Abstract
Homogeneous TiO2 gel powders were prepared by hydrolysis and condensation of titanium(IV) isopropoxide with HCl or SnCl2 catalysts, by working under reduced pressure or in air. Ti(IV) alkoxide was previously modified by reaction with formic or acetic acid, used as chelating ligands, when gelation was performed in acidic catalysis. Crude TiO2 xerogels were purified by water reflux treatment in order to induce a low temperature crystallisation to the anatase phase. Both crude and purified TiO2 samples were characterised by XRD, FT-IR, SEM, and N2 adsorption analysis. Thermoanalyses (TG, DTA, DTG, TG-MS, TG-GC-MS) were carried out to quantify the residual organic components in the crude TiO2 gels and to obtain stoichiometric formulas to describe their chemical compositions. XRD data of purified TiO2 powders were processed by means of a Rietveld refinement procedure to determine TiO2 polymorphs, crystallite sizes and cell parameters, before their use in photocatalytic tests. The photoactivity of the purified TiO2 anatase powders was studied by using 4-nitrophenol degradation as “probe” reaction carried out in a batch and/or a membrane photoreactor. Samples prepared by using formic acid or SnCl2 were the most photoactive, whereas specimens gelled under vacuum treatment showed detrimental effects.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
D.F. Ollis and H. Al-Ekabi, Photocatalyic Purification of Water and Treatment and Air (Elsevier, Amsterdam, 1993).
G.R. Helz, R.G. Zepp, and D.G. Crosby, Aquatic and Surface Photochemistry (Lewis Publishers, Boca Raton, 1994).
V. Augugliaro, L. Palmisano, A. Sclafani, C. Minero, and E. Pelizzetti, Toxicol. Environ. Chem. 16, 2015 (1988).
V. Augugliaro, L. Palmisano, M. Schiavello, A. Sclafani, L. Marchese, G. Martra, and F. Miano, Appl. Catal. 69, 323 (1991).
R. Molinari, L. Palmisano, E. Drioli, and M. Schiavello, J. Membr. Sci. 206, 399 (2002).
B.E. Yoldas, J. Mater. Sci. 21, 1087 (1986).
D. Robert and J.V. Weber, J. Mater. Sci. Lett. 18, 97 (1999).
W.W. So, S.B. Park, and S.J. Moon, J. Mater. Sci. Lett. 17, 1219 (1998).
G. Marcì, L. Palmisano, A. Sclafani, A.M. Venezia, R. Campostrini, G. Carturan, C. Martin, V. Rives, and G. Solana, J. Chem. Soc., Faraday Trans. 92, 819 (1996).
G. Facchin, G. Carturan, R. Campostrini, S. Gialanella, L. Lutterotti, L. Armelao, G. Marcì, L. Palmisano, and A. Sclafani, J. Sol-Gel Sci. Technol. 18, 29 (2000).
R. Campostrini, G. Carturan, L. Palmisano, M. Schiavello, and A. Sclafani, Mat. Chem. Phys. 38, 277 (1994).
C. Sanchez, P. Toledano, and F. Ribot, Mater. Res. Soc. Symp. Proc. 180, 47 (1990).
T.J. Boyle, T.M. Alam, C.J. Tafoya, and B.L. Scott, Inorg. Chem. 37, 5588 (1998).
A.P. Hagan, M. G. Lofthouse, F. S. Stone, and M. A. Trevethan, in Studies in Surface Science and Catalysis, edited by B. Delmon, P. Grange, P. Jacobs, and G. Poncelet (Elsevier, Amsterdam, 1979), p. 417.
S.J. Gregg and K.S.W. Sing, Adsorption, Surface Area and Porosity (Academic Press, London, 1982).
P.A. Webb and C. Orr, Analitycal Methods in Fine Particles Technology (Micromeritics Instrument Corporation, Norcross, USA, 1997).
R. Campostrini, M. Ischia, and L. Palmisano, J. Therm. Anal. Cal. 71, 997 (2003).
L. Lutterotti, S. Matthies, and H.-R. Wenk, CPD Newsletter IUCr 21, 14 (1999).
A. Le Bail, J. Non-Cryst. Solids 183, 39 (1995).
L. Lutterotti, R. Campostrini, R. Di Maggio, and S. Gialanella, Mat. Sci. Forum 343, 657 (2000).
M. Ischia, R. Campostrini, G. Carturan, E. García-López, G. Marcí, L. Palmisano, and M. Schiavello, in Proceeding of III CNDR Convegno Nazionale dei Docenti e Ricercatori di Chimica delle Facolta di Ingegneria, Trento, p. 96.
T. López, E. Sánchez, P. Bosch, Y. Meas, and R. Gomez, Mater. Chem. Phys. 32, 141 (1992).
K. Nakamoto, Infrared and Raman Spectra of Inorganic and Coordination Compounds (John Wiley and Sons, New York, 1986).
N.B. Colthup, L.H. Daly, and S.E. Wiberley, Introduction to Infrared and Raman Spetroscopy (Academic Press, San Diego, 1990).
R. Campostrini, M. Ischia, and L. Palmisano, J. Therm. Anal. Cal. 75, 13 (2004).
R. Campostrini, M. Ischia, and L. Palmisano, J. Therm. Anal. Cal. 75, 25 (2004).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Ischia, M., Campostrini, R., Lutterotti, L. et al. Synthesis, Characterization and Photocatalytic Activity of TiO2 Powders Prepared Under Different Gelling and Pressure Conditions. J Sol-Gel Sci Technol 33, 201–213 (2005). https://doi.org/10.1007/s10971-005-5615-4
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s10971-005-5615-4