Abstract
It is necessary to control the emissions of toluene, which is hazardous to both human health and the atmosphere environment and has been classified as a priority pollutant. Manganese oxide-based (Mn-based) catalysts have received increased attention due to their high catalytic performance, good physicochemical characteristic, availability in various crystal structures and morphologies, and being environmentally friendly and low cost. These catalysts can be classified into five categories, namely single manganese oxide, Mn-based composite oxides, Mn-based special oxides, supported Mn-based oxides, and Mn-based monoliths. This review focused on the recent progress on the five types of Mn-based catalysts for catalytic removal of toluene at low temperature and further systematically summarized the strategies improving catalysts, including improving synthetic methods, incorporating MnOx with other metal oxides, depositing Mn-based oxides on proper supports, and tuning the supports. Moreover, the effect of coexisting components, the reaction kinetics, and the oxidation mechanisms toward the removal of toluene were also discussed. Finally, the future research direction of this field was presented.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Aguero FN, Barbero BP, Almeida LC, Montes M, Cadús LE (2011) MnOx supported on metallic monoliths for the combustion of volatile organic compounds. Chem Eng J 166:218–223. https://doi.org/10.1016/j.cej.2010.10.064
Aguero FN, Barbero BP, Gambaro L, Cadús LE (2009a) Catalytic combustion of volatile organic compounds in binary mixtures over MnOx/Al2O3 catalyst. Appl Catal, B 91:108–112. https://doi.org/10.1016/j.apcatb.2009.05.012
Aguero FN, Barbero BP, Sanz O, Echave Lozano FJ, Montes M, Cadús LE (2010) Influence of the support on MnOx metallic monoliths for the combustion of volatile organic compounds. Ind Eng Chem Res 49:1663–1668. https://doi.org/10.1021/ie901567a
Aguero FN, Scian A, Barbero BP, Cadús LE (2009b) Influence of the support treatment on the behavior of MnOx/Al2O3 catalysts used in VOC combustion. Catal Lett 128:268–280. https://doi.org/10.1007/s10562-008-9695-y
Aguilera DA, Perez A, Molina R, Moreno S (2011) Cu–Mn and Co–Mn catalysts synthesized from hydrotalcites and their use in the oxidation of VOCs. Appl Catal, B 104:144–150. https://doi.org/10.1016/j.apcatb.2011.02.019
Ahmadi M, Haghighi M, Kahforoushan D (2017) Influence of active phase composition (Mn, Ni, MnxNi10−x) on catalytic properties and performance of clinoptilolite supported nanocatalysts synthesized using ultrasound energy toward abatement of toluene from polluted air. Process Saf Environ Protect 106:294–308. https://doi.org/10.1016/j.psep.2016.06.029
Ahn C-W, You Y-W, Heo I, Hong JS, Jeon J-K, Ko Y-D, Kim YH, Park H, Suh J-K (2017) Catalytic combustion of volatile organic compound over spherical-shaped copper–manganese oxide. J Ind Eng Chem 47:439–445. https://doi.org/10.1016/j.jiec.2016.12.018
Avila P, Montes M, Miró EE (2005) Monolithic reactors for environmental applications. Chem Eng J 109:11–36. https://doi.org/10.1016/j.cej.2005.02.025
Azimi Pirsaraei SR, Asilian Mahabadi H, Jonidi Jafari A (2016) Airborne toluene degradation by using manganese oxide supported on a modified natural diatomite. J Porous Mat 23:1015–1024. https://doi.org/10.1007/s10934-016-0159-2
Behar S, Gómez-Mendoza N-A, Gómez-García M-Á, Świerczyński D, Quignard F, Tanchoux N (2015) Study and modelling of kinetics of the oxidation of VOC catalyzed by nanosized Cu–Mn spinels prepared via an alginate route. Appl Catal A 504:203–210. https://doi.org/10.1016/j.apcata.2014.12.021
Behar S, Gonzalez P, Agulhon P, Quignard F, Świerczyński D (2012) New synthesis of nanosized Cu–Mn spinels as efficient oxidation catalysts. Catal Today 189:35–41. https://doi.org/10.1016/j.cattod.2012.04.004
Bonet F, Grugeon S, Herrera Urbina R, Tekaia-Elhsissen K, Tarascon JM (2002) In situ deposition of silver and palladium nanoparticles prepared by the polyol process, and their performance as catalytic converters of automobile exhaust gases. Solid State Sci 4:665–670. https://doi.org/10.1016/S1293-2558(02)01311-0
Castaño MH, Molina R, Moreno S (2013) Mn–Co–Al–Mg mixed oxides by auto-combustion method and their use as catalysts in the total oxidation of toluene. J Mol Catal A: Chem 370:167–174. https://doi.org/10.1016/j.molcata.2013.01.008
Castaño MH, Molina R, Moreno S (2015) Catalytic oxidation of VOCs on MnMgAlOx mixed oxides obtained by auto-combustion. J Mol Catal A: Chem 398:358–367. https://doi.org/10.1016/j.molcata.2015.01.001
