Abstract
The results are given of a theoretical investigation of heat transfer from thin wires to emulsions in which the disperse phase is low-boiling compared to the dispersion medium. A special feature of heat transfer to such emulsions is observed in the mode of nucleate boiling, when only the droplets of the disperse phase of emulsion are boiling. The transition from the convective mode of heat transfer to nucleate boiling requires high values of temperature gradient ΔT = T W − T 0 at which the temperature of the heat-transfer surface T W is higher than the temperature T S of saturated vapors of the disperse phase by 100 °C and more. Here, T 0 is the temperature of the heat-transfer agent away from the heat-transfer surface. Note that, for pure liquids and solutions, the value of delay of the beginning of boiling ΔT i = T W − T S as a rule does not exceed 1–5 °C. Another feature of heat transfer to the emulsions being treated is a wide temperature range of the mode of nucleate boiling (over 100 °C); the upper limit of this temperature range is defined by the temperature of transition to film boiling of the dispersion medium of the emulsion being investigated that has already boiled by this instant of time. The value of delay of the beginning of boiling is affected significantly by additions of surfactants and adsorbents.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Bulanov, N.V., Teplofiz. Vys. Temp., 2001, vol. 39, no. 3, p. 495 (High Temp. (Engl. transl.), vol. 39, no. 3, p. 462).
Bulanov, N.V., Skripov, V.P., and Shuravenko, N.A., Inzh. Fiz. Zh., 1982, vol. 42, no. 2, p. 235.
Bulanov, N.V., Gasanov, B.M., and Baidakov, V.G., The Mode of Nucleate Boiling of Emulsion with Low-Boiling Disperse Phase, Trudy III Minskogo mezhdunarodnogo foruma po teploobmenu (Proc. III Minsk Int. Forum on Heat Transfer), Minsk: ITMO (Lykov Inst. of Heat and Mass Transfer, Nat. Acad. Sci. of Belarus), 1996, vol. 4, Part 1, p. 54.
Gasanov, B.M., Bulanov, N.V., and Baidakov, V.G., Inzh. Fiz. Zh., 1997, vol. 70, no. 2, p. 185.
Bulanov, N.V., Baidakov, V.G., and Gasanov, B.M., Nucleate Boiling of Emulsions with Low-Boiling Disperse Phase, in Kipenie, krizisy kipeniya, zakrizisnyi teploobmen. Trudy II Rossiiskoi natsional’noi konferentsii po teploobmenu (Boiling, Boiling Crises, Supercritical Heat Transfer. Proceedings of II Russian National Conference on Heat Transfer), Moscow: Izd. MEI (Moscow Inst. of Power Engineering), 1998, vol. 4, p. 49.
Bulanov, N.V. and Gasanov, B.M., Control of the Number of Boiling Centers under Conditions of Heat Transfer to Emulsion with Low-Boiling Disperse Phase, in Trudy III Rossiiskoi natsional’noi konferentsii po teploobmenu (Boiling, Boiling Crises, Supercritical Heat Transfer. Proceedings of II Russian National Conference on Heat Transfer), Moscow: Izd. MEI (Moscow Inst. of Power Engineering), 2002, vol. 4, p. 49.
Bulanov, N.V. and Gasanov, B.M., Special features of Boiling of Emulsions with Low-Boiling Disperse Phase, Trudy V Minskogo mezhdunarodnogo foruma po teploobmenu (Proc. III Minsk Int. Forum on Heat Transfer), Minsk: ITMO (Lykov Inst. of Heat and Mass Transfer, Nat. Acad. Sci. of Belarus), 2004, CDROM.
Bulanov, N.V. and Gasanov, B.M., The Effect of Minor Additions of Adsorbents on the Delay of the Beginning of Boiling, in Metastabil’nye sostoyaniya i fazovye perekhody (Metastable States and Phase Transitions), Ekaterinburg: UrO RAN (Ural Division, Russ. Acad. Sci.), 2004, issue 7, p. 36.
Biryukova, L.V., Danilov, N.N., and Sinitsyn, E.N., Superheating of Pure Liquids and Binary Solutions under Conditions of Convective Heat Transfer to Thin Wire, in Teplofizika metastabil’nykh sistem (Thermophysics of Metastable Systems), Sverdlovsk: UNTs AN SSSR (Ural Sci. Center, USSR Acad. Sci.), 1977, p. 16.
Skripov, V.P. and Bulanov, N.V., Inzh. Fiz. Zh., 1972, vol. 22, no. 4, p. 614.
Skripov, V.P. and Bulanov, N.V., Gidrodin. Teploobmen, 1972, issue 1, p. 41.
Kutateladze, S.S., Osnovy teorii teploobmena (Fundamentals of the Theory of Heat Transfer), Moscow: Atomizdat, 1979.
Mori, Yu., Inui, E., and Komotori, K., Teploperedacha, 1978, vol. 100, no. 4, p. 55 (Russ. transl.).
Gradus, Ya.S., Rukovodstvo po dispersionnomu analizu metodom mikroskopii (Handbook on Dispersion Analysis by Microscopy), Moscow: Khimiya, 1979.
Skripov, V.P., Sinitsyn, V.N., Pavlov, P.A., et al.. Teplofizicheskie svoistva zhidkostei v metastabil’nom sostoyanii. Spravochnik (The Thermal Properties of Liquids in the Metastable State: A Reference Book), Moscow: Atomizdat, 1980.
Reshetnikov, A.V., Isaev, O.A., Mazheiko, N.A., and Bulanov, N.V., Disintegration of a Jet of Boiling-up Water, in Teplomassoobmen MMF-92. Teploobmen v dvukhfaznykh sistemakh (MMF-92 Minsk International Forum on Heat and Mass Transfer. Heat Transfer in Two-Phase Systems), Minsk: ITMO (Lykov Inst. of Heat and Mass Transfer, Nat. Acad. Sci. of Belarus), 1992, vol. 4, p. 111.
Voprosy fiziki kipeniya (Problems in Physics of Boiling), Alad’ev, I.T., Ed., Moscow: Mir, 1964.
Gasanov, B.M. and Bulanov, N.V., The Delay of Nucleate Boiling Crisis in Water/Diethyl Ether and Water/Khladon-113 Systems, in Metastabil’nye sostoyaniya i fazovye perekhody (Metastable States and Phase Transitions), Ekaterinburg: UrO RAN (Ural Division, Russ. Acad. Sci.), 1997, p. 129.
Bulanov, N.V., Skripov, V.P., and Shuravenko, N.A., Inzh. Fiz. Zh., 1982, vol. 42, no. 2, p. 235.
Author information
Authors and Affiliations
Additional information
__________
Translated from Teplofizika Vysokikh Temperatur, Vol. 44, No. 2, 2006, pp. 268–284.
Original Russian Text Copyright © 2006 by N. V. Bulanov, B. M. Gasanov, and E. A. Turchaninova.
Rights and permissions
About this article
Cite this article
Bulanov, N.V., Gasanov, B.M. & Turchaninova, E.A. Results of experimental investigation of heat transfer with emulsions with low-boiling disperse phase. High Temp 44, 267–282 (2006). https://doi.org/10.1007/s10740-006-0033-z
Received:
Issue Date:
DOI: https://doi.org/10.1007/s10740-006-0033-z