Skip to main content
SpringerLink
Log in

An experimental investigation of bacteria-producing calcareous cement in wind erosion prevention

  • Original Paper
  • Published:
International Journal of Environmental Science and Technology Aims and scope Submit manuscript

Abstract

Soil stabilization is essential in different fields, such as the environment, to prevent wind erosion and dust. Microbial-induced carbonate precipitation (MICP) is a soil healing method in which bacteria with CaCO3 precipitation among soil particles increase the soil erosion resistance against wind erosion. In this study, by culturing a bacterium species with the scientific name of “Sporosarcina pasteurii” in the laboratory and preparing the solution with three levels of urea and calcium chloride (concentrations of 0.1, 0.2, and 0.4 M) as a nutrient, the status of CaCO3 precipitation was investigated. The erosion of the cemented samples was simulated at a speed of 10–20 km h−1 at the height of 10 cm from the tunnel bottom using a wind tunnel apparatus. The results showed that the highest CaCO3 precipitation occurred in treatments of 0.1 M calcium chloride with 0.2 M and 0.4 M urea. At both wind speeds, MICP treatments significantly reduced soil erosion as compared with the control samples. The FTIR test confirmed the CaCO3 precipitations. Further, the study of CaCO3 precipitation using XRD and SEM analysis showed that it is more in the form of vitriol crystals, binding together loose soil particles and increasing their resistance to the shear stress of wind.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  • Achal V, Mukherjee A, Reddy M (2011) Effect of calcifying bacteria on permeation properties of concrete structures. J Ind Microbiol Biotechnol 38(9):1229–1234

    CAS  Google Scholar 

  • Achal V, Pan X, Fu Q, Zhang D (2012) Biomineralization based remediation of As(III) contaminated soil by Sporosarcina ginsengisoli. J Hazard Mater 201–202:178–184

    Google Scholar 

  • Ahani E, Narouei H, Ahmadpour M (2019) Assessment of the economic, social and environmental impacts of aerosols and their damages (Zabul City Case Study). In: International dust conference on Southwest Asia, 23–25 April 2019. University of Zabol, Zabol, Iran (in Persian)

  • Ahmadi H, Khorasani NA, Karami M, Azarkar SM (2004) Estimation of wind erosion in Khorasan habitats (case study: Sarakhs area). J Environ Sci Technol 5(4):19–28

    Google Scholar 

  • Al-Thawadi Salwa M (2008) High strength in-situ biocementation of soil by calcite precipitating locally isolated ureolytic bacteria, Ph.D. School of Biological Sciences and Biotechnology, Murdoch University

  • Alipour H, Jalalian A, Honarjoo N, Sarmadian F (2019) Spatial and temporal distribution of dust‐bound trace metal elements around Kuhdasht watershed area in Iran. Clean Soil Air Water 19(10). https://doi.org/10.1002/clen.201900318

  • Anbu P, Kang CH, Shin YJ, So JS (2016) Formations of CaCO3 minerals by bacteria and its multiple applications. Springerplus 5:250–262

    Google Scholar 

  • Arias D, Cisternas LA, Rivas M (2017) Biomineralization of calcium and magnesium crystals from seawater by halotolerant bacteria isolated from Atacama Salar (Chile). Desalination 405:1–9

    CAS  Google Scholar 

  • Ayaran A, Kamali M (2018) Investigating the role of the environment in sustainable security development (focusing on the crisis of aerosol in Khuzestan Province). In: Fourth international conference on sustainable development focused on environmental engineering, 17–9 December 2018. Center for Sustainable Development Solutions—Mehr Arvand Higher Education Institute, Tehran, Iran (in Persian)

  • Azoogh L, Khalili B, Moghadam Jafari S (2018) Interaction of petroleum mulching, vegetation restoration and dust fallout on the conditions of sand dunes in southwest of Iran. Aeolian Res 32:124–132

    Google Scholar 

  • Barzegar Bafravi R, Dolatabadi M, Esfandiarpour N (2019) A review of factors affecting aerosol generation in Iran. In: First national aerosol conference on health-oriented approach, 4–7 February 2019. Zabol University of Medical Sciences and Health Services (in Persian)

  • Chahar Azar F, Chahar Azar Y, Javad Amiri M (2019) The role of aerosol on human health and the environment. In: International dust conference on Southwest Asia, 23–25 April 2019. University of Zabol, Zabol, Iran. (in Persian)

