Abstract
The municipal solid waste incineration bottom ash (IBA) is increasingly used as a secondary resource for civil engineering and various other applications. IBA contains various metals. The presence of these metals may limit the use of IBA as a secondary resource. This can be overcome by removing metals from IBA. This study focused on determination of metal contents of IBA and leaching of these metals. The results show that calcium (Ca), iron (Fe), aluminum (Al), silicon (Si), and sodium (Na) are the major metals present in IBA. Many other metals ranging from magnesium (Mg) to mercury (Hg) were also present in varying quantities. In the present study, four organic acids, namely, citric, malic, oxalic, and gluconic acids have been used to compare the metal leaching from IBA. The citric acid was found to be the most effective leaching agent. Various process parameters for metal leaching were optimized. It was found that the maximum metal leaching was achieved in 48 h. The 1 M citric acid, 100 mL working volume, 150 rpm, and 30 °C were the optimal conditions to leach 100 wt% Si, Na, Au, Sb, respectively. Around 99 wt% Mg, 95 wt% K, 93 wt% Cd, 88 wt% Al, 84 wt% Ca, 80 wt% Fe, 79 wt% Sr, 77 wt% Pb, Zn, As respectively, 67 wt% Cu, V, Ag respectively, 66 wt% Mn, 64 wt% Co, 56 wt% Cr, 43 wt% Ni, Sn respectively, 40 wt% Se, 21 wt% Ba, 10 wt% Hg were leached using citric acid at optimal conditions. The leaching efficiency decreased with increasing pulp density. An optimal pulp density for metal leaching was observed at 1% (w/v). The method described in the present study provides an alternative environmentally friendly process to remove metals from IBA. This will facilitate the recycling of metal-free IBA for geotechnical applications.
Similar content being viewed by others
References
Yang E, Liu Y, Chen Z (2015) Environmental Sustainability through recycling incineration bottom ash for the production of autoclaved aerated concrete. Key Eng Mater 650:51–70
Xu T, Ting Y (2004) Optimisation on bioleaching of incinerator fly ash by Aspergillus niger-use of central composite design. Enzym Microb Technol 35:444–454
Hong K, Tokunaga S, Ishigami Y, Kajuichi T (2000) Extraction of heavy metals from MSW incinerator fly ash using saponins. Chemosphere 41:345–352
Song Y, Li B, Yang E, Liu Y, Tian D (2015) Feasibility study on utilization of municipal solid waste incineration bottom ash as aerating agent for the production of autoclaved aerated concrete. Cement Concr Compos 56:51–58
Song Y, Li B, Yang E, Liu Y, Chen Z (2016) Gas generation from incinerator bottom ash: potential aerating agent for lightweight concrete production. J Mater Civ Eng 28(7):04016030
Zhang H, He P, Shao L, Li X (2008) Leaching behaviour of heavy metals from municipal solid waste incineration bottom ash and its geochemical modelling. Mater Cycles Waste Manag 10:7–13
Ferreira C, Ribeiro A, Ottosen L (2003) Possible applications for municipal solid waste fly ash. J Hazard Mater 96:201–216
Muchova L, Rem P (2007) Wet or dry separation; management of bottom ash in Europe. Waste Manag World 11:46–49
Chimenos J, Segarra M, Fernandez M, Espiell F (1999) Characterization of the bottom ash in municipal solid waste incinerator. J Hazard Mater 64:211–222
Santos R, Mertens G, Salman M, Cizer O, Gerven T (2013) Comparative study of ageing, heat treatment and accelerated carbonation for stabilization of municipal solid waste incineration bottom ash in view of reducing regulated heavy metal/metalloid leaching. J Environ Manag 128:807–821
Sloot V, Kosson H, Hjelmar D (2001) Characteristics, treatment and utilization of residues from municipal waste incineration. Waste Manag 21:753–765
Sabbas T, Polettini A, Pomi R, Astrup T, Hjelmar O, Mostbauer P et al (2003) Management of municipal solid waste residues. Waste Manag 23:61–88
Schneider J, Vehlow J, Vogg H (1994) Improving the MSWI bottom ash quality by simple in-plant measures. In: Goumans JJJM, van der Sloot HA, Aalbers ThG (eds) Environmental aspects of construction with waste materials, studies in environmental sciences 60. Elsevier, Amsterdam, pp 605–620
Gerven T, Keer E, Arickx S, Jaspers M, Wauters G, Vandecasteele C (2005) Carbonation of MSWI-bottom ash to decrease heavy metal leaching, in view of recycling. Waste Manag 25:291–300
Arickx S, Gerven T, Vandecasteele C (2006) Accelerated carbonation for treatment of MSWI bottom ash. J Hazard Mater 137:235–243
Gerven T, Cooreman H, Imbrechts K, Hindrix K, Vandecasteele C (2007) Extraction of heavy metals from municipal solid waste incinerator (MSWI) bottom ash with organic solutions. J Hazard Mater 140:376–381
