Skip to main content

Advertisement

SpringerLink
Log in

Study on the co-pyrolysis characteristics of sewage sludge and wood powder and kinetic analysis

  • Original Article
  • Published:
Biomass Conversion and Biorefinery Aims and scope Submit manuscript

Abstract

How to treat and recycle sewage sludge quickly and harmlessly has been widely concerned. In this study, the pyrolysis of sewage sludge, wood powder, and their mixtures in different proportions was carried out in the TGA and fixed-bed reactor. Co-pyrolysis products including char, pyrolytic liquid, and gas composition were evaluated based on different mixtures of sewage sludge and wood powder. The results show that there is a significantly synergistic effect between sewage sludge and wood powder during the co-pyrolysis process, and the strongest synergetic effect of sewage sludge and wood powder appears at the biomass proportion of 60 wt.%. The synergetic effect resulted in an increase in gas yield but a decrease in char yield, which improves the utilization of sludge and the characteristics of pyrolysis products. The gas composition and synergetic effect degree are strongly affected by the wood powder percentages. In addition, the Coats-Redfern integral method was used to calculate the pre-exponential factor and activation energy of sewage sludge, wood powder, and blends. The results show that when the reaction order is 1.5, equation describes the co-pyrolysis process well, so the kinetic mechanism function of co-pyrolysis is F(α) = (1-α)1.5. In a nutshell, the amount of wood powder has a great influence on co-pyrolysis characteristics and the degree of synergistic effect.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10

Similar content being viewed by others

Data availability

The data that support the finding of this study are available from the corresponding author upon reasonable request.

References

  1. Liu Y et al (2020) Characterization and analysis of sludge char prepared from bench-scale fluidized bed pyrolysis of sewage sludge. Energy 200:117398

    Article  Google Scholar 

  2. Smith KM et al (2009) Sewage sludge-based adsorbents: a review of their production, properties and use in water treatment applications. Water Res 43(10):2569–2594

    Article  MATH  Google Scholar 

  3. Li H et al (2015) Effect of bioleaching on hydrogen-rich gas production by steam gasification of sewage sludge. Energy Convers Manag 106(DEC):1212–1218

    Article  MATH  Google Scholar 

  4. Kan T, Strezov V, Evans T (2016) Effect of the heating rate on the thermochemical behavior and biofuel properties of sewage sludge pyrolysis. Energy Fuels 30(3):1564–1570

    Article  Google Scholar 

  5. Zaker A, Chen Z, Zaheer-Uddin M (2021) Catalytic pyrolysis of sewage sludge with HZSM5 and sludge-derived activated char: a comparative study using TGA-MS and artificial neural networks. J Environ Chem Eng 9(5):105891

    Article  Google Scholar 

  6. Shen L, DK Zhang (2003) An experimental study of oil recovery from sewage sludge by low-temperature pyrolysis in a fluidised-bed. Fuel 82(4):465–472

  7. M, et al. (2002) On the pyrolysis of sewage sludge: the influence of pyrolysis conditions on solid, liquid and gas fractions. J Anal Appl Pyrol 63(1):209–222

  8. Shao J et al (2008) Pyrolysis characteristics and kinetics of sewage sludge by thermogravimetry fourier transform infrared analysis. Energy Fuels 22(1):38–45

    Article  MATH  Google Scholar 

  9. Fonts I et al (2012) Sewage sludge pyrolysis for liquid production: a review. Renew Sustain Energy Rev 16(5):2781–2805

    Article  MATH  Google Scholar 

  10. Manara P, Zabaniotou A (2012) Towards sewage sludge based biofuels via thermochemical conversion – a review. Renew Sustain Energy Rev 16(5):2566–2582

    Article  MATH  Google Scholar 

  11. Ding HS, Jiang H (2013) Self-heating co-pyrolysis of excessive activated sludge with waste biomass: energy balance and sludge reduction. Biores Technol 133:16–22

    Article  MATH  Google Scholar 

  12. Wang S et al (2021) Synergistic effects in the copyrolysis of municipal sewage sludge digestate and salix: reaction mechanism, product characterization and char stability. Appl Energy 289:116687

    Article  Google Scholar 

  13. Alvarez J et al (2015) Fast co-pyrolysis of sewage sludge and lignocellulosic biomass in a conical spouted bed reactor. Fuel 159(nov.1):810–818