Castaño MH, Molina R, Moreno S (2017) Effect of Mg and Al on manganese oxides as catalysts for VOC oxidation. Mol Catal 443:117–124. https://doi.org/10.1016/j.mcat.2017.09.015
Chen J, Chen X, Chen X, Xu W, Xu Z, Jia H, Chen J (2018) Homogeneous introduction of CeOy into MnOx-based catalyst for oxidation of aromatic VOCs. Appl Catal, B 224:825–835. https://doi.org/10.1016/j.apcatb.2017.11.036
Chen J, Chen X, Xu W, Xu Z, Chen J, Jia H, Chen J (2017) Hydrolysis driving redox reaction to synthesize Mn-Fe binary oxides as highly active catalysts for the removal of toluene. Chem Eng J 330:281–293. https://doi.org/10.1016/j.cej.2017.07.147
Ching S, Roark JL, Duan N, Suib SL (1997) Sol−gel route to the tunneled manganese oxide cryptomelane. Chem Mater 9:750–754. https://doi.org/10.1021/cm960460k
Chlala D, Giraudon JM, Nuns N, Lancelot C, Vannier R-N, Labaki M, Lamonier JF (2016) Active Mn species well dispersed on Ca2+ enriched apatite for total oxidation of toluene. Appl Catal, B 184:87–95. https://doi.org/10.1016/j.apcatb.2015.11.020
Chlala D, Griboval-Constant A, Nuns N, Giraudon JM, Labaki M, Lamonier JF (2018) Effect of Mn loading onto hydroxyapatite supported Mn catalysts for toluene removal: contribution of PCA assisted ToF-SIMS. Catal Today 307:41–47. https://doi.org/10.1016/j.cattod.2017.04.018
Cichowska-Kopczyńska I, Joskowska M, Debski B, Aranowski R, Hupka J (2018) Separation of toluene from gas phase using supported imidazolium ionic liquid membrane. J Membr Sci 566:367–373. https://doi.org/10.1016/j.memsci.2018.08.058
Colman-Lerner E, Peluso MA, Sambeth J, Thomas H (2016) Cerium, manganese and cerium/manganese ceramic monolithic catalysts. Study of VOCs and PM removal. J Rare Earths 34:675–682. https://doi.org/10.1016/s1002-0721(16)60078-9
Delimaris D, Ioannides T (2008) VOC oxidation over MnOx–CeO2 catalysts prepared by a combustion method. Appl Catal, B 84:303–312. https://doi.org/10.1016/j.apcatb.2008.04.006
Deng J, Dai H, Jiang H, Zhang L, Wang G, He H, Au CT (2010) Hydrothermal fabrication and catalytic properties of La1-xSrxM1-yFeyO3 (M = Mn, Co) that are highly active for the removal of toluene. Environ Sci Technol 44:2618–2623. https://doi.org/10.1021/es9031997
Deng J, Zhang L, Dai H, He H, Au CT (2008) Strontium-doped lanthanum cobaltite and manganite: highly active catalysts for toluene complete oxidation. Ind Eng Chem Res 47:8175–8183. https://doi.org/10.1021/ie800585x
Deng J, Zhang L, Dai H, He H, Au CT (2009) Hydrothermally fabricated single-crystalline strontium-substituted lanthanum manganite microcubes for the catalytic combustion of toluene. J Mol Catal A: Chem 299:60–67. https://doi.org/10.1016/j.molcata.2008.10.006
Deng L, Ding Y, Duan B, Chen Y, Li P, Zhu S, Shen S (2018a) Catalytic deep combustion characteristics of benzene over cobalt doped Mn-Ce solid solution catalysts at lower temperatures. Mol Catal 446:72–80. https://doi.org/10.1016/j.mcat.2017.12.020
Deng L, Huang C, Kan J, Li B, Chen Y, Zhu S, Shen S (2018b) Effect of coating modification of cordierite carrier on catalytic performance of supported NiMnO3 catalysts for VOCs combustion. J Rare Earths 36:265–272. https://doi.org/10.1016/j.jre.2017.07.015
Derwent RG, Jenkin ME, Saunders SM (1996) Photochemical ozone creation potentials for a large number of reactive hydrocarbons under European conditions. Atmos Environ 30:181–199. https://doi.org/10.1016/1352-2310(95)00303-G
Doggali P, Teraoka Y, Mungse P, Shah IK, Rayalu S, Labhsetwar N (2012) Combustion of volatile organic compounds over Cu–Mn based mixed oxide type catalysts supported on mesoporous Al2O3, TiO2 and ZrO2. J Mol Catal A: Chem 358:23–30. https://doi.org/10.1016/j.molcata.2012.02.004
Dong C, Qu Z, Qin Y, Fu Q, Sun H, Duan X (2019) Revealing the highly catalytic performance of spinel CoMn2O4 for toluene oxidation: involvement and replenishment of oxygen species using in situ designed-TP techniques. ACS Catal 9:6698–6710. https://doi.org/10.1021/acscatal.9b01324
Du J, Qu Z, Dong C, Song L, Qin Y, Huang N (2018) Low-temperature abatement of toluene over Mn-Ce oxides catalysts synthesized by a modified hydrothermal approach. Appl Surf Sci 433:1025–1035. https://doi.org/10.1016/j.apsusc.2017.10.116
Du Y, Meng Q, Wang J, Yan J, Fan H, Liu Y, Dai H (2012) Three-dimensional mesoporous manganese oxides and cobalt oxides: high-efficiency catalysts for the removal of toluene and carbon monoxide. Microporous Mesoporous Mater 162:199–206. https://doi.org/10.1016/j.micromeso.2012.06.030