  • Chen X, Achal V (2019) Biostimulation of carbonate precipitation process in soil for copper immobilization. J Hazard Mater 368:705–713

    CAS  Google Scholar 

  • Chen Y, Cheng JJ, Creamer KS (2008) Inhibition of anaerobic digestion process: a review. Bioresour Technol 99(10):4044–4064

    CAS  Google Scholar 

  • Chen H, Zhang X, Abla M, Lü D, Yan R, Ren Q, Ren Z, Yang Y, Zhao W, Lin P, Liu B, Yang X (2018) Effects of vegetation and rainfall types on surface runoff and soil erosion on steep slopes on the Loess Plateau, China. CATENA 170:141–149

    Google Scholar 

  • Chen J, Xiao H, Li Z, Liu C, Wang D, Wang L, Tang C (2019) Threshold effects of vegetation coverage on soil erosion control in small watersheds of the red soil hilly region in China. Ecol Eng 132:109–114

    Google Scholar 

  • Cuzman OA, Richter K, Wittig L, Tiano P (2015) Alternative nutrient sources for biotechnological use of Sporosarcina pasteurii. World J Microbiol Biotechnol 31(6):897–906

    CAS  Google Scholar 

  • Dejong JT, Fritzges MB, Nusslein K (2006) Microbially induced cementation to control sand response to undrained shear. J Geotech Geoenviron Eng 132:1381–1392

    CAS  Google Scholar 

  • DeJong JT, Mortensen BM, Martinez BC, Nelson DC (2010) Bio-mediated soil improvement. Ecol Eng 36(2):197–210

    Google Scholar 

  • Dhami NK, Alsubhi WR, Watkin E, Mukherjee A (2017) Bacterial community dynamics and biocement formation during stimulation and augmentation: implications for soil consolidation. Front Microbiol 8:1267. https://doi.org/10.3389/fmicb.2017.01267

    Article  Google Scholar 

  • Eryürük K, Yang S, Suzuki D, Sakaguchi I, Akatsuka T, Tsuchiya T, Katayama A (2015) Reducing hydraulic conductivity of porous media using CaCO3 precipitation induced by Sporosarcina pasteurii. J Biosci Bioeng 119(3):331–336

    Google Scholar 

  • Grabiec AM, Starzyk J, Stefaniak K, Wierzbicki J, Zawal D (2017) On possibility of improvement of compacted silty soils using bioprecipitation method. Constr Build Mater 138:134–140

    CAS  Google Scholar 

  • Ha Nguyen T, Ghorbel E, Fares H, Cousture A (2019) Bacterial self-healing of concrete and durability assessment. Cem Concr Compos 104:103340. https://doi.org/10.1016/j.cemconcomp.2019.103340

    Article  CAS  Google Scholar 

  • Hammes F, Verstraete W (2002) Key roles of pH and calcium metabolism in microbial carbonate precipitation. Rev Environ Sci Biotechnol 1:3–7

    CAS  Google Scholar 

  • Hammes F, Seka A, Knijf SD, Verstraete W (2003) A novel approach to calcium removal from calcium-rich industrial wastewater. Water Res 37(3):699–704

    CAS  Google Scholar 

  • Henze J, Randall DG (2019) Microbial induced CaCO3 precipitation at elevated pH values (>11) using Sporosarcina pasteurii. J Environ Chem Eng 6(4):5008–5013

    Google Scholar 

  • Jiang NJ, Soga K (2019) Erosional behavior of gravel-sand mixtures stabilized by microbially induced calcite precipitation (MICP). Soils Found 59(3):699–709

    Google Scholar 

  • Jiang N, Hideyosh Y, Koj Y, Soga K (2016) Ureolytic activities of a urease-producing bacterium and purified urease enzyme in the anoxic condition: implication for subseafloor sand production control by microbially induced carbonate precipitation (MICP). Ecol Eng 90:96–104

    CAS  Google Scholar 

  • Jiang N, Rui Liu J, Yan Jun D, Yu Zhang B (2019) Microbial induced carbonate precipitation for immobilizing Pb contaminants: toxic effects on bacterial activity and immobilization efficiency. Sci Total Environ 672:722–731

