Abstract
Some surfactant solutions have been observed to exhibit a strong drag reduction behavior in turbulent flow. This effect is generally believed to result from the formation of large cylindrical micelles or micellar structures. To characterize and understand better these fluids, we have studied the transient rheological properties of an efficient drag-reducing aqueous solution: tris (2-hydroxyethyl) tallowalkyl ammonium acetate (TTAA) with added sodium salicylate (NaSal) as counter ion. For a 5/5 mM equimolar TTAA/NaSal solution, there is no measurable first normal stress difference (N 1) immediately after the inception of shear, but N 1 begins to increase after a well-defined induction time — presumably as shear-induced structures (SIS) are formed — and it finally reaches a fluctuating plateau region where its average value is two orders of magnitude larger than that of the shear stress. The SIS buildup times obtained by first normal stress measurements were approximately inversely proportional to the shear rate, which is consistent with a kinetic process during which individual micelles are incorporated through shear into large micellar structures. The SIS buildup after a strong preshear and the relaxation processes after flow cessation were also studied and quantified with first normal stress difference measurements. The SIS buildup times and final state were also found to be highly dependent on flow geometry. With an increase in gap between parallel plates, for example, the SIS buildup times decreased, whereas the plateau viscosity increased.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Bewersdorff HW, Frings B, Linder P, Oberthür RC (1986) The conformation of drag reducing micelles from small-angle neutron scattering experiments. Rheol Acta 25:642–646
Bewersdorff HW, Dohmann J, Langowski J, Linder P, Maack A, Oberthür RC, Thiel H (1989) SANS and LS studies on drag reducing surfactant solutions. Physica B 156/157:508–511
Gasljevic K, Matthys EF (1993) On saving pumping power in hydronic thermal distribution systems through the use of drag-reducing additives. Energy and Buildings 20:45–56
Gasljevic K, Matthys EF (1994) Hydrodynamic and thermal field development in the pipe entry region for turbulent flow of drag-reducing surfactant solutions. In: Developments in non-Newtonian flows II, FED Vol. 206/AMD Vol. 191, 51–61. ASME Pub., New York
Gu DF, Jamieson AM, Wang SQ (1993) Rheological characterization of director tumbling induced in a flow-aligning nematic solvent by dissolution of a sidechain liquid-crystal polymer. J Rheol 37:985–1001
Hoffmann H, Platz G, Rehage H, Schorr W (1982) The influence of the salt concentration on the aggregation behavior of viscoelastic detergents. Adv Colloid Interface Sci 17:27–298
Hofmann S, Rauscher A, Hoffmann H (1991) Shear-induced micellar structures. Ber Bunsen Ges Phys Chem 95:153–164
Hofmann S, Stern P, Myška J (1994) Rheological behavior and birefringence investigations on drag-reducing surfactant solutions of tallow-(tris-hydroxyethyl)-ammonium acetate/sodiumsalicylate mixtures. Rheol Acta 33:419–430
Hu Y, Wang SQ, Jamieson AM (1993a) Kinetic studies of a shear thickening micellar solution. J Colloid Interface Sci 156:31–37
Hu Y, Wang SQ, Jamieson AM (1993b) Rheological and flow birefringence studies of a shear-thickening complex fluid — a surfactant model system. J Rheol 37:531–546
Jindal VK, Kalus J, Pilsl H, Hoffmann H, Lindner P (1990) Dynamic small-angle neutron scattering study of rodlike micelles in a surfactant solution. J Phys Chem 94:3129–3138
Kalus J, Hoffmann H, Chen SH, Lindner P (1989) Correlation in micellar solutions under shear: a small-angle neutron scattering study of the chain surfactant N-hexadecyloctyldimethylammonium bromide. J Phys Chem 93:4267–4276
Larson RG, Shaqfeh ESG, Mullet SJ (1990) A purely elastic instability in Taylor-Couette flow. J Fluid Mech 218: 573–600
Macosko CW (1994) Rheology principles, measurements and applications. VCH, New York
Münch C, Hoffmann H, Ibel K, Kalus J, Neubauer G, Schmelzer U, Selbach J (1991) A shear-induced structure transition on a micellar solution measured by time-dependent small-angle neutron scattering. Progr Colloid Polym Sci 84:69–71
Myška J, Štern P (1994) Properties of a drag reducing micelle system. Colloid Poly Sci 272:542–547
Ohlendorf D, Interthal W, Hoffmann H (1986) Surfactant systems for drag reduction: physico-chemical properties and theological behavior. Rheol Acta 25:468–486
Rehage H, Hoffmann H (1982) Shear-induced phase transition in highly dilute aqueous detergent solutions. Rheol Acta 21:561–563
Rehage H, Wunderlich I, Hoffmann H (1986) Shear-induced phase transition in dilute aqueous surfactant solutions. Progr Colloid Polym Sci 72:51–59
Rose GD, Foster KL (1989) Drag reduction and rheological properties of cationic viscoelastic surfactant formulations. J Non-Newtonian Fluid Mechanics 31:59–85
Shaqfeh ESG, Mullet SJ, Larson RG (1992) The effects of gap width and dilute solution properties on the viscoelastic Taylor-Couette instability. J Fluid Mech 235:285–317
Shenoy AV (1984) A review on drag reduction with special reference to micellar systems. Colloid Polymer Sci 262:319–337
Wunderlich I, Hoffmann H, Rehage H (1987) Flow birefringence and theological measurements on shear induced micellar structures. Rheol Acta 26:532–542
Wunderlich AM, Brunn PO (1989) The complex theological behavior of an aqueous cationic surfactant solution investigated in a Couette-type viscometer. Colloid Polym Sci 267:627–636
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Hu, Y., Matthys, E.F. Characterization of micellar structure dynamics for a drag-reducing surfactant solution under shear: normal stress studies and flow geometry effects. Rheola Acta 34, 450–460 (1995). https://doi.org/10.1007/BF00396558
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF00396558