Durán FG, Barbero BP, Cadús LE, Rojas C, Centeno MA, Odriozola JA (2009) Manganese and iron oxides as combustion catalysts of volatile organic compounds. Appl Catal, B 92:194–201. https://doi.org/10.1016/j.apcatb.2009.07.010
Feng J, Hou Z-Y, Zhou X-Y, Zhang H-L, Cheng T-Q, Lin T, Chen Y-Q (2017) Low-temperature catalytic oxidation of toluene over Mn–Co–O/Ce0.65Zr0.35O2 mixed oxide catalysts. Chem Pap 72:161–172. https://doi.org/10.1007/s11696-017-0267-8
García T, López JM, Mayoral Á, Zhang YP, Arenal R, Alonso-Domínguez D, Pico MP, López ML, Dejoz A, Álvarez-Serrano I, Sanchis R, Solsona B (2019) Green synthesis of cavity-containing manganese oxides with superior catalytic performance in toluene oxidation. Appl Catal, A 582:117107. https://doi.org/10.1016/j.apcata.2019.06.005
Genuino HC, Dharmarathna S, Njagi EC, Mei MC, Suib SL (2012) Gas-phase total oxidation of benzene, toluene, ethylbenzene, and xylenes using shape-selective manganese oxide and copper manganese oxide catalysts. J Phys Chem C 116:12066–12078. https://doi.org/10.1021/jp301342f
Giroir-Fendler A, Alves-Fortunato M, Richard M, Wang C, Díaz JA, Gil S, Zhang CH, Can F, Bion N, Guo YL (2016) Synthesis of oxide supported LaMnO3 perovskites to enhance yields in toluene combustion. Appl Catal, B 180:29–37. https://doi.org/10.1016/j.apcatb.2015.06.005
Hannigan JH, Bowen SE (2010) Reproductive toxicology and teratology of abused toluene. Syst Biol Reprod Med 56:184–200. https://doi.org/10.3109/19396360903377195
Hariz R, del Rio Sanz JI, Mercier C, Valentin R, Dietrich N, Mouloungui Z, Hébrard G (2017) Absorption of toluene by vegetable oil–water emulsion in scrubbing tower: experiments and modeling. Chem Eng Sci 157:264–271. https://doi.org/10.1016/j.ces.2016.06.008
Hou Z, Feng J, Lin T, Zhang H, Zhou X, Chen Y (2018) The performance of manganese-based catalysts with Ce0.65Zr0.35O2 as support for catalytic oxidation of toluene. Appl Surf Sci 434:82–90. https://doi.org/10.1016/j.apsusc.2017.09.048
Hsu DJ, Huang HL, Lin HY, Lin TS (2006) Potential volatile organic compound exposure from dry process photocopiers in operation-idle mode. Bull Environ Contam Toxicol 76:922–929. https://doi.org/10.1007/s00128-006-1006-y
Hu F, Chen J, Peng Y, Song H, Li K, Li J (2018a) Novel nanowire self-assembled hierarchical CeO2 microspheres for low temperature toluene catalytic combustion. Chem Eng J 331:425–434. https://doi.org/10.1016/j.cej.2017.08.110
Hu F, Chen J, Zhao S, Li K, Si W, Song H, Li J (2017) Toluene catalytic combustion over copper modified Mn0.5Ce0.5Ox solid solution sponge-like structures. Appl Catal, A 540:57–67. https://doi.org/10.1016/j.apcata.2017.04.010
Hu J, Li WB, Liu RF (2018b) Highly efficient copper-doped manganese oxide nanorod catalysts derived from CuMnO hierarchical nanowire for catalytic combustion of VOCs. Catal Today 314:147–153. https://doi.org/10.1016/j.cattod.2018.02.009
Huang H, Xu Y, Feng Q, Leung DYC (2015) Low temperature catalytic oxidation of volatile organic compounds: a review. Catal Sci Technol 5:2649–2669. https://doi.org/10.1039/c4cy01733a
Huang H, Zhang CH, Wang L, Li GQ, Song L, Li GC, Tang SF, Li XB (2016) Promotional effect of HZSM-5 on the catalytic oxidation of toluene over MnOx/HZSM-5 catalysts. Catal Sci Technol 6:4260–4270. https://doi.org/10.1039/c5cy02011e
Huang N, Qu Z, Dong C, Qin Y, Duan X (2018) Superior performance of α@β-MnO2 for the toluene oxidation: active interface and oxygen vacancy. Appl Catal, A 560:195–205. https://doi.org/10.1016/j.apcata.2018.05.001
Huang Q, Zhang Z-Y, Ma W-J, Chen Y-W, Zhu S-M, Shen S-B (2012) A novel catalyst of Ni–Mn complex oxides supported on cordierite for catalytic oxidation of toluene at low temperature. J Ind Eng Chem 18:757–762. https://doi.org/10.1016/j.jiec.2011.11.129
Jung S-C, Park Y-K, Jung HY, Kang UI, Nah JW, Kim SC (2015) Effects of calcination and support on supported manganese catalysts for the catalytic oxidation of toluene as a model of VOCs. Res Chem Intermed 42:185–199. https://doi.org/10.1007/s11164-015-2333-6
Kamal MS, Razzak SA, Hossain MM (2016) Catalytic oxidation of volatile organic compounds (VOCs)—a review. Atmos Environ 140:117–134. https://doi.org/10.1016/j.atmosenv.2016.05.031
Kašpar J, Fornasiero P, Graziani M (1999) Use of CeO2-based oxides in the three-way catalysis. Catal Today 50:285–298. https://doi.org/10.1016/S0920-5861(98)00510-0
Kim SC, Park Y-K, Nah JW (2014) Property of a highly active bimetallic catalyst based on a supported manganese oxide for the complete oxidation of toluene. Powder Technol 266:292–298. https://doi.org/10.1016/j.powtec.2014.06.049
