Skip to main content
SpringerLink
Log in

Studies on the solid acidity of heated and cation-exchanged montmorillonite using n-butylamine titration in non-aqueous system and diffuse reflectance Fourier transform infrared (DRIFT) spectroscopy

  • Original Paper
  • Published:
Physics and Chemistry of Minerals Aims and scope Submit manuscript

Abstract

The effects of heating and cation exchange on the solid acidity of montmorillonite were investigated using n-butylamine titration in non-aqueous system and diffuse reflectance Fourier transform infrared spectroscopy. The number of total, Brønsted, and Lewis acid sites showed the same modulation tendency with increasing heating temperature, reaching a maximum at 120 °C and subsequently decreasing until it reaches a minimum at 600 °C. The Lewis acid sites result from unsaturated Al3+ cations, and their number increased with the heating temperature due to the dehydration and dehydroxylation of montmorillonite. The generation and evolution of Brønsted acidity were mainly related to interlayer-polarized water molecules. Water adsorbed on the unsaturated Al3+ ions also acted as a Brønsted acid. The acid strength of the Brønsted acid sites was dependent on the polarization ability of the exchangeable cation, the amount of interlayer water, and the degree of dissociation of the interlayer water coordinated to exchangeable cations. All cation-exchanged montmorillonites exhibited different numbers of acid sites and various distributions of acid strength. Brønsted acidity was predominant in Al3+-exchanged montmorillonite, whereas the Na+- and K+-exchanged montmorillonites showed predominantly Lewis acidity. Moreover, Mg2+- and Li+-exchanged montmorillonites exhibited approximately equal numbers of Brønsted and Lewis acid sites. The Brønsted acidity of cation-exchanged montmorillonite was positively correlated with the charge-to-radius ratios of the cations, whereas the Lewis acidity was highly dependent on the electronegativity of the cations. The acid strengths of Al3+- and Mg2+-exchanged montmorillonites were remarkably higher than those of monovalent cation-exchanged montmorillonites, showing the highest acid strength (H 0 ≤ −3.0). Li+- and Na+-exchanged montmorillonites exhibited an acid strength distribution of −3.0 < H 0 ≤ 4.8, with the acid strength ranging primarily from 1.5 to 3.3 in Li+-exchanged montmorillonite, whereas only weaker-strength acid sites (1.5 < H 0 ≤ 4.8) were present in K+-exchanged montmorillonite. The results of the catalysis experiments indicated that montmorillonite promoted the thermal decomposition of the model organic. The catalytic activity showed a positive correlation with the solid acidity of montmorillonite and was affected by cation exchange, which occurs naturally in geological processes.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  • Adams J, McCabe R (2006) Clay minerals as catalysts. In: Bergaya F, Theng BKG, Lagaly G (eds) Handbook of clay science, vol 1. Elsevier, Amsterdam, pp 541–581

    Chapter  Google Scholar 

  • Akçay M (2005) The surface acidity and characterization of Fe-montmorillonite probed by in situ FT-IR spectroscopy of adsorbed pyridine. Appl Catal A Gen 294(2):156–160

    Article  Google Scholar 

  • Arena F, Dario R, Parmaliana A (1998) A characterization study of the surface acidity of solid catalysts by temperature programmed methods. Appl Catal A Gen 170(1):127–137

    Article  Google Scholar 

  • Benesi H (1957) Acidity of catalyst surfaces. II. Amine titration using Hammett indicators. J Phys Chem 61(7):970–973

    Article  Google Scholar 

  • Bhattacharyya KG, Gupta SS (2008) Adsorption of a few heavy metals on natural and modified kaolinite and montmorillonite: a review. Adv Colloid Interface 140(2):114–131. doi:10.1016/j.cis.2007.12.008

    Article  Google Scholar 

  • Billingham J, Breen C, Yarwood J (1996) In situ determination of Brønsted/Lewis acidity on cation-exchanged clay mineral surfaces by ATR-IR. Clay Miner 31(4):513–522

    Article  Google Scholar 

  • Bjølykke K (1998) Clay mineral diagenesis in sedimentary basins–a key to the prediction of rock properties. Examples from the North Sea Basin. Clay Miner 33(1):15–34