    CAS  Google Scholar 

  • Jongvivatsakul P, Janprasit K, Nuaklong P, Pungrasmi W, Likitlersuang S (2019) Investigation of the crack healing performance in mortar using microbially induced CaCO3 precipitation (MICP) method. Constr Build Mater 212:737–744

    CAS  Google Scholar 

  • Kader MA, Senge M, Mojid MA, Ito K (2017) Recent advances in mulching materials and methods for modifying soil environment. Soil Till Res 168:155–166

    Google Scholar 

  • Katebi H, Fahmi A, Samadi Kafil H, Hajialilue Bonab M (2018) Stabilization of calcareous sand dunes using phosphoric acid mulching liquid. J Arid Environ 148:34–44

    Google Scholar 

  • Li D, Tian K, Zhang H, Wub Y, Nie K, Zhang S (2018) Experimental investigation of solidifying desert aeolian sand using microbially induced calcite precipitation. Constr Build Mater 172:251–262

    Google Scholar 

  • Liu J, Chen Z, Kanungo DK, Song Z, Bai Y, Wang Y, Li D, Qian W (2019) Topsoil reinforcement of sandy slope for preventing erosion using water-based polyurethane soil stabilizer. Eng Geol 252:125–135

    Google Scholar 

  • Molares L, Garzon E, Romero E, Sanchez-soto PJ (2019) Microbiological induced carbonate (CaCO3) precipitation using clay phyllites to replace chemical stabilizers (cement or lime). Appl Clay Sci 174:15–28

    Google Scholar 

  • Montoya BM (2012) Bio-mediated soil improvement and the effect of cementation on the behavior, improvement, and performance of sand. University of California, Davis

    Google Scholar 

  • Moradi G, Aprajunqani A (2019) Investigating the origin of aerosol and their impacts on air pollution. In: International dust conference on Southwest Asia, 23–25 April 2019. University of Zabol, Zabol (in Persian)

  • Musa Zadeh Moghadampour R, Tabandeh F, Kalantari F (2016) Investigation of factors affecting soil microbial improvement based on determination of unfinished soil compressive resistance. In: Third national conference on environment and natural resources, Shiraz (in Persian)

  • Omoregie AI, Khoshdelnezamiha G, Senian N, Ong DE, Nissom P (2017) Experimental optimisation of various cultural conditions on urease activity for isolated Sporosarcina pasteurii strains and evaluation of their biocement potentials. Ecol Eng 109:65–75

    Google Scholar 

  • Omoregie A, Lock Hei Ngu I, Dominic Ek Leong O, Peter Morin N (2019) Low-cost cultivation of Sporosarcina pasteurii strain in food-grade yeast extract medium for microbially induced carbonate precipitation (MICP) application. Biocatal Agric Biotechnol 17:247–255

    Google Scholar 

  • Qiu J, Qin Sheng Teng D, Yang E (2014) Surface treatment of recycled concrete aggregates through microbial carbonate precipitation. Constr Build Mater 57:144–150

    Google Scholar 

  • Rahim S, Zomorodian SMA, Niazi A, O’Kelly B (2015) Improving sand with microbialinduced carbonate precipitation. Proc Inst Civ Eng Ground Improv 168(3):217–230

    Google Scholar 

  • Robichaud PR, Jennewein J, Sharrat BS, Lewis SA, Brown RE (2017) Evaluating the effectiveness of agricultural mulches for reducing post-wildfire wind erosion. Aeolian Res 27:13–21

    Google Scholar 

  • Ruan S, Qiu J, Weng Y, Yang Y, Yang E, Chu J, Unluer C (2019) The use of microbial induced carbonate precipitation in healing cracks within reactive magnesia cement-based blends. Cem Concr Res 115:176–188

    CAS  Google Scholar 

  • Sarani A, Rahdari S (2019) Aerosol on agricultural performance and extension activities. In: International dust conference on Southwest Asia, 23–25 April 2019. University of Zabol, Zabol, Iran (in Persian)

  • Shahkoui A, Rahmani T (2018) Climatic survey of aerosol at Northwest of Iran. In: Second national meteorological conference of Iran, 9th May 2018. Ferdowsi University of Mashhad, Mashhad (in Persian)

  • Sharaky A, Mohamed N, Elmashad M, Shredah N (2018) Application of microbial biocementation to improve the physico-mechanical properties of sandy soil. Constr Build Mater 190:861–869