Kim SC, Shim WG (2010) Catalytic combustion of VOCs over a series of manganese oxide catalysts. Appl Catal, B 98:180–185. https://doi.org/10.1016/j.apcatb.2010.05.027
Lahousse C, Bernier A, Grange P, Delmon B, Papaefthimiou P, Ioannides T, Verykios X (1998) Evaluation of γ-MnO2 as a VOC removal catalyst: comparison with a noble metal catalyst. J Catal 178:214–225. https://doi.org/10.1006/jcat.1998.2148
Li D, Shen G, Tang W, Liu H, Chen Y (2014a) Large-scale synthesis of hierarchical MnO2 for benzene catalytic oxidation. Particuology 14:71–75. https://doi.org/10.1016/j.partic.2013.06.010
Li J, Li L, Cheng W, Wu F, Lu X, Li Z (2014b) Controlled synthesis of diverse manganese oxide-based catalysts for complete oxidation of toluene and carbon monoxide. Chem Eng J 244:59–67. https://doi.org/10.1016/j.cej.2014.01.041
Li L, Jing F, Yan J, Jing J, Chu W (2017a) Highly effective self-propagating synthesis of CeO2-doped MnO2 catalysts for toluene catalytic combustion. Catal Today 297:167–172. https://doi.org/10.1016/j.cattod.2017.04.053
Li L, Luo J, Liu Y, Jing F, Su D, Chu W (2017b) Self-propagated flaming synthesis of highly active layered CuO–δ-MnO2 hybrid composites for catalytic total oxidation of toluene pollutant. ACS Appl Mater Interfaces 9:21798–21808. https://doi.org/10.1021/acsami.7b04380
Li WB, Chu WB, Zhuang M, Hua J (2004) Catalytic oxidation of toluene on Mn–containing mixed oxides prepared in reverse microemulsions. Catal Today 93-95:205–209. https://doi.org/10.1016/j.cattod.2004.06.042
Li WB, Wang JX, Gong H (2009) Catalytic combustion of VOCs on non-noble metal catalysts. Catal Today 148:81–87. https://doi.org/10.1016/j.cattod.2009.03.007
Li WB, Zhuang M, Wang JX (2008) Catalytic combustion of toluene on Cu-Mn/MCM-41 catalysts: influence of calcination temperature and operating conditions on the catalytic activity. Catal Today 137:340–344. https://doi.org/10.1016/j.cattod.2007.11.002
Li WB, Zhuang M, Xiao TC, Green MLH (2006) MCM-41 supported Cu−Mn catalysts for catalytic oxidation of toluene at low temperatures. J Phys Chem B 110:21568–21571. https://doi.org/10.1021/jp063580g
Li X, Wang L, Xia Q, Liu Z, Li Z (2011) Catalytic oxidation of toluene over copper and manganese based catalysts: effect of water vapor. Catal Commun 14:15–19. https://doi.org/10.1016/j.catcom.2011.07.003
Liang S, Teng F, Bulgan G, Zong R, Zhu Y (2008) Effect of phase structure of MnO2 nanorod catalyst on the activity for CO oxidation. J Phys Chem C 112:5307–5315. https://doi.org/10.1021/jp0774995
Liao Y, Fu M, Chen L, Wu J, Huang B, Ye D (2013) Catalytic oxidation of toluene over nanorod-structured Mn–Ce mixed oxides. Catal Today 216:220–228. https://doi.org/10.1016/j.cattod.2013.06.017
Liao Y, Zhang X, Peng R, Zhao M, Ye D (2017) Catalytic properties of manganese oxide polyhedra with hollow and solid morphologies in toluene removal. Appl Surf Sci 405:20–28. https://doi.org/10.1016/j.apsusc.2017.02.012
Lin F, Wang Z, Zhang Z, He Y, Zhu Y, Shao J, Yuan D, Chen G, Cen K (2019) Flue gas treatment with ozone oxidation: an overview on NOx, organic pollutants, and mercury. Chem Eng J. https://doi.org/10.1016/j.cej.2019.123030
Liu L, Jia J, Sun T, Zhang H (2018a) A facile method for scalable preparation of mesoporous structured SmMnO3 perovskites sheets for efficient catalytic oxidation of toluene. Mater Lett 212:107–110. https://doi.org/10.1016/j.matlet.2017.10.048
Liu L, Li J, Zhang H, Li L, Zhou P, Meng X, Guo M, Jia J, Sun T (2019) In situ fabrication of highly active γ-MnO2/SmMnO3 catalyst for deep catalytic oxidation of gaseous benzene, ethylbenzene, toluene, and o-xylene. J Hazard Mater 362:178–186. https://doi.org/10.1016/j.jhazmat.2018.09.012
Liu P, He H, Wei G, Liu D, Liang X, Chen T, Zhu J, Zhu R (2017) An efficient catalyst of manganese supported on diatomite for toluene oxidation: manganese species, catalytic performance, and structure-activity relationship. Microporous Mesoporous Mater 239:101–110. https://doi.org/10.1016/j.micromeso.2016.09.053
Liu S, Chen J, Peng Y, Hu F, Li K, Song H, Li X, Zhang Y, Li J (2018b) Studies on toluene adsorption performance and hydrophobic property in phenyl functionalized KIT-6. Chem Eng J 334:191–197. https://doi.org/10.1016/j.cej.2017.08.091
Liu Y, Dai H, Deng J, Zhang L, Gao B, Wang Y, Li X, Xie S, Guo G (2013) PMMA-templating generation and high catalytic performance of chain-like ordered macroporous LaMnO3 supported gold nanocatalysts for the oxidation of carbon monoxide and toluene. Appl Catal, B 140-141:317–326. https://doi.org/10.1016/j.apcatb.2013.04.025