    Article  Google Scholar 

  • Breen C (1991a) Thermogravimetric and infrared study of the desorption of butylamine, cyclohexylamine and pyridine from Ni-and Co-exchanged montmorillonite. Clay Miner 26(4):487–496

    Article  Google Scholar 

  • Breen C (1991b) Thermogravimetric study of the desorption of cyclohexylamine and pyridine from an acid-treated Wyoming bentonite. Clay Miner 26(4):473–486

    Article  Google Scholar 

  • Breen C, Moronta AJ (2001) Influence of exchange cation and layer charge on the isomerization of α-pinene over SWy-2, SAz-1 and Sap-Ca. Clay Miner 36(4):467–472. doi:10.1180/0009855013640001

    Article  Google Scholar 

  • Breen C, Deane A, Flynn J (1987) The acidity of trivalent cation-exchanged montmorillonite. Temperature-programmed desorption and infrared studies of pyridine and n-butylamine. Clay Miner 22(2):169–178

    Article  Google Scholar 

  • Brown DR, Rhodes CN (1997) Brønsted and Lewis acid catalysis with ion-exchanged clays. Catal Lett 45(1):35–40. doi:10.1023/a:1019038806333

    Article  Google Scholar 

  • Cseri T, Békássy S, Figueras F, Rizner S (1995) Benzylation of aromatics on ion-exchanged clays. J Mol Catal A Chem 98(2):101–107. doi:10.1016/1381-1169(95)00016-x

    Article  Google Scholar 

  • Dontsova KM, Norton LD, Johnston CT, Bigham JM (2004) Influence of exchangeable cations on water adsorption by soil clays. Soil Sci Soc Am J 68(4):1218–1227. doi:10.2136/sssaj2004.1218

    Article  Google Scholar 

  • Flessner U, Jones DJ, Rozière J, Zajac J, Storaro L, Lenarda M, Pavan M, Jiménez-López A, Rodríguez-Castellón E, Trombetta M, Busca G (2001) A study of the surface acidity of acid-treated montmorillonite clay catalysts. J Mol Catal A Chem 168(1–2):247–256. doi:10.1016/s1381-1169(00)00540-9

    Article  Google Scholar 

  • Frenkel M (1974) Surface acidity of montmorillonites. Clays Clay Miner 22(5–6):435–441

    Article  Google Scholar 

  • Fripiat J, Cruz-Cumplido M (1974) Clays as catalysts for natural processes. Annu Rev Earth Plant Sci 2:239

    Article  Google Scholar 

  • Geatches DL, Clark SJ, Greenwell HC (2010) Role of clay minerals in oil-forming reactions. J Phys Chem A 114(10):3569–3575. doi:10.1021/jp9096869

    Article  Google Scholar 

  • Hart MP, Brown DR (2004) Surface acidities and catalytic activities of acid-activated clays. J Mol Catal A Chem 212(1–2):315–321. doi:10.1016/j.molcata.2003.11.013

    Article  Google Scholar 

  • He H, Yang D, Yuan P, Shen W, Frost RL (2006) A novel organoclay with antibacterial activity prepared from montmorillonite and Chlorhexidini Acetas. J Colloid Interface Sci 297(1):235–243. doi:10.1016/j.jcis.2005.10.031

    Article  Google Scholar 

  • Heller-Kallai L (2006) Thermally modified clay minerals. In: Bergaya F, Theng BKG, Lagaly G (eds) Handbook of clay science, vol 1. Elsevier, Amsterdam, pp 289–308

    Chapter  Google Scholar 

  • Hetényi M (1995) Simulated thermal maturation of type I and III kerogens in the presence, and absence, of calcite and montmorillonite. Org Geochem 23(2):121–127. doi:10.1016/0146-6380(94)00120-p

    Article  Google Scholar 

  • Jankovič Ľ, Komadel P (2003) Metal cation-exchanged montmorillonite catalyzed protection of aromatic aldehydes with Ac2O. J Catal 218(1):227–233. doi:10.1016/s0021-9517(03)00138-6