    Article  MathSciNet  MATH  Google Scholar 

  14. Jin J et al (2017) Cumulative effects of bamboo sawdust addition on pyrolysis of sewage sludge: Biochar properties and environmental risk from metals. Biores Technol 228:218–226

    Article  Google Scholar 

  15. Yang et al (2017) Co-pyrolysis of sewage sludge and sawdust/rice straw for the production of biochar. J Anal Appl Pyrol 125:61–68

  16. Zhang, et al (2015) Beneficial synergetic effect on gas production during co-pyrolysis of sewage sludge and biomass in a vacuum reactor. Bioresource Technology: Biomass, Bioenergy, Biowastes, Conversion Technologies, Biotransformations, Production Technologies 183:255–258

  17. Zhu X et al (2015) Co-pyrolysis behaviors and kinetics of sewage sludge and pine sawdust blends under non-isothermal conditions. J Therm Anal Calorim 119:2269–2279

  18. Salleh F, Samsuddin R, Husin M (2011) Bio-fuel source from combination feed of sewage sludge and rice waste. International Conference on Environment Science and Engineering IPCBEE, vol 8

  19. Ath A, et al (2021) Progress on the lignocellulosic biomass pyrolysis for biofuel production toward environmental sustainability. Fuel Process Technol 223:106997

  20. Itoh T et al (2020) Effects of pyrolysis temperature and feedstock type on particulate matter emission characteristics during biochar combustion. Fuel Process Technol 204:106408

    Article  MATH  Google Scholar 

  21. Samanya J et al (2012) Characteristics of the upper phase of bio-oil obtained from co-pyrolysis of sewage sludge with wood, rapeseed and straw. J Anal Appl Pyrol 94:120–125

    Article  Google Scholar 

  22. Chen Q et al (2019) Structure characteristics of bio-char generated from co-pyrolysis of wooden waste and wet municipal sewage sludge. Fuel Process Technol 183:48–54

    Article  MATH  Google Scholar 

  23. Wang et al (2019) Co-pyrolysis characteristics of sludge and sawdust. Renewable Energy 37(01):26–33

    MATH  Google Scholar 

  24. Sakulkit P et al (2020) Characteristics of pyrolysis products from pyrolysis and co-pyrolysis of rubber wood and oil palm trunk biomass for biofuel and value-added applications. J Environ Chem Eng 8(6):104561

    Article  MATH  Google Scholar 

  25. Wang C et al (2020) Co-pyrolysis of sewage sludge and rice husk by TG–FTIR–MS: pyrolysis behavior, kinetics, and condensable/non-condensable gases characteristics. Renew Energy 160:1048–1066

    Article  MATH  Google Scholar 

  26. Wang C, et al (2020) Co-pyrolysis of sewage sludge and rice husk by TG–FTIR–MS: pyrolysis behavior, kinetics, and condensable/non-condensable gases characteristics. Renew Energy 160:1048–1066

  27. Az A, et al (2020) Co-pyrolysis of sewage sludge and low-density polyethylene – a thermogravimetric study of thermo-kinetics and thermodynamic parameters - ScienceDirect. J Environ Chem Eng 9(1)

  28. Raveendran K, Ganesh A, Khilart KC (1995) Influence of mineral matter pyrolysis characteristics on biomass 74(12):1812–1822

  29. Idris SS et al (2010) Investigation on thermochemical behaviour of low rank Malaysian coal, oil palm biomass and their blends during pyrolysis via thermogravimetric analysis (TGA). Biores Technol 101(12):4584–4592

    Article  MATH  Google Scholar 

  30. Zhang et al (2018) Co-pyrolysis of municipal Solid waste and pine sawdust. Environ Eng 36(4):137–141

  31. Li et al (2016) Influence factors of dehydrated sludge/Poplar sawdust co-gasification. Nat Gas Chem Ind 41(006):25–30

    MATH  Google Scholar 

  32. Li S et al (2015) Co-pyrolysis characteristic of biomass and bituminous coal. Bioresour Technol 179:414–420

  33. Wang et al (2016) Synergetic effect of sewage sludge and biomass co-pyrolysis: a combined study in thermogravimetric analyzer and a fixed bed reactor. Energy Convers Manag 118:399–405

  34. Jiawei Guo, Study on pyrolysis characteristics of bio-activated sludge, 2019, Southeast University

  35. Lin B, Huang Q, Chi Y (2018) Co-pyrolysis of oily sludge and rice husk for improving pyrolysis oil quality. Fuel Process Technol 177:275–282

