediction of the Chloride Diffusion Coefficient of Concrete[J]. Material and Structure, 2007, 40(7): 693–701
Author information
Authors and Affiliations
Corresponding author
Additional information
Funded by the National Natural Science Foundation of China (No. 51178103)
Rights and permissions
About this article
Cite this article
Shen, Q., Pan, G. & Zhan, H. Test method to simulate the influence of the interface on the concrete carbonation process. J. Wuhan Univ. Technol.-Mat. Sci. Edit. 31, 594–598 (2016). https://doi.org/10.1007/s11595-016-1415-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11595-016-1415-7