Abstract
Partially acidulated phosphate rocks were prepared from unground North Carolina phsophate rock and H3PO4 by (i) mixing phosphate rock with the requisite amount of H3PO4, (ii) mixing with a portion of the acid followed by adding the remaining acid during granulation and (iii) single-step acidulation and granulation. The degrees of acidulation were 20, 30, 40 and 50%. Only 20% and 30% acidulations were done by method (iii). The phosphate rock granulated readily on addition of H3PO4 either as in method (ii) or (iii) and the products did not need external drying before storage. The citric and water soluble P showed that from the viewpoint of acid-phosphate rock interaction all three methods of preparation were satisfactory. The granules were equally strong as or stronger than commercially available single or triple superphosphate samples tested. The percent degradation on abrasion was less than 4% compared to about 8% for superphosphate and 0.4% for triple superphosphate. A sand incubation study suggested an interaction in the partially acidulated phosphate rock between the monocalcium phosphate component and unreacted phosphate rock which initially increased the solubility of P.
Similar content being viewed by others
References
AOAC (1980) Official methods of analysis. Ed. W. Horwitz. 13th ed, pp 9–10
Ashby DL, Fenster WE and Attoe OJ (1966) Effect of partial acidulation and elemental sulphur on availability of phosphorus in rock phosphate. Agron J 58, 621–625
Aslyng HC (1954) The lime and phosphate potentials of soils. The solubility and availability of phosphates. Roy. Vet. Agric. Coll. Copenhagen Yearbook, pp 1–50
Braithwaite AC (1983) Physical and chemical properties of phosphate rocks partially acidulated with phosphoric acid. Proc. 194 Tech. Conf. NZ Fertiliser manufacturers' research association, pp 256–266
Chapman HD and Pratt PF (1961) Methods of analysis for soils plants and waters. University of California, USA. pp 169
Chien SH and Hammond LL (1978) A comparison of various laboratory methods for predicting the agronomic potential of phosphate rocks for direct application. Soil Sci Soc Am J 42:935–939
Garbouchev IP (1981) The manufacture and agronomic efficiency of a partially acidulated phosphate rock fertiliser. Soil Sci Soc Am J 45:970–974
Hammond LL, Chien SH and Polo JR (1980) Phosphorus availability from partial acidulation of two phosphate rocks. Fert. Res. 1:37–49
Logan TL and McLean EO (1977) Diffusion of32P from partially acidulated rock phosphate. Soil Sci 123:203–206
Lutz JA Jr (1973) Effect of partially acidulated rock phosphate and concentrated superphosphate on yield and chemical composition of alfalfa and Orchardgrass. Agron J 65:286–289
McLean EO and Balam BS (1967) Partially acidulated rock phosphates as a source of phosphorus to plants. III. Uptake of corn from soils of different calcium status. Soil Sci Soc Am Proc 31:811–814
McLean EO and Logan TJ (1970) Source of phosphorus for plants grown in soils with different phosphorus fixation tendencies. Soil Sci Soc Am Proc 34:807–911
McLean EO and Wheeler RW (1964) Partially acidulated rock phosphates as a source of phosphorus to plants. I. Growth chamber studies. Soil Sci Soc Am Proc 28:545–550
McLean EO, Wheeler RW and Watson JD (1964) Partially acidulated rock phosphates as a source of phosphorus to plants. II. Growth chamber and field corn studies. Soil Sci Soc Am Proc 29:625–628
Mokwunye AU and Chien SH (1980) Reactions of partially acidulated phosphate rock with soils from the tropics. Soil Sci Soc Am J 44:477–482
Murphy J and Riley JP (1962) A modified single solution method for the determination of phosphate in natural waters. Anal Chimica Acta 27:31–37
Phillips AB, Young RD, Lewis Jr JS and Heil FG (1958) Development of a one-step process for production of granular triple superphosphate. Agri and Food Chem 6:584–587
Rajan SSS and Edge EA (1980) Dissolution of granulated low-grade phosphate rocks, phosphate rocks/sulphur, and superphosphate in soil. NZ J Agric Res 23:451–456
Tanke MA, Brewer KP and Rusli IT (1983) Evaluation of some ‘unground’ phosphate rocks in dihydrate phosphoric acid production. Presented at the American Chemical Society 186th national meeting (Div Fert and Soil Chem), Washington, DC, USA
Tennessee Valley Authority (1970) ‘TVA procedures for determining physical properties of fertilisers’ Special report no. S-444, NFDC, Muscle Shoals, Alabama 35660
USDA-TVA (1964) Superphosphate: Its history, chemistry and manufacture. US Government Printing Office, Washington DC. pp 274–275
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Rajan, S. Partial acidulation of an ‘unground’ phosphate rock: I. Preparation and characteristics. Fertilizer Research 8, 147–155 (1985). https://doi.org/10.1007/BF01048898
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF01048898