Quek A, Xu W, Guo L, Wu D (2016) Heavy metal removal from incineration bottom ash through washing with rainwater and seawater. Int J Waste Resour 6:1–9
Agcasulu I, Akcil A (2017) Metal recovery from bottom ash of an incineration plant: laboratory reactor tests. Miner Process Extr Metall Rev 38:199–206
Arickx S, Gerven T, Knaepkens T et al (2007) Influence of treatment techniques on Cu leaching and different organic fractions in MSWI bottom ash leachate. Waste Manag 27:1422–1427
Hong K, Tokunaga S, Kajiuchi T (2000) Extraction of heavy metals from MSW incinerator fly ashes by chelating agents. J Hazard Mater 75:57–73
Bosshard P, Bachofen R, Brandl H (1996) Metal leaching of fly ash from municipal waste incineration by Aspergillus niger. Environ Sci Technol 30:3066–3070
Ishigaki T, Nakanishi A, Tateda M, Ike M, Fujita M (2005) Bioleaching of metal from municipal waste incineration fly ash using a mixed culture of sulfur-oxidizing and iron-oxidizing bacteria. Chemosphere 60:1087–1094
Wu H, Ting Y (2006) Metal extraction from municipal solid waste (MSW) incinerator fly ash-Chemical leaching and fungal bioleaching. Enzym Microb Technol 38:839–847
Wang Q, Yang J, Wang Q, Wu T (2009) Effects of water-washing pretreatment on bioleaching of heavy metals from municipal solid waste incinerator fly ash. J Hazard Mater 162:812–818
Ure A (1995) Heavy metals in soils. Blackie Academic and Professional, London, pp 58–102
Jadhav U, Hocheng H (2015) Analysis of metal bioleaching from thermal power plant fly ash by Aspergillus niger 34770 culture supernatant and reduction of phytotoxicity during the process. Appl Biochem Biotechnol 175:870–881
Gau S, Jeng W (1998) Influence of ligands on metals leachability from landfilling bottom ashes. J Hazard Mater 58:59–71
Muchova L, Bakker E, Rem P (2009) Precious metals in municipal solid waste incineration bottom ash. Water Air Soil Pollut 9:107–116
Brombacher C, Bachofen R, Brandl H (1998) Development of a laboratory-scale leaching plant for metal extraction from fly ash by Thiobacillus strains. Appl Environ Microbiol 64:1237–1241
Jung C, Matsuto T, Tanaka N et al (2004) Metal distribution in incineration residues of municipal solid waste (MSW) in Japan. Waste Manag 24:381–391
Bruder-Hubscher V, Lagarde F, Leroy M et al (2002) Application of a sequential extraction procedure to study the release of elements from municipal solid waste incineration bottom ash. Anal Chim Acta 451:285–295
Feng S, Wang X, Wei G, Peng P, Yang Y, Cao Z (2007) Leachates of municipal solid waste incineration bottom ash from Macao: heavy metal concentrations and genotoxicity. Chemosphere 67:1133–1137
Huang K, Inoue K, Harada H, Kawakita H, Ohto K (2011) Leaching of heavy metals by citric acid from fly ash generated in municipal waste incineration plants. J Mater Cycles Waste Manag 13:118–126
Goyne W, Brantley L, Chorover J (2010) Rare earth element release from phosphate minerals in the presence of organic acids. Chem Geol 278:1–14
Saidan M, Brown B, Valix M (2012) Leaching of electronic waste using biometabolised acids. Chin J Chem Eng 20:530–534
Steer J, Griffiths A (2013) Investigation of carboxylic acids and non-aqueous solvents for the selective leaching of zinc from blast furnace dust slurry. Hydrometallurgy 140:34–41
Li P, Zeng G, Xu W, Zhang C, Jiang M (2010) Effects of organic acids on zinc and lead leaching from contaminated sediments. China Environ Sci 30:1235–1240
Saito C, Okada H, Titus M, Yoshioka T, Mizoguchi T (2007) Leaching of heavy metals from fly ash generated from gasification and melting furnace for municipal solid wastes by organic acids. Jpn Soc Waste Manag Expert 18:157–166
Li L, Ge J, Wu F, Chen R, Chen S, Wu B (2010) Recovery of cobalt and lithium from spent lithium ion batteries using organic citric acid as leachant. J Hazard Mater 176:288–293
Acknowledgements
The authors would like to acknowledge the financial support from the Environment Technology Research Program (ETRP), the National Environment Agency, Singapore (ETRP Nos. 1301 104).
Author information
Authors and Affiliations
Corresponding author
Additional information
The contributing editor for this article was D. Panias.
Rights and permissions
About this article
Cite this article
Jadhav, U.U., Biswal, B.K., Chen, Z. et al. Leaching of Metals from Incineration Bottom Ash Using Organic Acid. J. Sustain. Metall. 4, 115–125 (2018). https://doi.org/10.1007/s40831-018-0161-9
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40831-018-0161-9