    Article  Google Scholar 

  36. Zaker A, Chen Z (2021) Catalytic pyrolysis of sewage sludge for upgrading bio-oil quality using sludge-based activated char as an alternative to HZSM5. J Environ Eng Ecol Sci 15(8):194–204

    MATH  Google Scholar 

  37. Alvarez J et al (2016) Characterization of the bio-oil obtained by fast pyrolysis of sewage sludge in a conical spouted bed reactor. Fuel Process Technol 149:169–175

    Article  MATH  Google Scholar 

  38. Mes A et al (2009) Effect of pyrolysis temperature on the composition of the oils obtained from sewage sludge - ScienceDirect. Biomass Bioenergy 33(6–7):933–940

    MATH  Google Scholar 

  39. Chen et al (2021) Characteristics of co-pyrolysis oil of municipal sludge and typical forest biomass. Chinese J Solar Energy 42(07):456–462

  40. De Parnau AuV, Dignac MF (2007) The organic matter composition of various wastewater sludges and their neutral detergent fractions as revealed by pyrolysis-GC/MS. J Anal Appl Pyrol 78(1):140–152

    Article  Google Scholar 

  41. Pan X et al (2021) Comparative study on the effect of different dewatering skeleton conditioners on sludge pyrolysis products. J Environ Chem Eng 9(6):106527

    Article  MathSciNet  MATH  Google Scholar 

  42. Li et al (2021) Co-pyrolysis of rice straw and sludge. J Nanjing Agric Univ 44(04):789–796

  43. Tian B et al (2021) A comprehensive evaluation on pyrolysis behavior, kinetics, and primary volatile formation pathways of rice husk for application to catalytic valorization. Fuel Process Technol 214:106715

    Article  Google Scholar 

  44. Shen X et al (2006) Optimization and comparison of kinetic models for pyrolysis of main refuse components.Journal of chemical industry 10:2433–2438

  45. Zhu J et al (2018) Co-pyrolysis of textile dyeing sludge and four typical lignocellulosic biomasses: thermal conversion characteristics, synergetic effects and reaction kinetics. Int J Hydrogen Energy 43(49):22135–22147

    Article  Google Scholar 

  46. He F, Yi W, Zha J (2009) Measurement of the heat of smoldering combustion in straws and stalks by means of simultaneous thermal analysis. Biomass Bioenerg 33(1):130–136

    Article  MATH  Google Scholar 

  47. Wang X et al (2016) Synergetic effect of sewage sludge and biomass co-pyrolysis: a combined study in thermogravimetric analyzer and a fixed bed reactor. Energy Convers Manage 118:399–405

    Article  MATH  Google Scholar 

Download references

Funding

The project was supported by the National Natural Science Foundation of China (51676081), Wuhan Enterprise Technology Innovation Projects (2019020702011359; 2020020602012150), and the 111 Project B17019.

Author information

Authors and Affiliations

  1. Chemistry College, Central China Normal University, Wuhan, 430079, China

    Jun Zhang, Rui Zhao, Yuying Du, Liang Chen, Zizhao Chen, Na Xiao & Zhengshun Wu

Authors
  1. Jun Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Rui Zhao
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Yuying Du
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Liang Chen
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Zizhao Chen
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Na Xiao
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Zhengshun Wu
    View author publications

    You can also search for this author in PubMed Google Scholar

Contributions

The corresponding author is responsible for ensuring that the descriptions are accurate and agreed by all authors; the role(s) of all authors are as follows:

Jun Zhang—conceptualization, methodology, data curation, writing (original draft preparation). Rui Zhao and Yuying Du—writing (reviewing and editing). Liang Chen—visualization, investigation. Zizhao Chen—project administration. Na Xiao—resources. Zhengshun Wu—supervision and formal analysis.

Corresponding author

Correspondence to Zhengshun Wu.

Ethics declarations

Conflict of interest

The authors declare no competing interests.

Additional information

Publisher's note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zhang, J., Zhao, R., Du, Y. et al. Study on the co-pyrolysis characteristics of sewage sludge and wood powder and kinetic analysis. Biomass Conv. Bioref. 14, 1593–1605 (2024). https://doi.org/10.1007/s13399-022-02589-9

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13399-022-02589-9

Keywords

Search

Navigation