Skip to main content
SpringerLink
Log in

Biofiltration of high formaldehyde loads with ozone additions in long-term operation

  • Environmental biotechnology
  • Published:
Applied Microbiology and Biotechnology Aims and scope Submit manuscript

Abstract

Formaldehyde (FA) biofiltration was evaluated over 310 days with and without ozone addition. Without ozone, the biofilter was able to treat formaldehyde at inlet loads (ILs) lower than 40 g m−3 h−1, maintaining, under this condition, an average removal efficiency (RE) of 88 % for a few days before collapsing to zero. The continuous addition of ozone (90 ppbv) helped to recover the RE from zero to 98 ± 2 % and made it possible to operate at an IL of 40 g m−3 h−1 for long periods of operation (107 days). Furthermore, the ozone addition aided in operating the biofilter at a formaldehyde IL of up to 120 g m−3 h−1 values that have never before been reached. GC-mass spectrometry (MS) analysis showed that dimethoxymethane was the common compound in leachate during the performance decay. Also, the addition of ozone aided in maintaining an optimal pH in the biofilter with values between 7.5 and 8.2, due to the carbonate species formed during the ozone reactions with formaldehyde and its by-products. Thus, the pH control was confirmed and the alkalinity of the biofilter increased from 334.1 ± 100.3 to 1450 ± 127 mg CaCO3 L−1 when ozone was added. Ozone addition diminished the exopolymeric substances (EPS) content of biofilm and biofilm thickness without affecting cell viability. Kinetic parameters suggested that the best conditions for carrying out FA biofiltration were reached under ozone addition. The addition of ozone during formaldehyde biofiltration could be a good strategy to maintain the pH and the steady state of the system under high ILs and for long periods of operation.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4

Similar content being viewed by others

References

  • Adroer N, Casas C, de Mas C, Solà C (1990) Mechanism of formaldehyde biodegradation by Pseudomonas putida. Appl Microbiol Biot 33:217–220. doi:10.1007/BF00176528

    Article  CAS  Google Scholar 

  • APHA, Standards methods for the examination of water of wastewater, (1998), 20th 577 ed., American Public Health Association-American Water Works. Association- 578. Water Pollution Control Federation (AWWA-WPCF), Washington, DC

  • Avalos-Ramírez A, Bénard S, Giroir-Fendler A, Jones PJ, Heitz M (2008) Kinetics microbial growth and biodegradation of methanol and toluene in biofilters and an analysis of the energetic indicators. J Biotechnol 138:88–95. doi:10.1016/j.jbiotec.2008.08.001

    Article  PubMed  Google Scholar 

  • Boncz MA (2002) Selective oxidation of organic compounds in waste water by ozone-based oxidation processes. Ph.D. dissertation. Thesis Wageningen University, Wageningen, the Netherlands. Chapters 2–7

  • Crittenden JC, Trussell RR, Hand DW, Howe KJ, Tchobanflous G (2005) Water treatment: principles and design, 2a. John Wiley & Sons, Inc, Edición

    Google Scholar 

  • Ebrahimi S, Borghei M (2011) Formaldehyde biodegradation using an immobilized bed aerobic bioreactor with pumice stone as a support. Sci Iran 18:1372–1376. doi:10.1016/j.scient.2011.01.001

    Article  CAS  Google Scholar 

  • Environmental Protection Agency (EPA), 1991, Sick Building Syndrome, Indoor Fact Sheet. 4, http://www.epa.gov/iaq/pdfs/sick_building_factsheet.pdf

  • Environmental Protection Agency (EPA), 2014, Indoor air quality, formaldehyde, http://www.epa.gov/iaq/formaldehyde.html

  • Ferranti MM (2001) Formaldehyde biological removal from exhaust air in the composite panel board industry from pilot tests to industrial plant. In: Proceedings of the 35th international particleboard composite materials symposium. Pullmann, Wash

  • Galindo H, Revah S, Cervantes FJ, Arriaga S (2011) Effect of surfactant and oil additions in the biodegradation of hexane and toluene vapors in batch tests. Environ Technol 32:167–173. doi:10.1080/09593330.2010.491132

    Article  CAS  PubMed  Google Scholar 

  • Garcia-Pérez T, Aizpuru A, Arriaga S (2013) By-passing acidification limitations during the biofiltration of high formaldehyde loads via the application of ozone pulses. J Hazard Mater 262:732–740. doi:10.1016/j.jhazmat.2013.09.053

    Article  PubMed  Google Scholar 

  • Hinojosa-Reyes M, Rodríguez-González V, Arriaga S (2012) Enhancing ethylbenzene vapors degradations in a hybrid system based on photocatalytic oxidation UV/TiO2-In and a biofiltration process. J Hazard Mater 209–210:365–371. doi:10.1016/j.jhazmat.2012.01.035

    Article  PubMed  Google Scholar 

  • Iuga C, Olea R, Vivier-Bunge A (2008) Mechanism and kinetics of the OH• radical reaction with formaldehyde bound to an Si(OH)4 monomer. J Mex Chem Soc 51:36–46

    Google Scholar 

  • Kato N, Shirakawa K, Kobayashi H, Sakazawa C (1983) The dismutation of aldehydes by a bacterial enzyme. Agric Biol Chem 47:39–46. doi:10.1271/bbb1961.47.39

    Article  CAS  Google Scholar 

  • Liu H, Fang HHP (2002) Extraction of extracellular polymeric substances (EPS) of sludges. J Biotechnol 95:249–256. doi:10.1016/S0168-1656(02)00025-1