    Article  Google Scholar 

  • Jerónimo D, Guil JM, Corbella BM, Vasques H, Miranda A, Silva JM, Lobato A, Pires J, Carvalho AP (2007) Acidity characterization of pillared clays through microcalorimetric measurements and catalytic ethylbenzene test reaction. Appl Catal A Gen 330:89–95. doi:10.1016/j.apcata.2007.07.013

    Article  Google Scholar 

  • Johns WD (1979) Clay mineral catalysis and petroleum generation. Annu Rev Earth Plant Sci 7:183

    Article  Google Scholar 

  • Johns WD, Shimoyama A (1972) Clay minerals and petroleum-forming reactions during burial and diagenesis. AAPG Bull 56(11):2160–2167

    Google Scholar 

  • Khaorapapong N, Ontam A, Youngme S, Ogawa M (2008) Solid-state intercalation and in situ formation of cadmium sulfide in the interlayer space of montmorillonite. J Phys Chem Solids 69(5–6):1107–1111

    Article  Google Scholar 

  • Larter SR, Douglas AG (1982) Pyrolysis methods in organic geochemistry: an overview. J Anal Appl Pyrol 4(1):1–19. doi:10.1016/0165-2370(82)80023-5

    Article  Google Scholar 

  • Liu D, Yuan P, Liu H, Cai J, Qin Z, Tan D, Zhou Q, He H, Zhu J (2011) Influence of heating on the solid acidity of montmorillonite: a combined study by DRIFT and Hammett indicators. Appl Clay Sci 52(4):358–363. doi:10.1016/j.clay.2011.03.016

    Article  Google Scholar 

  • Madejová J, Komadel P (2001) Baseline studies of the clay minerals society source clays: infrared methods. Clays Clay Miner 49(5):410–432

    Article  Google Scholar 

  • Mahmoud S, Hammoudeh A, Al-Noaimi M (2003) Pretreatment effects on the catalytic activity of Jordanian bentonite. Clays Clay Miner 51(1):52–57. doi:10.1346/ccmn.2003.510106

    Article  Google Scholar 

  • Mortland M, Raman K (1968) Surface acidity of smectites in relation to hydration, exchangeable cation, and structure. Clays Clay Miner 16(5):393–398

    Article  Google Scholar 

  • Motokura K, Nakagiri N, Mizugaki T, Ebitani K, Kaneda K (2007) Nucleophilic substitution reactions of alcohols with use of montmorillonite catalysts as solid Brønsted acids. J Org Chem 72(16):6006–6015. doi:10.1021/jo070416w

    Article  Google Scholar 

  • Noyan H, Önal M, Sarikaya Y (2006) The effect of heating on the surface area, porosity and surface acidity of a bentonite. Clays Clay Miner 54(3):375–381. doi:10.1346/ccmn.2006.0540308

    Article  Google Scholar 

  • Reddy CR, Iyengar P, Nagendrappa G, Jai Prakash BS (2005) Esterification of succinic anhydride to di-(p-cresyl) succinate over Mn + -montmorillonite clay catalysts. J Mol Catal A Chem 229(1–2):31–37. doi:10.1016/j.molcata.2004.10.044

    Article  Google Scholar 

  • Reddy CR, Nagendrappa G, Jai Prakash BS (2007) Surface acidity study of Mn + -montmorillonite clay catalysts by FT-IR spectroscopy: correlation with esterification activity. Catal Commun 8(3):241–246

    Article  Google Scholar 

  • Reddy CR, Bhat YS, Nagendrappa G, Jai Prakash BS (2009) Brønsted and Lewis acidity of modified montmorillonite clay catalysts determined by FT-IR spectroscopy. Catal Today 141(1–2):157–160

    Article  Google Scholar 

  • Rupert JP, Granquist WT, Pinnavaia TJ (1987) Catalytic properties of clay minerals. Chemistry of clays and clay minerals. Longman scientific and technical, New York

    Google Scholar 

  • Shimizu K-i, Higuchi T, Takasugi E, Hatamachi T, Kodama T, Satsuma A (2008) Characterization of Lewis acidity of cation-exchanged montmorillonite K-10 clay as effective heterogeneous catalyst for acetylation of alcohol. J Mol Catal A Chem 284(1–2):89–96. doi:10.1016/j.molcata.2008.01.013