Liu Y, Dai H, Du Y, Deng J, Zhang L, Zhao Z, Au CT (2012) Controlled preparation and high catalytic performance of three-dimensionally ordered macroporous LaMnO3 with nanovoid skeletons for the combustion of toluene. J Catal 287:149–160. https://doi.org/10.1016/j.jcat.2011.12.015
Lu H, Kong X, Huang H, Zhou Y, Chen Y (2015) Cu-Mn-Ce ternary mixed-oxide catalysts for catalytic combustion of toluene. J Environ Sci 32:102–107. https://doi.org/10.1016/j.jes.2014.11.015
Lu H, Zhou Y, Huang H, Zhang B, Chen Y (2011) In-situ synthesis of monolithic Cu-Mn-Ce/cordierite catalysts towards VOCs combustion. J Rare Earths 29:855–860. https://doi.org/10.1016/s1002-0721(10)60555-8
Luo Y, Dai H, Deng J, Zhang L, Gao B, Wang Y, Li X, Xie S, Guo G (2018) Insights into the high performance of Mn-Co oxides derived from metal-organic frameworks for total toluene oxidation. J Hazard Mater 349:119–127. https://doi.org/10.1016/j.jhazmat.2018.01.053
Ma J, Wang C, He H (2017) Transition metal doped cryptomelane-type manganese oxide catalysts for ozone decomposition. Appl Catal, B 201:503–510. https://doi.org/10.1016/j.apcatb.2016.08.050
Ma WJ, Huang Q, Xu Y, Chen YW, Zhu SM, Shen SB (2013) Catalytic combustion of toluene over Fe–Mn mixed oxides supported on cordierite. Ceram Int 39:277–281. https://doi.org/10.1016/j.ceramint.2012.06.022
Mathur AK, Majumder CB, Chatterjee S (2007) Combined removal of BTEX in air stream by using mixture of sugar cane bagasse, compost and GAC as biofilter media. J Hazard Mater 148:64–74. https://doi.org/10.1016/j.jhazmat.2007.02.030
Meng Q, Wang W, Weng X, Liu Y, Wang H, Wu Z (2016) Active oxygen species in Lan+1NinO3n+1 layered perovskites for catalytic oxidation of toluene and methane. J Phys Chem C 120:3259–3266. https://doi.org/10.1021/acs.jpcc.5b08703
Meng Y, Genuino HC, Kuo CH, Huang H, Chen SY, Zhang L, Rossi A, Suib SL (2013) One-step hydrothermal synthesis of manganese-containing MFI-type zeolite, Mn-ZSM-5, characterization, and catalytic oxidation of hydrocarbons. J Am Chem Soc 135:8594–8605. https://doi.org/10.1021/ja4013936
Merino NA, Barbero BP, Grange P, Cadus LE (2005) LaCaCoO perovskite-type oxides: preparation, characterisation, stability, and catalytic potentiality for the total oxidation of propane. J Catal 231:232–244. https://doi.org/10.1016/j.jcat.2005.01.003
Merino NA, Barbero BP, Ruiz P, Cadús LE (2006) Synthesis, characterisation, catalytic activity and structural stability of LaCo1−yFeyO3±λ perovskite catalysts for combustion of ethanol and propane. J Catal 240:245–257. https://doi.org/10.1016/j.jcat.2006.03.020
Miao L, Wang J, Zhang P (2019) Review on manganese dioxide for catalytic oxidation of airborne formaldehyde. Appl Surf Sci 466:441–453. https://doi.org/10.1016/j.apsusc.2018.10.031
Morales MR, Barbero BP, Cadús LE (2008) Evaluation and characterization of Mn–Cu mixed oxide catalysts for ethanol total oxidation: influence of copper content. Fuel 87:1177–1186. https://doi.org/10.1016/j.fuel.2007.07.015
Muñoz-Batista MJ, Bertolini GR, Cabello CI, Luque R, Rodríguez-Castellón E, Kubacka A, Fernández-García M (2018) Novel (NH4)4[NiMo6O24H6]·5H2O–TiO2 composite system: photo-oxidation of toluene under UV and sunlight-type illumination. Appl Catal, B 238:381–392. https://doi.org/10.1016/j.apcatb.2018.07.041
Nijhuis TA, Beers AEW, Vergunst T, Hoek I, Kapteijn F, Moulijn JA (2001) Preparation of monolithic catalysts. Cat Rev - Sci Eng 43:345–380. https://doi.org/10.1081/CR-120001807
Niu J, Qian H, Liu J, Liu H, Zhang P, Duan E (2018) Process and mechanism of toluene oxidation using Cu1-yMn2CeyOx/sepiolite prepared by the co-precipitation method. J Hazard Mater 357:332–340. https://doi.org/10.1016/j.jhazmat.2018.06.004
Ordóñez S, Bello L, Sastre H, Rosal R, Díez FV (2002) Kinetics of the deep oxidation of benzene, toluene, n-hexane and their binary mixtures over a platinum on γ-alumina catalyst. Appl Catal, B 38:139–149. https://doi.org/10.1016/S0926-3373(02)00036-X
Özçelik Z, Soylu GSP, Boz İ (2009) Catalytic combustion of toluene over Mn, Fe and Co-exchanged clinoptilolite support. Chem Eng J 155:94–100. https://doi.org/10.1016/j.cej.2009.07.013
Papavasiliou J, Avgouropoulos G, Ioannides T (2007) Combined steam reforming of methanol over Cu–Mn spinel oxide catalysts. J Catal 251:7–20. https://doi.org/10.1016/j.jcat.2007.07.025
Peña MA, Fierro JLG (2001) Chemical structures and performance of perovskite oxides. Chem Rev 101:1981–2018. https://doi.org/10.1021/cr980129f