    Article  CAS  PubMed  Google Scholar 

  • Lu Z, Hegemann W (1998) Anaerobic toxicity and biodegradation of formaldehyde in batch cultures. Water Res 32:209–215. doi:10.1016/S0043-1354(97)00181-4

    Article  CAS  Google Scholar 

  • Mah TF, O’Toole GA (2001) Mechanisms of biofilm resistance to antimicrobial agents. Trends Microbiol 9:4–39. doi:10.1016/S0966-842X(00)01913-2

    Article  Google Scholar 

  • Moussavi G, Mohseni M (2007) Using UV pretreatment to enhance biofiltration of mixtures of aromatic VOC. J Hazard Mater 144:59–66. doi:10.1016/j.jhazmat.2006.09.086

    Article  CAS  PubMed  Google Scholar 

  • Prado ÓJ, Veiga MC, Kennes C (2004) Biofiltration of waste gases containing a mixture of formaldehyde and methanol. Appl Microbiol Biot 65:235–242. doi:10.1007/s00253-004-1616-4

    Article  CAS  Google Scholar 

  • Prado ÓJ, Veiga MC, Kennes C (2006) Effect of key parameters on the removal of formaldehyde and methanol in gas-phase biotrickling filters. J Hazard Mater 138:543–548. doi:10.1016/j.jhazmat.2006.05.093

    Article  CAS  PubMed  Google Scholar 

  • Rakness K, Gordon G, Langlais B, Masschelein W, Matsumoto N, Richard Y, Robson MC, Somiya I (1996) Guideline for measurement of ozone concentration in the process gas from an ozone generator. Ozone Sci Eng 18:209–229

    Article  CAS  Google Scholar 

  • Shareefdeen Z, Baltzis BC, Oh YS, Bartha R (1993) Biofiltration of methanol vapor. Biotechnol Bioeng 41:512–524. doi:10.1002/bit.260410503

    Article  CAS  PubMed  Google Scholar 

  • Shpak ED, Lakeman MB, Torii KU (2003) Dominant-negative receptor uncovers redundancy in the arabidopsis ERECTA leucine-rich repeat receptor-like kinase signaling pathway that regulates organ shape. Plant Cell 15:1095–1110. doi:10.1105/tpc.010413

    Article  CAS  PubMed Central  PubMed  Google Scholar 

  • U.S. Department of Health and Human Services (HHS), Report on carcinogens, twelfth edition, (2011), Public Health Service. National Toxicology Program. http://ntp.niehs.nih.gov/ntp/roc/twelfth/roc12.pdf

  • Von Gunten U (2003) Ozonation of drinking water: part I. Oxidation kinetics and product formation. Water Res 37:1443–1467. doi:10.1016/S0043-1354(02)00457-8

    Article  Google Scholar 

  • Wang C, Jin -Ying X, Hong-Ying H, Yuan Y (2009) Advantages of combined UV photodegradation and biofiltration processes to treat gaseous chlorobenzene. Environ Sci Technol 43:9407–9941. doi:10.1016/j.jhazmat.2009.06.129

    Article  CAS  PubMed  Google Scholar 

  • Wei Z, Sun J, Xie Z, Liang M, Chen S (2010) Removal of gaseous toluene by the combination of photocatalytic oxidation under complex light irradiation of UV and visible light and biological process. J Hazard Mater 177:814–821. doi:10.1016/j.jhazmat.2009.12.106

  • World Health Organization. International agency for research on cancer (WHO/IARC), (2006), Monographs on the evaluation of carcinogenic risks to humans. Formaldehyde, 2-Butoxyethanol and 1-tert-Butoxyporpan-2-ol.88, 62–63.http://monographs.iarc.fr/ENG/Monographs/vol88/mono88.pdf

  • Yapsakli K, Can Z (2004) Interaction of ozone with formic acid: a system which suppresses the scavenging effect of HCO3 −/CO3 2. Water Qual Res J Can 39:140–148

    CAS  Google Scholar 

Download references

Acknowledgments

We thank CONACYT for the financial support through the SEP-CONACYT-CB-2009-133930 grant. Guadalupe Maldonado also thanks CONACYT for the Master in Science fellowship. The use of the analytical infrastructure of LANBAMA is also acknowledged. Special gratitude is expressed to M.C. Dulce Partida, M.C. Juan Pablo Rodas, and M.C. Guillermo Vidriales. We also thank Dr. Aitor Aizpuru and Jennifer Anne Eckerly Goss for their suggestions on improving the manuscript.

Author information

Authors and Affiliations

  1. División de Ciencias Ambientales, Instituto Potosino de Investigación Científica y Tecnológica, Camino a la Presa San José 2055. Col. Lomas 4ª Sección, C.P 78216, San Luis Potosí, México

    G. Maldonado-Diaz & S. Arriaga

Authors
  1. G. Maldonado-Diaz
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. S. Arriaga
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to S. Arriaga.

Electronic supplementary material

Below is the link to the electronic supplementary material.

ESM 1

(PDF 527 kb)

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Maldonado-Diaz, G., Arriaga, S. Biofiltration of high formaldehyde loads with ozone additions in long-term operation. Appl Microbiol Biotechnol 99, 43–53 (2015). https://doi.org/10.1007/s00253-014-5848-7

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00253-014-5848-7

Keywords

Search

Navigation