    CAS  Google Scholar 

  • Shokouhi Nia M, Rezaei Kikhaei Kh (2018) How aerosols occur in Iran, effects and management strategies to cope with it. In: First national conference of aerosol on health-oriented approach, Zabol, Zabol University of Medical Sciences and Health Services (in Persian)

  • Stabnikov V, Jian C, Ivanov V, Li YS (2013) Halotolerant, alkaliphilic ureaseproducing bacteria from different climate zones and their application for biocementation of sand. World J Microb Biotechnol 29(8):1453–1460

    CAS  Google Scholar 

  • Tayebani B, Mostofinejad D (2019) Self-healing bacterial mortar with improved chloride permeability and electrical resistance. Constr Build Mater 208:75–86

    CAS  Google Scholar 

  • Tobler DJ, Cuthbert MO, Greswell RB, Riley MS, Renshaw JC, Handley-Sidhu S, Phoenix VR (2011) Comparison of rates of ureolysis between Sporosarcina pasteurii and an indigenous groundwater community under conditions required to precipitate large volumes of calcite. Geochim Cosmochim Acta 75(11):3290–3301

    CAS  Google Scholar 

  • Warren LA, Maurice PA, Parmar N, Grant Ferris F (2010) Microbiolly mediated CaCO3 precipitation: implications for interpreting calcite precipitation and for solid-phase capture of inorganic contaminants. Geomicrobiol J 18(1):93–115

    Google Scholar 

  • Wasim Kh, Basit EM (2016) Crack healing in concrete using various bio influenced self-healing techniques. Constr Build Mater 102(1):349–357

    Google Scholar 

  • Whiffin VS, van Paassen LA, Harkes MP (2007) Microbial carbonate precipitation as a soil improvement technique. Geomicrobiol J 24(5):417–423

    CAS  Google Scholar 

  • Whitman WB, Coleman DC, Wiebe W (1998) Prokaryotes: the unseen majority. Proc Natl Acad Sci (PNAS) 95(12):6578–6583

    CAS  Google Scholar 

  • Wieder WL, Shoop SA (2018) State of the knowledge of vegetation impact on soil strength and trafficability. J Terramech 78:1–14

    Google Scholar 

  • Wu M, Hu X, Zhang Q, Xue D, Zhao Y (2019) Growth environment optimization for inducing bacterial mineralization and its application in concrete healing. Constr Build Mater 209:631–643

    CAS  Google Scholar 

  • Zhang C, Zhou A, Zhang H, Zhang Q, Zhang X, Sun H, Zhao C (2019a) Soil erosion in relation to climate change and vegetation cover over the past 2000 years as inferred from the Tianchi Lake in the Chinese Loess Plateau. J Asian Earth Sci 180:103850. https://doi.org/10.1016/j.jseaes.2019.04.019

    Article  Google Scholar 

  • Zhang J, Kumari D, Fang C, Achal V (2019b) Combining the microbial calcite precipitation process with biochar in order to improve nickel remediation. Appl Geochem 103:68–71

    CAS  Google Scholar 

  • Zomorodian SMA, Ghaffari H, O’Kelly BC (2019) Stabilisation of crustal sand layer using biocementation technique for wind erosion control. Aeolian Res 40:34–41

    Google Scholar 

Download references

Acknowledgements

The data were supported by Razi experimental complex of Science and Research Branch, Islamic Azad University, that is gratefully acknowledged.

Author information

Authors and Affiliations

  1. Department of Soil Science, Science and Research Branch, Islamic Azad University, Tehran, Iran

    Sh. S. Nasir & A. Mohammadi Torkashvand

  2. Department of Soil Science, Savadkooh Branch, Islamic Azad University, Savadkooh, Iran

    N. Khakipour

Authors
  1. Sh. S. Nasir
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. A. Mohammadi Torkashvand
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. N. Khakipour
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to A. Mohammadi Torkashvand.

Additional information

Editorial responsibility: Samareh Mirkia.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Nasir, S.S., Mohammadi Torkashvand, A. & Khakipour, N. An experimental investigation of bacteria-producing calcareous cement in wind erosion prevention. Int. J. Environ. Sci. Technol. 19, 2107–2118 (2022). https://doi.org/10.1007/s13762-021-03207-3

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13762-021-03207-3

Keywords

Search

Navigation