Peng R, Li S, Sun X, Ren Q, Chen L, Fu M, Wu J, Ye D (2018) Size effect of Pt nanoparticles on the catalytic oxidation of toluene over Pt/CeO2 catalysts. Appl Catal, B 220:462–470. https://doi.org/10.1016/j.apcatb.2017.07.048
Peng Y, Zhang L, Chen L, Yuan D, Wang G, Meng X, Xiao F-S (2017) Catalytic performance for toluene abatement over Al-rich beta zeolite supported manganese oxides. Catal Today 297:182–187. https://doi.org/10.1016/j.cattod.2017.04.058
Piumetti M, Fino D, Russo N (2015) Mesoporous manganese oxides prepared by solution combustion synthesis as catalysts for the total oxidation of VOCs. Appl Catal, B 163:277–287. https://doi.org/10.1016/j.apcatb.2014.08.012
Pozan GS (2012) Effect of support on the catalytic activity of manganese oxide catalyts for toluene combustion. J Hazard Mater 221-222:124–130. https://doi.org/10.1016/j.jhazmat.2012.04.022
Qin C, Dang X, Huang J, Teng J, Huang X (2016) Plasma-catalytic oxidation of adsorbed toluene on Ag–Mn/γ-Al2O3: comparison of gas flow-through and gas circulation treatment. Chem Eng J 299:85–92. https://doi.org/10.1016/j.cej.2016.04.093
Qin L, Huang X, Zhao B, Wang Y, Han J (2019a) Iron oxide as a promoter for toluene catalytic oxidation over Fe–Mn/γ-Al2O3 catalysts. Catal Lett. https://doi.org/10.1007/s10562-019-02975-5
Qin Y, Qu Z, Dong C, Wang Y, Huang N (2019b) Highly catalytic activity of Mn/SBA-15 catalysts for toluene combustion improved by adjusting the morphology of supports. J Environ Sci 76:208–216. https://doi.org/10.1016/j.jes.2018.04.027
Qu Z, Gao K, Fu Q, Qin Y (2014) Low-temperature catalytic oxidation of toluene over nanocrystal-like Mn–Co oxides prepared by two-step hydrothermal method. Catal Commun 52:31–35. https://doi.org/10.1016/j.catcom.2014.03.035
Rokicińska A, Drozdek M, Dudek B, Gil B, Michorczyk P, Brouri D, Dzwigaj S, Kuśtrowski P (2017) Cobalt-containing BEA zeolite for catalytic combustion of toluene. Appl Catal, B 212:59–67. https://doi.org/10.1016/j.apcatb.2017.04.067
Santos VP, Bastos SST, Pereira MFR, Órfão JJM, Figueiredo JL (2010a) Stability of a cryptomelane catalyst in the oxidation of toluene. Catal Today 154:308–311. https://doi.org/10.1016/j.cattod.2009.12.005
Santos VP, Pereira MFR, Órfão JJM, Figueiredo JL (2010b) The role of lattice oxygen on the activity of manganese oxides towards the oxidation of volatile organic compounds. Appl Catal, B 99:353–363. https://doi.org/10.1016/j.apcatb.2010.07.007
Saqer SM, Kondarides DI, Verykios XE (2011) Catalytic oxidation of toluene over binary mixtures of copper, manganese and cerium oxides supported on γ-Al2O3. Appl Catal, B 103:275–286. https://doi.org/10.1016/j.apcatb.2011.01.001
Seiyama T (1992) Total oxidation of hydrocarbons on perovskite oxides. Catal Rev 34:281–300. https://doi.org/10.1080/01614949208016313
Shan Y, Gao N, Chen Y, Shen S (2019) Self-template synthesis of a MnCeOδ/Co3O4 polyhedral nanocage catalyst for toluene oxidation. Ind Eng Chem Res 58:16370–16378. https://doi.org/10.1021/acs.iecr.9b00847
Shi F, Wang F, Dai H, Dai J, Deng J, Liu Y, Bai G, Ji K, Au CT (2012) Rod-, flower-, and dumbbell-like MnO2: highly active catalysts for the combustion of toluene. Appl. Catal, A 433-434:206–213. https://doi.org/10.1016/j.apcata.2012.05.016
Si W, Wang Y, Peng Y, Li X, Li K, Li J (2015) A high-efficiency γ-MnO2-like catalyst in toluene combustion. Chem Commun 51:14977–14980. https://doi.org/10.1039/c5cc04528b
Si W, Wang Y, Zhao S, Hu F, Li J (2016) A facile method for in situ preparation of the MnO2/LaMnO3 catalyst for the removal of toluene. Environ Sci Technol 50:4572–4578. https://doi.org/10.1021/acs.est.5b06255
Sihaib Z, Puleo F, Garcia-Vargas JM, Retailleau L, Descorme C, Liotta LF, Valverde JL, Gil S, Giroir-Fendler A (2017) Manganese oxide-based catalysts for toluene oxidation. Appl Catal, B 209:689–700. https://doi.org/10.1016/j.apcatb.2017.03.042
Solsona B, García T, Sanchis R, Soriano MD, Moreno M, Rodríguez-Castellón E, Agouram S, Dejoz A, López Nieto JM (2016) Total oxidation of VOCs on mesoporous iron oxide catalysts: soft chemistry route versus hard template method. Chem Eng J 290:273–281. https://doi.org/10.1016/j.cej.2015.12.109
Soylu GSP, Özçelik Z, Boz İ (2010) Total oxidation of toluene over metal oxides supported on a natural clinoptilolite-type zeolite. Chem Eng J 162:380–387. https://doi.org/10.1016/j.cej.2010.05.020
Spiveya JJ, Buttb JB (1992) Literature review: deactivation of catalysts in the oxidation of volatile organic compounds. Catal Today 4:465–500. https://doi.org/10.1016/0920-5861(92)80039-P