    Article  Google Scholar 

  • Singh B, Patial J, Sharma P, Agarwal SG, Qazi GN, Maity S (2007) Influence of acidity of montmorillonite and modified montmorillonite clay minerals for the conversion of longifolene to isolongifolene. J Mol Catal A Chem 266(1–2):215–220

    Article  Google Scholar 

  • Tyagi B, Chudasama CD, Jasra RV (2006) Characterization of surface acidity of an acid montmorillonite activated with hydrothermal, ultrasonic and microwave techniques. Appl Clay Sci 31(1–2):16–28

    Article  Google Scholar 

  • Ursu AV, Jinescu G, Gros F, Nistor ID, Miron ND, Lisa G, Silion M, Djelveh G, Azzouz A (2011) Thermal and chemical stability of Romanian bentonite. J Therm Anal Calorim 106(3):965–971. doi:10.1007/s10973-011-1414-z

    Article  Google Scholar 

  • Vaccari A (1999) Clays and catalysis: a promising future. Appl Clay Sci 14(4):161–198

    Article  Google Scholar 

  • Varma RS (2002) Clay and clay-supported reagents in organic synthesis. Tetrahedron 58(7):1235–1255

    Article  Google Scholar 

  • Walling C (1950) The acid strength of surfaces. J Am Chem Soc 72(3):1164–1168

    Article  Google Scholar 

  • Wattel-Koekkoek EJW, van Genuchten PPL, Buurman P, van Lagen B (2001) Amount and composition of clay-associated soil organic matter in a range of kaolinitic and smectitic soils. Geoderma 99(1–2):27–49. doi:10.1016/s0016-7061(00)00062-8

    Article  Google Scholar 

  • Zheng Y, Zaoui A, Shahrour I (2010) Evolution of the interlayer space of hydrated montmorillonite as a function of temperature. Am Mineral 95(10):1493–1499. doi:10.2138/am.2010.3541

    Article  Google Scholar 

  • Zhou CH (2011) Clay mineral-based catalysts and catalysis. Appl Clay Sci 53(2):85

    Article  Google Scholar 

Download references

Acknowledgments

This work was financially supported by the National Basic Research Program of China (Grant No. 2012CB214704-01), the National Scientific Foundation of China (No. 41272059) and the National S&T Major Project of China No. 2011ZX05008-002-21). This is a contribution (No. IS-1642) from GIGCAS.

Author information

Authors and Affiliations

  1. CAS Key Laboratory of Mineralogy and Metallogeny, Guangzhou Institute of Geochemistry, Chinese Academy of Sciences, Guangzhou, 510640, China

    Hongmei Liu, Dong Liu, Peng Yuan, Daoyong Tan, Hongping He & Jianxi Zhu

  2. University of Chinese Academy of Sciences, Beijing, 100049, China

    Hongmei Liu & Daoyong Tan

  3. School of Ocean and Earth Science, Tongji University, Shanghai, 200092, China

    Jingong Cai

  4. The State Key Laboratory of Organic Geochemistry, Guangzhou Institute of Geochemistry, Chinese Academy of Sciences, Guangzhou, 510640, China

    Zhiguang Song

Authors
  1. Hongmei Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Dong Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Peng Yuan
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Daoyong Tan
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Jingong Cai
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Hongping He
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Jianxi Zhu
    View author publications

    You can also search for this author in PubMed Google Scholar

  8. Zhiguang Song
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Peng Yuan.

Electronic supplementary material

Below is the link to the electronic supplementary material.

Supplementary material 1 (DOC 44 kb)

Rights and permissions

Reprints and permissions

About this article

Cite this article

Liu, H., Liu, D., Yuan, P. et al. Studies on the solid acidity of heated and cation-exchanged montmorillonite using n-butylamine titration in non-aqueous system and diffuse reflectance Fourier transform infrared (DRIFT) spectroscopy. Phys Chem Minerals 40, 479–489 (2013). https://doi.org/10.1007/s00269-013-0585-5

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00269-013-0585-5

Keywords

Search

Navigation