Suárez-Vázquez SI, Gil S, García-Vargas JM, Cruz-López A, Giroir-Fendler A (2018) Catalytic oxidation of toluene by SrTi1-XBXO3 (B = Cu and Mn) with dendritic morphology synthesized by one pot hydrothermal route. Appl Catal, B 223:201–208. https://doi.org/10.1016/j.apcatb.2017.04.042
Suib SL (2008) Porous manganese oxide octahedral molecular sieves and octahedral layered materials. Acc Chem Res 41:479–487. https://doi.org/10.1021/ar7001667
Sun H, Chen S, Wang P, Quan X (2011) Catalytic oxidation of toluene over manganese oxide octahedral molecular sieves (OMS-2) synthesized by different methods. Chem Eng J 178:191–196. https://doi.org/10.1016/j.cej.2011.10.047
Sun H, Liu Z, Chen S, Quan X (2015) The role of lattice oxygen on the activity and selectivity of the OMS-2 catalyst for the total oxidation of toluene. Chem Eng J 270:58–65. https://doi.org/10.1016/j.cej.2015.02.017
Sun H, Yu X, Ma X, Yang X, Lin M, Ge M (2019) MnOx-CeO2 catalyst derived from metal-organic frameworks for toluene oxidation. Catal Today. https://doi.org/10.1016/j.cattod.2019.05.062
Sun J, Wu F, Hu B, Tang G, Zhang J, Wang Y (2016) VOC characteristics, emissions and contributions to SOA formation during hazy episodes. Atmos Environ 141:560–570. https://doi.org/10.1016/j.atmosenv.2016.06.060
Sun M, Yu L, Fei Y, Diao G, Yu Q, Hao Z, Zheng Y, Yuan L (2013) Transition metal doped cryptomelane-type manganese oxide for low-temperature catalytic combustion of dimethyl ether. Chem Eng J 220:320–327. https://doi.org/10.1016/j.cej.2013.01.061
Tan W, Guo G, Deng J, Xie S, Yang H, Jiang Y, Dai H (2014) Au/Ce0.6Zr0.3Y0.1O2 nanorods: highly active catalysts for the oxidation of carbon monoxide and toluene. Ind Eng Chem Res 53:18452–18461. https://doi.org/10.1021/ie503784e
Tang W, Wu X, Liu G, Li S, Li D, Li W, Chen Y (2015) Preparation of hierarchical layer-stacking Mn-Ce composite oxide for catalytic total oxidation of VOCs. J Rare Earths 33:62–69. https://doi.org/10.1016/s1002-0721(14)60384-7
Tomašić V, Jović F (2006) State-of-the-art in the monolithic catalysts/reactors. Appl Catal, A 311:112–121. https://doi.org/10.1016/j.apcata.2006.06.013
Torres JQ, Sb R, Bellat J-P, Giraudon J-M, JeanFran Å (2013) Formaldehyde: catalytic oxidation as a promising soft way of elimination. Chem Sus Chem 6:578–592. https://doi.org/10.1002/cssc.201200809
Wang F, Dai H, Deng J, Bai G, Ji K, Liu Y (2012) Manganese oxides with rod-, wire-, tube-, and flower-like morphologies: highly effective catalysts for the removal of toluene. Environ Sci Technol 46:4034–4041. https://doi.org/10.1021/es204038j
Wang H, Lu Y, Han Y, Lu C, Wan H, Xu Z, Zheng S (2017) Enhanced catalytic toluene oxidation by interaction between copper oxide and manganese oxide in Cu-O-Mn/γ-Al2O3 catalysts. Appl Surf Sci 420:260–266. https://doi.org/10.1016/j.apsusc.2017.05.133
Wang H, Nie L, Li J, Wang Y, Wang G, Wang J, Hao Z (2013) Characterization and assessment of volatile organic compounds (VOCs) emissions from typical industries. Chin Sci Bull 58:724–730. https://doi.org/10.1007/s11434-012-5345-2
Wang L, Zhang C, Huang H, Li X, Zhang W, Lu M, Li M (2016a) Catalytic oxidation of toluene over active MnOx catalyst prepared via an alkali-promoted redox precipitation method. React Kinet, Mech Catal 118:605–619. https://doi.org/10.1007/s11144-016-1011-z
Wang Y, Deng W, Wang Y, Guo L, Ishihara T (2018a) A comparative study of the catalytic oxidation of chlorobenzene and toluene over Ce-Mn oxides. Mol Catal 459:61–70. https://doi.org/10.1016/j.mcat.2018.08.022
Wang Y, Guo L, Chen M, Shi C (2018b) CoMnxOy nanosheets with molecular-scale homogeneity: an excellent catalyst for toluene combustion. Catal Sci Technol 8:459–471. https://doi.org/10.1039/c7cy01867c
Wang Y, Xie S, Deng J, Deng S, Wang H, Yan H, Dai H (2014) Morphologically controlled synthesis of porous spherical and cubic LaMnO3 with high activity for the catalytic removal of toluene. ACS Appl Mater interfaces 6:17394–17401. https://doi.org/10.1021/am500489x
Wang Y, Xue Y, Zhao C, Zhao D, Liu F, Wang K, Dionysiou DD (2016b) Catalytic combustion of toluene with La0.8Ce0.2MnO3 supported on CeO2 with different morphologies. Chem Eng J 300:300–305. https://doi.org/10.1016/j.cej.2016.04.007
Wang Y, Yang D, Li S, Zhang L, Zheng G, Guo L (2019) Layered copper manganese oxide for the efficient catalytic CO and VOCs oxidation. Chem Eng J 357:258–268. https://doi.org/10.1016/j.cej.2018.09.156
Wang Y, Zhang L, Guo L (2018c) Enhanced toluene combustion over highly homogeneous iron manganese oxide nanocatalysts. ACS Appl Nano Mater 1:1066–1075. https://doi.org/10.1021/acsanm.7b00258
Wang Z, Qin Y, Pan F, Li Z, Zhang W, Wu F, Chen D, Wen W, Li J (2018d) Mesoporous silica-supported manganese oxides for complete oxidation of volatile organic compounds: influence of mesostructure, redox properties, and hydrocarbon dimension. Ind Eng Chem Res 57:7374–7382. https://doi.org/10.1021/acs.iecr.8b00630
Weng X, Zhang J, Wu Z, Liu Y (2011) Continuous hydrothermal flow syntheses of transition metal oxide doped CexTiO2 nanopowders for catalytic oxidation of toluene. Catal Today 175:386–392. https://doi.org/10.1016/j.cattod.2011.04.016
Wu Y, Yuan S, Feng R, Ma Z, Gao Y, Xing S (2017) Comparative study for low-temperature catalytic oxidation of o-xylene over doped OMS-2 catalysts: role of Ag and Cu. Mol Catal 442:164–172. https://doi.org/10.1016/j.mcat.2017.09.020
Xu H, Yan N, Qu Z, Liu W, Mei J, Huang W, Zhao S (2017) Gaseous heterogeneous catalytic reactions over Mn-based oxides for environmental applications: a critical review. Environ Sci Technol 51:8879–8892. https://doi.org/10.1021/acs.est.6b06079
Yang X, Yu X, Jing M, Song W, Liu J, Ge M (2019a) Defective MnxZr1–xO2 solid solution for the catalytic oxidation of toluene: insights into the oxygen vacancy contribution. ACS Appl Mater interfaces 11:730–739. https://doi.org/10.1021/acsami.8b17062
Yang X, Yu X, Lin M, Ma X, Ge M (2019b) Enhancement effect of acid treatment on Mn2O3 catalyst for toluene oxidation. Catal Today 327:254–261. https://doi.org/10.1016/j.cattod.2018.04.041
Ye Z, Giraudon JM, Nuns N, Simon P, De Geyter N, Morent R, Lamonier JF (2018) Influence of the preparation method on the activity of copper-manganese oxides for toluene total oxidation. Appl Catal, B 223:154–166. https://doi.org/10.1016/j.apcatb.2017.06.072
Yosefi L, Haghighi M, Allahyari S, Shokrani R, Ashkriz S (2015) Abatement of toluene from polluted air over Mn/Clinoptilolite–CeO2 nanopowder: impregnation vs. ultrasound assisted synthesis with various Mn-loading. Adv Powder Technol 26:602–611. https://doi.org/10.1016/j.apt.2015.01.009
Yu D, Liu Y, Wu Z (2010) Low-temperature catalytic oxidation of toluene over mesoporous MnOx–CeO2/TiO2 prepared by sol–gel method. Catal Commun 11:788–791. https://doi.org/10.1016/j.catcom.2010.02.016
Zhang C, Guo Y, Guo Y, Lu G, Boreave A, Laurence R, Baylet A, Giroir-Fendler A (2014) LaMnO3 perovskite oxides prepared by different methods for catalytic oxidation of toluene. Appl Catal, B 148-149:490–498. https://doi.org/10.1016/j.apcatb.2013.11.030
Zhang C, Huang H, Li G, Wang L, Song L, Li X (2019) Zeolitic acidity as a promoter for the catalytic oxidation of toluene over MnOx/HZSM-5 catalysts. Catal Today 327:374–381. https://doi.org/10.1016/j.cattod.2018.03.019
Zhang X, Gao B, Creamer AE, Cao C, Li Y (2017) Adsorption of VOCs onto engineered carbon materials: a review. J Hazard Mater 338:102–123. https://doi.org/10.1016/j.jhazmat.2017.05.013
Zhang Y, Zhang H, Yan Y (2018) Metal-organic chemical vapor deposition of Cu(acac)2 for the synthesis of Cu/ZSM-5 catalysts for the oxidation of toluene. Microporous Mesoporous Mater 261:244–251. https://doi.org/10.1016/j.micromeso.2017.11.006
Zhao C, Hao Q, Zhang Q, Yan N, Liu J, Dou B, Bin F (2019) Catalytic self-sustained combustion of toluene and reaction pathway over CuxMn1-xCe0.75Zr0.25/TiO2 catalysts. Appl Catal, A 569:66–74. https://doi.org/10.1016/j.apcata.2018.10.034
Zhao S, Li K, Jiang S, Li J (2016) Pd–Co based spinel oxides derived from pd nanoparticles immobilized on layered double hydroxides for toluene combustion. Appl Catal, B 181:236–248. https://doi.org/10.1016/j.apcatb.2015.08.001
Zhou G, He X, Liu S, Xie H, Fu M (2015) Phenyl VOCs catalytic combustion on supported CoMn/AC oxide catalyst. J Ind Eng Chem 21:932–941. https://doi.org/10.1016/j.jiec.2014.04.035
Zhou G, Lan H, Wang H, Xie H, Zhang G, Zheng X (2014) Catalytic combustion of PVOCs on MnOx catalysts. J Mol Catal A: Chem 393:279–288. https://doi.org/10.1016/j.molcata.2014.06.028
Funding
This work was supported by the Key Research and Development Program of Hunan Province in China [2018SK2032] and the National Key Research and Development Program of China [2016YFC0204100].
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible Editor: Santiago V. Luis
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Lyu, Y., Li, C., Du, X. et al. Catalytic removal of toluene over manganese oxide-based catalysts: a review. Environ Sci Pollut Res 27, 2482–2501 (2020). https://doi.org/10.1007/s11356-019-07037-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-019-07037-2